3M, INDUSTRIAL TAPE AND SPECI -- SCOTCH SEAL 800 INDUSTRIAL SEALANT
=======================================================
Material Safety Data Sheet
=======================================================
NIIN: 01-440-4359
MSDS Num: CLFFL
MSDS NAME: SCOTCH SEAL 800 INDUSTRIAL SEALANT
Responsible Party
Name: 3M, INDUSTRIAL TAPE AND SPECIALTIES DIVISION
Address: 3M CENTER
City: ST PAUL MN 55144-1000
Info Phone: 1-800-364-3577
Emergency Phone Number: 651-737-650; 800-364-3577
Resp. Party Other MSDS No.: 10-3117-8
Review Ind: Y
Published: Y
=======================================================
Contractor Summary
=======================================================
Name: MINNESOTA MINING & MFG CO INDUSTRIAL TAPE & SPECIALTIES DIV
Address: 3M CENTER
City: ST PAUL MN 55144-1000
Phone: 1-800-364-3577
=======================================================
Item Description Information
=======================================================
=======================================================
Ingredients
=======================================================
Cas: 78-93-3
RTECS #: EL6475000
Name: METHYL ETHYL KETONE
% low Wt: 40.
% high Wt: 50.
OSHA PEL: 200 PPM
OSHA STEL: 300 PPM
ACGIH TLV: 200 PPM
ACGIH STEL: 300 PPM
EPA Rpt Qty: 5000 LBS
DOT Rpt Qty: 5000 LBS
------------------------------
Cas: 9003-18-3
Name: ACRYLONITRILE-BUTADIENE POLYMER
% low Wt: 10.
% high Wt: 20.
OSHA PEL: NONE
OSHA STEL: NONE
ACGIH TLV: NONE
ACGIH STEL: NONE
------------------------------
Cas: 8050-31-5
Name: GLYCEROL ESTERS OF ROSIN ACIDS
% low Wt: 10.
% high Wt: 20.
OSHA PEL: NONE
OSHA STEL: NONE
ACGIH TLV: NONE
ACGIH STEL: NONE
------------------------------
Cas: 471-34-1
RTECS #: FF9335000
Name: CALCIUM CARBONATE
% low Wt: 7.
% high Wt: 13.
ACGIH TLV: 10 MG/M3 TWA
------------------------------
Cas: 108-10-1
RTECS #: SA9275000
Name: METHYL ISOBUTYL KETONE
% low Wt: 3.
% high Wt: 7.
OSHA PEL: 50 PPM
OSHA STEL: 75 PPM
ACGIH TLV: 50 PPM
ACGIH STEL: 75 PPM
EPA Rpt Qty: 5000 LBS
DOT Rpt Qty: 5000 LBS
------------------------------
Cas: 78-51-3
RTECS #: KJ9800000
Name: TRI (BUTOXYETHYL) PHOSPHATE
% low Wt: 1.
% high Wt: 5.
OSHA PEL: NONE
OSHA STEL: NONE
ACGIH TLV: NONE
ACGIH STEL: NONE
------------------------------
Cas: 1327-39-5
Name: CALCIUM ALUMINUM SILICATE
% low Wt: 1.
% high Wt: 5.
OSHA PEL: NONE
OSHA STEL: NONE
ACGIH TLV: NONE
ACGIH STEL: NONE
------------------------------
Cas: 13463-67-7
RTECS #: XR2275000
Name: TITANIUM DIOXIDE
% low Wt: 1.
% high Wt: 5.
OSHA PEL: 10 MG/M3
ACGIH TLV: 10 MG/M3
------------------------------
Cas: 1309-37-1
RTECS #: NO7400000
Name: IRON OXIDE
% low Wt: 1.
% high Wt: 5.
OSHA PEL: 10 MG/M3 (AS FUME)
ACGIH TLV: 5 MG/M3 (AS FE)
------------------------------
Cas: 69-72-7
RTECS #: VO0525000
Name: SALICYLIC ACID
% low Wt: 1.
% high Wt: 5.
OSHA PEL: NONE
OSHA STEL: NONE
ACGIH TLV: NONE
ACGIH STEL: NONE
------------------------------
Cas: 1314-13-2
RTECS #: ZH4810000
Name: ZINC OXIDE
< Wt: 2.
Other REC Limits: SEE TOX SECTION.
OSHA PEL: 10 MG/M3 (AS DUST)
OSHA STEL: 10 MG/M3 (AS FUME)
ACGIH TLV: 10 MG/M3 (AS DUST)
ACGIH STEL: 10 MG/M3 (AS FUME)
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: EYE: MODERATE IRRITATION: SIGNS/SYMPTOMS CAN INCLUDE
REDNESS, SWELLING, PAIN, TEARING, & HAZY VISION. SKIN: MILD IRRITATION
(AFTER PROLONGED OR REPEATED CONTACT): SIGNS/SYMPTOMS CAN INCLUDE REDNESS, S
WELLING, ITCHING. INHALATION: CENTRAL NERVOUS SYSTEM DEPRESSION:
SIGNS/SYMPTOMS CAN INCLUDE HEADACHE, DIZZINESS, DROWSINESS, INCOORDINATION,
SLOWED REACTION TIME, SLURRED SPEECH, GIDDINESS & UNCONSCIO USNESS.
IRRITATION (UPPER RESPIRATORY): SIGNS/SYMPTOMS CAN INCLUDE SORENESS OF NOSE
& THROAT, COUGHING & SNEEZING. WHILE THE FOLLOWING EFFECTS ARE
ASSOCIATED WITH ONE OR MORE OF THE INDIVIDUAL INGREDI ENTS IN THIS PRODUCT
(EFTS OF OVEREXPOS)
Signs And Symptions Of Overexposure: HLTH HAZ (CONT'D): & ARE REQUIRED TO
BE INCLUDED ON THE MSDS BY THE U.S. OSHA HAZARD COMMUNICATION STANDARD, THEY
ARE NOT EXPECTED EFFECTS DURING FORESEEABLE USE OF THIS PRODUCT: KIDNEY
EFFECTS: SIGNS /SYMPTOMS CAN INCLUDE REDUCED URINE VOLUME, BLOOD IN URINE AND
BACK PAIN. LIVER EFFECTS: SIGNS/SYMPTOMS CAN INCLUDE YELLOW SKIN (JAUNDICE)
& TENDERNESS OF UPPER ABDOMEN. IF SWALLOWED: INGESTION MAY CA USE:
IRRITATION OF GASTROINTESTINAL TISSUES: SIGNS/SYMPTOMS CAN INCLUDE PAIN,
VOMITING, ABDOMINAL TENDERNESS, NAUSEA, BLOOD IN VOMITUS, & BLOOD IN
FECES. WHILE THE FOLLOWING EFFECTS ARE ASSOCIATED WIT H ONE OR MORE OF THE
(STATE REGULATORY)
First Aid: EYE CONTACT: IMMEDIATELY FLUSH EYES WITH LARGE AMOUNTS OF WATER. GET
IMMEDIATE MEDICAL ATTENTION. SKIN CONTACT: FLUSH SKIN WITH LARGE AMOUNTS OF
WATER. IF IRRITATION PERSISTS, GET MEDICAL ATTENTION. I NHALATION: REMOVE
PERSON TO FRESH AIR. IF NOT BREATHING, GIVE ARTIFICIAL RESPIRATION. IF
BREATHING IS DIFFICULT, GET IMMEDIATE MEDICAL ATTENTION. INGESTION: IF
SWALLOWED, CALL A PHYSICIAN IMMEDIATELY. ONLY INDUCE VOMITING AT THE
INSTRUCTION OF A PHYSICIAN. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS
PERSON.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: REFER TO OTHER SECTIONS OF THIS MSDS FOR INFORMATION
REGARDING PHYSICAL AND HEALTH HAZARDS, RESPIRATORY PROTECTION, VENTILATION,
AND PERSONAL PROTECTIVE EQUIPMENT. VENTILATE AREA. EXTINGUISH ALL IGNIT ION
SOURCES. COVER WITH ABSORBENT MATERIAL. COLLECT USING NON-SPARKING TOOLS.
PLACE IN A U.S. DOT-APPROVED CONTAINER.
Waste Disposal Methods: DISPOSE IN ACCORDANCE WITH ALL APPLICABLE FEDERAL,
STATE AND LOCAL REGULATIONS (FP N). INCINERATE IN A PERMITTED HAZARDOUS WASTE
INCINERATOR IN THE PRESENCE OF A COMBUSTIBLE MATERIAL. DISPOSE OF WASTE
PRODUCT IN A FACILITY PERMITTED TO ACCEPT CHEMICAL WASTE.
Handling And Storage Precautions: AVOID EYE CONTACT. AVOID SKIN CONTACT. USE IN
A WELL-VENTILATED AREA. AVOID PROLONGED BREATHING OF VAPORS. DO NOT INGEST.
KEEP CONTAINER CLOSED WHEN NOT IN USE. KEEP AWAY FROM HEAT, OPEN FLAME, AND
OT HER SOURCES OF IGNITION. GROUND CONTAINERS SECURELY WHEN TRANSFERRING
CONTENTS.KEEP (OTHER PREC)
Other Precautions: HANDLING/STORAGE (CONT'D): WEAR APPROPRIATE GLOVES WHEN
HANDLING THIS MATERIAL. KEEP CONTAINER TIGHTLY CLOSED. LOW STATIC OR
PROPERLY GROUNDED SHOES. KEEP OUT OF THE REACH OF CHILDREN
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point: =-6.5C, 20.F
Autoignition Temp Text: N/D
Lower Limits: CA. 1.4%
Upper Limits: 11.5%
Extinguishing Media: CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures: WEAR FULL PROTECTIVE CLOTHING, INCLUDING HELMET,
NIOSH APPROVED (FP N) SELF-CONTAINED POSITIVE PRESSURE OR PRESSURE DEMAND
BREATHING APPARATUS, BUNKER COAT AND PANTS, BANDS AROUND ARMS, WAIST AND LEGS
, FACE MASK, AND PROTECTIVE COVERING FOR EXPOSED AREAS OF THE HEAD.
Unusual Fire/Explosion Hazard: CLOSED CONTAINERS EXPOSED TO HEAT FROM FIRE MAY
BUILD PRESSURE & EXPLODE. VAPORS MAY TRAVEL LONG DISTANCES ALONG GROUND
OR FLOOR TO IGNITION SOURCE & FLASH BACK. FLAMMABLE LIQUID. KEEP
CONTAINER TIGHT LY CLOSED. NFPA HAZARD CODES: HEALTH-2, FIRE-3, REACTIVITY-0.
UNUSUAL REACTION HAZARD: NONE. FLAMMABLE LIQUID & VAPOR.
=======================================================
Control Measures
=======================================================
Respiratory Protection: SELECT ONE OF THE FOLLOWING NIOSH APPROVED RESPIRATORS
BASED ON AIRBORNE CONCENTRATION OF CONTAMINANTS AND IN ACCORDANCE WITH OSHA
REGULATIONS: HALF-MASK ORGANIC VAPOR RESPIRATOR.
Ventilation: SUFFICIENT VENTILATION TO MAINTAIN EMISSIONS BELOW RECOMMENDED
EXPOSURE LIMITS. IF EXHAUST VENTIALTION IS NOT ADEQUATE, USE APPROPRIATE
REPIRATORY PROTECTION.
Protective Gloves: GLOVES MADE FROM BUTYL RUBBER, POLYETHYLENE/ETHYLENE VINYL
(SUPP SFTY)
Eye Protection: ANSI APPROVED CHEMICAL SAFETY GOGGLES (FP N). WEAR VENTED
GOGGLES. (SUPP SAFTY)
Other Protective Equipment: EYEWASH AND DELUGE SHOWER MEETING ANSI DESIGN
CRITERIA (FP N).
Supplemental Safety and Health: (GLOVES, CONT'D) ALCOHOL,
POLYTETRAFLUOROETHYLENE (TEFLON) ARE RECOMMENDED. EYE PROTECTION: WEAR SAFETY
GLASSES WITH SIDESHIELDS. (MFR)
=======================================================
Physical/Chemical Properties
=======================================================
Boiling Point: =79.4C, 175.F
B.P. Text: CA. 175F MEK.
M.P/F.P Text: N/D
Vapor Pres: CA. 80 MMHG @ 68F.
Vapor Density: 2.5 AIR=1.
Spec Gravity: CA. 1.04 WATER=1.
PH: N/D
Viscosity: CA. 28700 CENTIPOISE.
Evaporation Rate & Reference: CA. 2.7. WATER=1.
Solubility in Water: SLIGHT.
Appearance and Odor: REDDISH-BROWN, HEAVY SYRUP - KETONE ODOR.
Percent Volatiles by Volume: CA 47% BY WT
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: STABLE.
Materials To Avoid: STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products: CARBON MONOXIDE AND CARBON DIOXIDE, OXIDES OF
NITROGEN, HYDROGEN CYANIDE, ALDEHYDES, KETONES, HYDROCARBONS, OXIDES OF ZINC.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: WILL NOT OCCUR.
=======================================================
Toxicological Information
=======================================================
Toxicological Information: EXPOSURE LIMITS: ZINC OXIDE (AS FUME): ACGIH TWA=5
MG/M3. OSHA TWA=5 MG/M3. NO SUBSTANCES OF THIS MATERIAL ARE POTENTIAL
CONTRIBUTORS TO THE OVERALL EXPOSURE BY THE CUTANEOUS ROUTE INCLUDING MUCOUS
MEMBRANE AND EYE., EITHER BY AIRBORNE OR, MORE PARTICULARLY, BY DIRECT
CONTACT WITH THE SUBSTANCE. VEHICLES CAN ALTER SKIN ABSORPTION.
=======================================================
Ecological Information
=======================================================
Ecological: NOT DETERMINED.
=======================================================
MSDS Transport Information
=======================================================
=======================================================
Regulatory Information
=======================================================
Sara Title III Information: THIS PRODUCT CONTAINS THE FOLLOWING TOXIC CHEMICALS
SUBJECT TO THE REPORTING REQUIREMENTS OF SECTION 313 OF TITLE III OF THE
EMERGENCY PLANNING AND COMMUNITY RIGHT-TO-KNOW ACT OF 1986 AND 40 CFR PART
372: METHYL ETHYL KETONE, METHYL ISOBUTYL KETONE, TRI (BUTOXYETHYL)
PHOSPHATE, AND ZINC OXIDE.
Federal Regulatory Information: VOLATILE ORGANIC COMPOUNDS: CA. 584 GMS/LITER
CALCULATED PER SCAQMD RULE 443.1. VOLATILE ORGANIC COMPOUNDS: CA. 47%.
VOLATILE ORGANIC COMPOUNDS: CA. 4.06 LB/GAL. VOC LESS H2*O & EXEMPT
SOLVENTS: CA. 4 86 GMS/LITER CALCULATED PER SCAQMD RULE 443.1. SINCE
REGULATIONS VARY, CONSULT APPLICABLE REGULATIONS OR AUTHORITIES BEFORE
DISPOSAL. U.S. EPA HAZARDOUS WASTE NUMBER = D001. (IGNITABLE). EPCRA HAZARD
CLASS: FIRE HAZARD: YES. PRESSURE: NO. REACTIVITY: NO. ACUTE: YES. CHRONIC:
YES.
State Regulatory Information: N/P. SIGNS/SYMPS OF OVEREXPOSURE (CONT'D):
INDIVIDUAL INGREDIENTS IN THIS PRODUCT & ARE REQUIRED TO BE INCLUDED ON
THE MSDS BY THE U.S. OSHA HAZARD COMMUNICATION STANDARD, THEY ARE NOT
EXPECTED EFFECT S DURING FORESEEABLE USE OF THIS PRODUCT. INGESTION MAY
CAUSE: CENTRAL NERVOUS SYSTEM DEPRESSION: SIGNS/SYMPS CAN INCLUDE HEADACHE,
DIZZINESS, DROWSINESS, MUSCULAR WEAKNESS, INCOORDINATION, SLOWED REA CTION
TIME, FATIGUE, BLURRED VISION, SLURRED SPEECH, GIDDINESS TREMORS &
CONVULSIONS. ASPIRATION PNE UMONITIS: SIGNS/SYMPS CAN INCLUDE COUGHING,
DIFFICULTY BREATHING, WHEEZING, COUGHING UP BLOOD, & PNEUMONIA, WHICH CAN
BE FATAL.
=======================================================
Other Information
=======================================================
Other Information: ID NUMBER/U.P.C.: 62-0800-0635-6 00-21200-85871-0,
62-0800-2631-3 00-21200-19674-4, 62-0800-2635-4, 62-0800-7530-2
00-21200-19677-5, 62-0800-8530-1 00-21200-19678-9, 62-0800-9530-0
00-21200-19681-2, 6 2-0800-9531-8, XS-0414-0879-9. SUPERCEDES MSDS OF 9-5-96.
=======================================================
HAZCOM Label
=======================================================
MSDS NAME: SCOTCH SEAL 800 INDUSTRIAL SEALANT
Company: MINNESOTA MINING & MFG CO INDUSTRIAL TAPE & SPECIALTIES
DIV
Street: 3M CENTER
City: ST PAUL MN
Zipcode: 55144-1000
Health Emergency Phone: 651-737-650; 800-364-3577
Label Required IND: Y
Date Of Label Review: 06/18/2001
Status Code: A
Origination Code: G
Hazard And Precautions: EYE: MODERATE IRRITATION: SIGNS/SYMPTOMS CAN INCLUDE
REDNESS, SWELLING, PAIN, TEARING, & HAZY VISION. SKIN: MILD IRRITATION
(AFTER PROLONGED OR REPEATED CONTACT): SIGNS/SYMPTOMS CAN INCLUDE REDNESS, S
WELLING, ITCHING. INHALATION: CENTRAL NERVOUS SYSTEM DEPRESSION:
SIGNS/SYMPTOMS CAN INCLUDE HEADACHE, DIZZINESS, DROWSINESS, INCOORDINATION,
SLOWED REACTION TIME, SLURRED SPEECH, GIDDINESS & UNCONSCIO USNESS.
IRRITATION (UPPER RESPIRATORY): SIGNS/SYMPTOMS CAN INCLUDE SORENESS OF NOSE
& THROAT, COUGHING & SNEEZING. WHILE THE FOLLOWING EFFECTS ARE
ASSOCIATED WITH ONE OR MORE OF THE INDIVIDUAL INGREDI ENTS IN THIS PRODUCT
(EFTS OF OVEREXPOS)
=======================================================
Disclaimer (provided with this information by the compiling agencies): This
information is formulated for use by elements of the Department of Defense.
The United States of America in no manner whatsoever expressly or implied
warrants, states, or intends said information to have any application, use or
viability by or to any person or persons outside the Department of Defense
nor any person or persons contracting with any instrumentality of the United
States of America and disclaims all liability for such use. Any person
utilizing this instruction who is not a military or civilian employee of the
United States of America should seek competent professional advice to verify
and assume responsibility for the suitability of this information to their
particular situation regardless of similarity to a corresponding Department
of Defense or other government situation.
*** END OF RECORD *** |
|
|