DEFT, INC. -- MIL-PRF-85285C (MIL-C-85285B), 03GY274CAT1644
=======================================================
Material Safety Data Sheet
=======================================================
MSDS Num: CLFHQ
MSDS NAME: MIL-PRF-85285C (MIL-C-85285B), 03GY274CAT16440
Responsible Party
Name: DEFT, INC.
Address: 17451 VON KARMAN AVENUE
City: IRVINE CA 92614
Info Phone: 949-474-0400
Emergency Phone Number: 800-424-9300
Preparer's Name: MIKE SMITH
Chemtrec IND/Phone: (800)424-9300
Review Ind: Y
Published: Y
=======================================================
Contractor Summary
=======================================================
Name: DEFT, INC.
Address: 17451 VON KARMAN AVE
City: IRVINE CA 92614
Phone: 949-474-0400
=======================================================
Ingredients
=======================================================
Cas: 3779-63-3
Name: ALIPHATIC ISOCYANATE
Percent by Wt: 40.
OSHA PEL: NOT ESTABLISHED
OSHA STEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
ACGIH STEL: NOT ESTABLISHED
------------------------------
Cas: 822-06-0
RTECS #: MO1740000
Name: HEXAMETHYLENE DIISOCYANATE (HDI). (FREE MONOMER CONTENT AVERAGE 0.10%
BASED ON RESIN SOLIDS AT TIME OF MANUFACTURE. AFTER 12 MONTHS STORAGE, THE
FREE MONOMER CONTENT MAY RISE TO A MAXIMUM OF 0.14%.)
% low Wt: .1
% high Wt: .14
ACGIH TLV: 0.005 PPM
EPA Rpt Qty: 1 LB
DOT Rpt Qty: 1 LB
------------------------------
Cas: 64742-95-6
RTECS #: WF3400000
Name: C8&10 AROMATIC HYDROCARBON
< Wt: 5.
Other REC Limits: DEFT: PEL 100 PPM.
OSHA PEL: NOT ESTABLISHED
OSHA STEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
ACGIH STEL: NOT ESTABLISHED
------------------------------
Cas: 123-86-4
RTECS #: AF7350000
Name: N-BUTYL ACETATE
< Wt: 5.
OSHA PEL: 150 PPM
OSHA STEL: 200 PPM
ACGIH TLV: 150 PPM
ACGIH STEL: 200 PPM
EPA Rpt Qty: 5000 LBS
DOT Rpt Qty: 5000 LBS
------------------------------
Cas: 107-87-9
RTECS #: SA7875000
Name: METHYL N-PROPYL KETONE
Percent by Wt: 45.
OSHA PEL: 200 PPM
OSHA STEL: 250 PPM
ACGIH TLV: 200 PPM
ACGIH STEL: 250 PPM
------------------------------
Cas: 763-69-9
RTECS #: UF3325000
Name: ETHYL 3-ETHOXYPROPIONATE
Percent by Wt: 5.
Other REC Limits: SEE TOXICOLOGICAL
OSHA PEL: NOT ESTABLISHED
OSHA STEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
ACGIH STEL: NOT ESTABLISHED
------------------------------
Cas: 1119-40-0
Name: DIBASIC ESTER
< Wt: 5.
Other REC Limits: DEFT AEL: 10 MG/M3
OSHA PEL: NOT ESTABLISHED
OSHA STEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
ACGIH STEL: NOT ESTABLISHED
------------------------------
Cas: 627-93-0
RTECS #: AV1645000
Name: ADIPIC ACID, DIMETHYL ESTER. (FP N)
< Wt: 5.
Other REC Limits: DEFT AEL: 10 MG/M3
OSHA PEL: NOT ESTABLISHED
OSHA STEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
ACGIH STEL: NOT ESTABLISHED
------------------------------
Cas: 106-65-0
RTECS #: WM7675000
Name: BUTANEDIOIC ACID, DIMETHYL ESTER. (FP N)
< Wt: 5.
Other REC Limits: DEFT AEL: 10 MG/M3
OSHA PEL: NOT ESTABLISHED
OSHA STEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
ACGIH STEL: NOT ESTABLISHED
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: VAPORS ARE IRRITATING TO EYES, NOSE, AND THROAT.
INHALATION MAY CAUSE HEADACHES, DIFFICULT BREATHING AND LOSS OF
CONSCIOUSNESS. CHRONIC: AS A RESULT OF PREVIOUS REPEATED OVEREXPOSURE OR A
SINGL E LARGE DOSE, CERTAIN INDIVIDUALS WILL DEVELOP ISOCYANATE SENSITIZATION
WHICH WILL CAUSE THEM TO REACT TO A LATER EXPOSURE OF ISOCYANATE LEVELS WELL
BELOW THE TLV OF ISOCYANATES. SIGNS AND SYMPT OMS OF OVEREXPOSURE
(CONT): INGESTION: ACUTE: CAN RESULT IN IRRITATION AND POSSIBLE CORROSIVE
ACTION IN THE MOUTH, STOMACH TISSUE AND DIGESTIVE TRACT. VOMITING MAY CAUSE
ASPIRATION OF THE SOLVENT, RES ULTING IN CHEMICAL PNEUMONITIS.
Signs And Symptions Of Overexposure: INHALATION: IRRITATION OF THE RESPIRATORY
TRACT & ACUTE NERVOUS SYSTEM DEPRESSION CHARACTERIZED BY THE FOLLOWING
PROGRESSIVE STEPS: HEADACHE, DIZZINESS, STAGGERING GAIT, CONFUSION,
UNCONSCIOUSNESS OR COMA. SKIN CONTACT: ISOCYANATES REACT WITH SKIN PROTEIN
AND MOISTURE AND CAN CAUSE IRRITATION. SYMPTOMS MAY BE SWELLING, REDNESS, AND
RASH. SKIN ABSORPTION: PROLONGED OR REPEATED CONTACT CAN CAUSE MOD ERATE
IRRITATION, DRYING, AND DEFATTING OF THE SKIN WHICH CAN CAUSE THE SKIN TO
CRACK. EYE CONTACT: LIQUID, AEROSOL, OR VAPORS ARE IRRITATING AND MAY CAUSE
TEARING, REDNESS, AND SWELLING ACCOMPANIED B Y A STINGING SENSATION. (HEALTH
HAZARDS)
Medical Cond Aggravated By Exposure: ASTHMA AND ANY OTHER RESPIRATORY
DISORDERS. SKIN ALLERGIES, ECZEMA, AND DERMATITIS. ISOCYANATE SENSITIZATION.
First Aid: INHALATION: MOVE TO AN AREA FREE FROM RISK OF FURTHER EXPOSURE.
RESTORE BREATHING. ASTHMATIC TYPE SYMPTOMS MAY DEVELOP AND MAY BE IMMEDIATE
OR DELAYED BY SEVERAL HOURS. OBTAIN MEDICAL ATTENTION. SKIN. REMOVE
CONTAMINATED CLOTHING. WASH AFFECTED AREAS THOROUGHLY WITH SOAP AND WATER.
WASH CONTAMINATED CLOTHING THOROUGHLY BEFORE REUSE. EYES: FLUSH WITH CLEAN
LUKEWARM WATER (LOW PRESSURE) FOR AT LEAST 15 MINUTES, OCCASIONALLY LIFTING
EYELIDS. OBTAIN MEDICAL ATTENTION. INGESTION: DO NOT INDUCE VOMITING. DO NOT
GIVE ANYTHING TO AN UNCONSCIOUS PERSON. OBTAIN MEDICAL ATTENTION.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: EVACUATE ALL NON-ESSENTIAL PERSONNEL. REMOVE ALL
SOURCES OF IGNITION (FLAME, SPARK SOURCES, HOT SURFACES). VENTILATE AREA.
CONTAIN AND REMOVE WITH INERT ABSORBENT AND NON-SPARKING TOOLS.
Waste Disposal Methods: WASTE MUST BE DISPOSED OF IN ACCORDANCE WITH FEDERAL,
STATE, AND LOCAL ENVIRONMENTAL CONTROL REGULATIONS. EMPTY CONTAINERS MUST BE
HANDLED WITH CARE, DUE TO PRODUCT RESIDUE AND FLAMMABLE VAPOR. DO NOT
INCINERATE CLOSED CONTAINERS. ALSO SEE FIRE HAZARD, HEALTH HAZARD, AND
REACTIVITY SECTIONS FOR OTHE R PRECAUTIONS. EPA HAZARDOUS (ECOLOGICAL INFO)
Handling And Storage Precautions: STORE IN BUILDINGS DESIGNED TO COMPLY WITH
OSHA 1910,106. AVOID STORING NEAR HIGH TEMPS, FIRE, OPEN FLAMES AND SPARK
SOURCES. STORE IN TIGHTLY CLOSED CONTAINERS. STORE IN WELL VENTILATED AREAS.
OT HER PRECAUTIONS: WASH HANDS BEFORE EATING, SMOKING, OR USING WASHROOM.
SMOKE IN SMOKING AREAS ONLY.
Other Precautions: KEEP CONTAINERS TIGHT AND UPRIGHT TO PREVENT LEAKAGE.
PREVENT PROLONGED BREATHING OF VAPORS OR SPRAY MISTS. PROLONGED OVEREXPOSURE
MAY CAUSE AN ALLERGIC REACTION. AVOID CONTACT WITH SKIN AND EYES. DO NOT
TAKE INTERNALLY. DO NOT HANDLE UNTIL THE MANUFACTURERS SAFETY PRECAUTIONS
HAVE BEEN READ AND UND ERSTOOD.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: TCC
Flash Point: =7.8C, 46.F
Autoignition Temp Text: NO INF
Lower Limits: 0.90%.
Upper Limits: 8.00%.
Extinguishing Media: FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG, WATER
SPRAY. FLAMMABILITY CLASS: 1B. FIRE FIGHTING PROC (CONT): VAPORS MAY BE
GENERATED BY COMBUSTION OR THERMAL DECOMPOSITION.
Fire Fighting Procedures: FULL FIRE FIGHTING EQUIPMENT WITH (NIOSH APPROVED, FP
N) SELF-CONTAINED BREATHING APPARATUS AND FULL PROTECTIVE CLOTHING SHOULD BE
WORN BY FIRE FIGHTERS. WATER MAY BE USED TO COOL CLOSED CONTAINERS TO
PREVENT PRESSURE BUILD-UP, AUTO IGNITION OR EXPLOSION. DURING A FIRE HDI
VAPORS AND OTHER IRRITATING (EXTING MEDIA)
Unusual Fire/Explosion Hazard: KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE FROM
HEAT, SPARKS, ELECTRICAL EQUIPMENT AND OPEN FLAME. CLOSED CONTAINERS MAY
EXPLODE WHEN EXPOSED TO EXTREME HEAT. APPLICATION TO HOT SURFACES REQURIES
SPECIAL PRECAUTIONS. DURING EMERGENCY CONDITIONS OVEREXPOSURE TO
DECOMPOSITION PRODUCTS MAY CAUSE A HEALTH HAZARD. (OTHER INFO)
=======================================================
Control Measures
=======================================================
Respiratory Protection: A NIOSH APPROVED (FP N) RESPIRATOR THAT IS RECOMMENDED
OR APPROVED FOR USE IN AN ORGANIC VAPOR ENVIRONMENT (AIR PURIFYING OR FRESH
AIR SUPPLIED) IS NECESSARY. OBSERVE OSHA REGULATIONS FOR RESPIRATOR U SE.
VENTILATION SHOULD BE PROVIDED TO KEEP EXPOSURE LEVELS BELOW THE OSHA
PERMISSIBLE LIMITS. AN AIR SUPPLIED RESPIRATOR IS (SUPPLEMENTAL SAFETY AND
HEALTH)
Ventilation: EXHAUST VENTILATION SUFFICIENT TO KEEP THE AIRBORNE CONCENTRATIONS
OF SOLVENT, HDI AND POLYISOCYANATES BELOW THEIR RESPECTIVE (SUPPLEMENTAL
SAFETY & HEALTH)
Protective Gloves: COTTON, NEOPRENE, RUBBER, POLYETHYLENE PROTECTIVE GLOVES TO
PREVENT SKIN CONT.
Eye Protection: ANSI APPROVED CHEMICAL SAFETY GOGGLES AND FULL FACESHIELD (FP
N).
Other Protective Equipment: EYEWASH AND DELUGE SHOWER MEETING ANSI DESIGN
CRITERIA (FP N). THE USE OF LONG SLEEVE AND LONG LEG CLOTHING IS RECOMMENDED.
Work Hygienic Practices: REMOVE AND WASH CONTAMNATED CLOTHING THOROUGHLY BEFORE
REUSE. WASH HANDS BEFORE EATING, SMOKING, OR USING WASHROOM.
Supplemental Safety and Health: RESPIRATORY PROTECTION (CONT): RECOMMENDED. A
VAPOR PARTICULATE RESPIRATOR (TC23C NIOSH) MAY BE APPROPRIATE WHERE AIR
MOMNITORING DEMONSTRATES VAPOR LEVELS BELOW TEN TIMES THE APPLICABLE EXPOSURE
LI MITS. VENTILATION (CONT): TLV'S MUST BE UTILIZED. REMOVE ALL IGNITION
SOURCES (HEAT, SPARKS, FLAME, HOT SURFACES).
=======================================================
Physical/Chemical Properties
=======================================================
Boiling Point: =100.6C, 213.F
B.P. Text: 213 - 437 F.
Decomp Text: NO INFORMATION FOUND.
Vapor Density: >THAN AIR.
Spec Gravity: 0.94958
VOC Grams/Liter: 550
Viscosity: SEE OTHER INFO.
Evaporation Rate & Reference: 1.49 X N-BUTYL ACETATE.
Solubility in Water: INSOLUBLE.
Appearance and Odor: AMBER LIQUID WITH SOLVENT ODOR.
Percent Volatiles by Volume: 65.8%
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: CONTACT WITH MOISTURE, MATERIAL WHICH REACT WITH
ISOCYANATES AND HIGH TEMPERATURES.
Materials To Avoid: WATER, AMINES, STRONG BASES, ALCOHOLS, METAL COMPOUNDS AND
SURFACE ACTIVE MATERIALS.
Hazardous Decomposition Products: BY HIGH HEAT/TEMPERATURE: CARBON MONOXIDE,
CARBON DIOXIDE, AND OXIDES OF NITROGEN, TRACES OF HCN AND HDI.
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
Toxicological Information: N/P. INGREDIENTS (CONT): OTHER
RECOMMENDED LIMIT: ETHYL 3-ETHOXYPROPIONATE: MANUFACTURER RECOMMENDS A
WORKPLACE EXPOSURE LIMIT OF 50 PPM-TWA; 100 PPM-STEL.
=======================================================
Ecological Information
=======================================================
Ecological: N/P. WASTE DISPOSAL (CONT): WASTE NUMBER / CODE: D001, F003,
F005. HAZARDOUS WASTE CHARACTERISTICS: IGNITABILITY: YES. CORROSIVITY: NO.
REACTIVITY: YES.
=======================================================
MSDS Transport Information
=======================================================
=======================================================
Regulatory Information
=======================================================
Sara Title III Information: SARA 313: THIS PRODUCT CONTAINS THE FOLLOWING TOXIC
CHEMICALS SUBJECT TO THE REPORTING REQUIREMENTS OF SECTION 313 OF THE
EMERGENCY PLANNING AND COMMUNITY RIGHT TO KNOW ACT OF 1986 AND OF 40 CFR 372:
NONE.
Federal Regulatory Information: TSCA: ALL INGREDIENTS LISTED IN THE INGREDIENTS
SECTION OF THIS MSDS ARE ON THE TSCA INVENTORY LIST. ANY UNLISTED INGREDIENTS
ARE ON THE TSCA INVENTORY LIST.
State Regulatory Information: PROP 65-CARCINOGENIC: WARNING: THIS PRODUCT
CONTAINS A CHEMICAL KNOWN TO THE STATE OF CALIFORNIA TO CAUSE CANCER: NONE.
PROP 65-TERATOGENIC: WARNING: THIS PRODUCT CONTAINS A CHEMICAL KNOWN TO THE
ST ATE OF CALIFORNIA TO CAUSE BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM: NONE.
PROP 65-CARCINOGENIC AND TERATOGENIC WARNING: THIS PRODUCT CONTAINS A
CHEMICAL KNOWN TO THE STATE OF CALIFORNIA TO CAUSE CAN CER OR BIRTH DEFECTS
OR OTHER REPRODUCTIVE HARM: NONE.
=======================================================
Other Information
=======================================================
Other Information: PRODUCT CLASS: TYPE 1, ALIPHATIC ISOCYANATE. C.A.S NUMBER:
NONE. HAZARD RATINGS: HEALTH-4, FIRE-3, REACTIVITY-1. KEY: NONE ->
EXTREME; 0--->4. PHYSICAL / CHEMICAL PROPERTIES (CONT): VISCOSITY:
THIN LIQUID TO HEAVY VISCOUS MATERIAL. LIQUID DENSITY: LIGHTER THAN WATER.
VOLATILES WGT%: 58.0. WGT PER GALLON: 7.91 POUNDS. AUTOIGNITION TEMPERATURE:
NO INFORMATION FOUND. CORROSION RATE: NO INFORM ATION FOUND. PREPARED BY
MIKE SMITH; TITLE: PROJECT LEADER. MSDS PRINTED DATE: 12/09/98. N.E. = NOT
ESTABLISHED. UNUSUAL FIRE & EXPLOSION HAZARDS (CONT): SYMPTOMS MAY
NOT BE IMMEDIATELY APPARENT.
=======================================================
HAZCOM Label
=======================================================
MSDS NAME: MIL-PRF-85285C (MIL-C-85285B), 03GY274CAT16440
Company: DEFT, INC.
Street: 17451 VON KARMAN AVE
City: IRVINE CA
Zipcode: 92614
Health Emergency Phone: 800-424-9300
Label Required IND: Y
Date Of Label Review: 06/19/2001
Status Code: A
Origination Code: F
Chronic Hazard IND: Y
Eye Protection IND: YES
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: Severe
Reactivity Hazard: Slight
Hazard And Precautions: ACUTE: VAPORS ARE IRRIT TO EYES, NOSE, THROAT. INHAL:
IRRIT OF RESP TRACT & ACUTE NERV SYS DEPRESS: HEADACHE, DIZZ, STAGGERING,
CONFUSION, UNCONSCIOUSNESS, COMA. SKIN: ISOCYANATES CAN CAUSE IRRIT, SWE
LLING, RASH. SKIN ABSORPT: CAN CAUSE MODERATE IRRIT, SK
=======================================================
Disclaimer (provided with this information by the compiling agencies): This
information is formulated for use by elements of the Department of Defense.
The United States of America in no manner whatsoever expressly or implied
warrants, states, or intends said information to have any application, use or
viability by or to any person or persons outside the Department of Defense
nor any person or persons contracting with any instrumentality of the United
States of America and disclaims all liability for such use. Any person
utilizing this instruction who is not a military or civilian employee of the
United States of America should seek competent professional advice to verify
and assume responsibility for the suitability of this information to their
particular situation regardless of similarity to a corresponding Department
of Defense or other government situation.
*** END OF RECORD *** |
|
|