===================== Product Identification =====================
MSDS NAME:ND 30, 26500012
NIIN:00N069709
MSDS Number: CBKSL
=== Responsible Party ===
Company:VALVOLINE INC
Box:14000
City:LEXINGTON
State:KY
ZIP:40512
Country:US
Info Phone Num:606-264-7000
Emergency Phone Num:800-274-5263
CAGE:GO029
=== Contractor Identification ===
Company:VALVOLINE INC
Box:14000
City:LEXINGTON
State:KY
ZIP:40512
Phone:(606) 268-7000
CAGE:GO029
Company:VALVOLINE OIL CO
Address:3499 BLAZER PKY
Box:14000
City:LEXINGTON
State:KY
ZIP:40512
Country:US
Phone:606-357-7206 / 800-274-5263
CAGE:72527
============= Composition/Information on Ingredients =============
Name:MINERAL OIL, PETROLEUM DISTILLATE, SOLVENT DEWAXED
(SEVERE), HEAVY PARAFFINIC; (PETROLEUM LUBE OIL)
CAS:64742-65-0
RTECS #:PY8038501
Fraction by Wt: 85-100%
OSHA PEL:5 MG/M3 (MFR)
ACGIH TLV:5 MG/M3 (MFR)
Name:SUP DAT: CLAY, EARTH, FLOOR ABSORBENT, OR OTHER ABSORBENT
MATERIAL AND SHOVELED INTO CONTAINERS.
RTECS #:9999999ZZ
Name:VENT: (GENERAL AND/OR LOCAL EXHAUST) VENTILATION TO
MAINTAIN EXPOSURE BELOW PEL/TLV.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES: NOT EXPECTED TO CAUSE
IRRITATION DURING NORMAL CONDITIONS OF USE. SKIN: PROLONGED OR
REPEATED CONTACT MAY BE MILDLY IRRITATING TO SKIN AND MAY CAUSE
DERMATITIS. INGESTION: NOT EXPECTED TO BE TOXIC BY INGESTION.
PRODUCT HAS LAXATIVE PROPERTIES AND MAY CAUSE NAUSEA, ABDOMINAL
CRAMPS AND (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: DIARRHEA. INHALATION: NOT EXPECTED TO
BE AN INHALATION HAZARD AT NORMAL ROOM TEMPERATURE. HOWEVER, IF
EXPOSURES EXCEED THE PEL/TLV OF 5 MG/M3 FOR OIL MIST, THEN
INHALATION OF MIST MAY RESULT IN RESPIRATORY IRRITATION AND
POSSIBLEDISCOMFORT.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:SKIN: THORO WASH EXPOSED AREA W/SOAP & WATER. REMOVE CONTAM
CLTHG & LAUNDER BEFORE REUSE. EYES: FLUSH W/LGE AMTS OF WATER,
LIFTING UPPER & LOWER LIDS OCCAS. GET MED ATTN IF IRRIT PERSISTS.
INGEST: DO NOT INDUCE VOMIT. KEEP PERS WARM & QUIET, & GET MED
ATTN. INHAL: REMOVE TO FRESH AIR. IF BRTHG IS DFCLT, ADMIN OXYGEN.
IF BRTHG HAS STOPPED GIVE ARTF RESP. KEEP PERS WARM, QUIET & GET
MED ATTN.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:>430F,>221C
Extinguishing Media:USE REGULAR FOAM, CARBON DIOXIDE OR DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. WATER/FOAM MAY CAUSE FROTHING WHICH CAN BE VIOLENT & POSS
ENDANGER LIFE OF FIREFIGHTER, ESP IF (SUP DAT)
Unusual Fire/Explosion Hazard:NEVER USE WELDING OR CUTTING TORCH ON OR
NEAR DRUM (EVEN EMPTY) BECAUSE PRODUCT (EVEN JUST RESIDUE) CAN
IGNITE EXPLOSIVELY.
================== Accidental Release Measures ==================
Spill Release Procedures:SML SPILL: ABSORB LIQ ON VERMICULITE, FLOOR
ABSORB/OTHER ABSORB MATL. LGE SPILL: PVNT RUN-OFF TO SEWER,
STREAMS/OTHER BODIES OF WATER. IF RUN-OFF OCCURS, NOTIFY PROPER
AUTH AS REQ, THAT A SPILL HAS OC CURRED. PERS NOT WEARING PROT
EQUIP (SUP DAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
====================== Handling and Storage ======================
Handling and Storage Precautions:AVOID PROLONGED OR REPEATED CONTACT TO
SKIN. CONTAINERS OF THIS MATERIAL MAY BE HAZARDOUS WHEN EMPTIED.
Other Precautions:SINCE EMPTIED CONTAINERS RETAIN PRODUCT RESIDUES
(VAPOR, LIQUID AND/OR SOLID), ALL HAZARD PRECAUTIONS GIVEN IN THIS
MSDS MUST BE OBSERVED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED UNDER NORMAL CONDITIONS OF USE.
HOWEVER, IF OIL MISTS ARE GENERATED ABOVE RECOMMENDED PEL/TLV OF 5
MG/M3, THEN A NIOSH/MSHA APPROVED RESP IS ADVISED IN ABSENCE OF
PROPER ENVIRONMENTAL CON TROL. (SEE YOUR SAFETY EQUIP SUPPLIER.)
Ventilation:NOT REQ UNDER NORM CNDTNS OF USE. HOWEVER, IF UNUSUAL
OPERATING CNDTNS EXIST, THEN PROVIDE SUFFICIENT MECHANICAL (ING 3)
Protective Gloves:NITRILE RUBBER.
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGS .
Other Protective Equipment:NORMAL WORK CLOTHING COVERING ARMS & LEGS.
EMERGENCY EYEWASH & DELUGE SHOWER MEETING ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRE FIGHT PROC: SPRAYED INTO CONTRS OF HOT, BURNING LIQ. DENSE SMOKE
MAY BE GENETATED WHILE BURNING. SPILL PROC: SHOULD BE EXCLUDED FROM
AREA OF SPILL UNTIL CLEAN-UP HAS BEEN COMPLETED. STOP SPILL AT
SOURCE, DIKE AREA OF SPILL TO PVNT SPREADING, PUMP LIQ TO SALVAGE
TANK. REMAINING LIQ MAY BE TAKEN UP ON SAND, (ING 2)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:575F,302C
Vapor Density:HVR/AIR
Spec Gravity:0.889
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:LIGHT AMBER LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:SMALL SPILL/LARGE SPILL: DISPOSE OF IN
ACCORDANCE WITH ALL LOCAL, STATE AND FEDERAL REGULATIONS.
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.
*** END OF RECORD *** |
|