===================== Product Identification =====================
MSDS NAME:SKC-NF/ZC-7B CLEANER(POST 87-SEE SUPPL)
NIIN:00-782-2740
Kit Part:Y
MSDS Number: BFPPH
=== Responsible Party ===
Company:MAGNAFLUX CORPORATION
Address:7300 W.LAWRENCE AVENUE
City:CHICAGO
State:IL
ZIP:60656-3504
Country:US
Info Phone Num:312-867-8000
Emergency Phone Num:312-867-8000
Preparer's Name:BRUCE C. GRAHAM
CAGE:37676
=== Contractor Identification ===
Company:ILLINOIS TOOL WORKS INC MAGNAFLUX DIV
Address:3624 WEST LAKE AVENUE
Box:City:GLENVIEW
State:IL
ZIP:60025
Country:US
Phone:847-657-5300/
CAGE:37676
============= Composition/Information on Ingredients =============
Name:METHYL CHLOROFORM (1,1,1-TRICHLOROEHANE) (SARA III)
CAS:71-55-6
RTECS #:KJ2975000
Fraction by Wt: 95.0%
OSHA PEL:350 PPM/450 STEL
ACGIH TLV:350 PPM/450STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ozone Depleting Chemical:1
Name:1,4-DIOXANE (DIETHYLENE DIOXIDE) (SARA III)
CAS:123-91-1
RTECS #:JG8225000
Fraction by Wt: 01.0%
OSHA PEL:S, 100 PPM
ACGIH TLV:S, 25 PPM; 9293
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Name:CARBON DIOXIDE
CAS:124-38-9
RTECS #:FF6400000
Fraction by Wt: 05.0%
OSHA PEL:5000 PPM
ACGIH TLV:5000PPM/30000STEL;93
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:IRRITATES EYES BY SOLVENT ACTION.
Explanation of Carcinogenicity:1,1,1-TRICHLOROETHANE AND 1,4-DIOXANE
ARE CURRENTLY UNDER TEST TO DETERMINE THE POSSIBLE
CARCINOGENICITY,PER MFR.
Effects of Overexposure:INHALATION:CAUSES
DIZZINESS,DROWSINESS,NAUSEA.CAUSES UNCONSCIOUSNESS AT HIGH
EXPOSURE; SKIN:NOT ABSORBED THROUGH SKIN IN SIGNIFICANT
AMOUNTS.HOWEVER,IRRITATES BY DISSOLVING SKIN OILS; EYES:IRRITATING
DUE TO STRONG SOLVENT ACTION; INGESTION:LOW SINGLE DOSE TOXICITY IN
TEST ANIMALS.
Medical Cond Aggravated by Exposure:NONE KNOWN TO MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION:REMOVE TO FRESH AIR.IF NOT BREATHING,GIVE CPR.IF
BREATHING IS DIFFICULT,GIVE OXYGEN; SKIN:WASH OFF IN FLOWING WATER
OR SHOWER.RMV CONTAMINATED CLOTHING AND WASH BEFORE REUSE.USE
SOOTHING LO TION; EYES:FLUSH EYES WITH A STEADY,GENTLE FLOW OF
WATER.GET MEDICAL ASST; INGESTION:DO NOT INDUCE VOMITING.IF VOMIT
IS INHALED,IT MAY CAUSE ASPHYXIATION.GET MED ATTN IMMEDIATELY; IN
EMERGENCY CALL MD
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:CARBON DIOXIDE,FOAM
Fire Fighting Procedures:KEEP CONTAINERS COOL WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:AEROSOL CANS CAN BURST IF HEATED ABOVE
130F(54.4C);VAPORS PARTIALLY DECOMPOSE TO TOXIC GASES WHEN EXPOSED
TO FLAME,ARC OR RED HOT SURFACES.
================== Accidental Release Measures ==================
Spill Release Procedures:LESS THAN ONE QUART:WIPE UP BUT DO NOT BREATHE
VAPORS;ONE QUART OR MORE:WEAR ALL PERSONAL SAFETY EQUIPMENT TO
AVOID VAPOR/LIQ CONTACT OR BREATHING.EVACUATE UNPROTECTED
PERSONS.ELIMINATE IGN SOURCES.DI KE LIQ.PLACE IN COVERED DRUMS.SEND
TO RECLAIMER.
Neutralizing Agent:NOT NOTED BY MFR.
====================== Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM HEAT SOURCES TO
MINIMIZE THE DANGER FROM EXPOSURE TO FIRES.STORE IN
DRY,COOL,VENTILATED AREA.
Other Precautions:DO NOT USE AROUND FLAMES/RED HOT SURFACES.DO NOT HEAT
ABOVE 130F.AVOID BREATHING VAPORS.AVOID FREQUENT/PROLONGED EXPOSURE
TO SKIN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR RESPIRATOR WITH CHEMICAL CARTRIDGE.IN
CONFINED AREAS,WEAR A FULL MASK WITH SEPARATE AIR SUPPLY.
Ventilation:GENERAL VENTILATION TO KEEP BELOW 350PPM OF TLV LIMIT.
Protective Gloves:NITRILE RUBBER GLOVES
Eye Protection:FULL GOGGLES
Other Protective Equipment:USE IN SPRAY BOOTH OR NEXT TO AN EXHAUST
VENT TO CARRY VAPORS AWAY FROM OCCUPIED AREAS.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING MATERIAL.LAUNDER
CONTAMINATED CLOTHES BEFORE REUSE OF:CLEANER/REMOVER SKC-NF/ZC-7B
Supplemental Safety and Health
NSN WAS GROUP VII OF MIL-I-25135C & HAD 3 PARTS(SEE PNI A THRU D FOR
OLD PARTS);UNDER REV"D" OF SPEC,NSN BECAME TYPE I,METH C,LVL 3 &
STILL HAS 3 PARTS;I/A/W QPL-25135-15,PARTS ARE:DEVELOPR(ZP-9E NOT
ZP-9F),CLEANER(SKC-NF/ZC-7B),& PENETRANT(ZL-22D OR
ZL-27A);KEY1:J7;REF:DGSC-SLM CASE HISTORY #88281H;THIS IS
SKC-NF/ZC7B
================== Physical/Chemical Properties ==================
HCC:V2
Boiling Pt:B.P. Text:N/R(AEROSOL
Spec Gravity:1.3 (OF LIQUID)
Evaporation Rate & Reference:0.7 (ETHER=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR,COLORLESS,MOBILE LIQUID BEFORE FILLING IN
AEROSOL CANS.
Percent Volatiles by Volume:100%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
POWDERED ZINC AND ALUMINUM
Stability Condition to Avoid:HEAT/HIGH TEMPERATURES
Hazardous Decomposition Products:PHOSGENE,HYDROCHLORIC ACID GAS &
OXIDES OF CARBON
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF AS EPA HAZARDOUS WASTE #F002;MAY BE
SENT TO SOLVENT RECLAIMER.INSURE THAT AEROSOL CANS ARE EMPTY AND
DEPRESSURIZED BEFORE DISCARDING,UNLESS A WASTE TREATMENT FACILITY
IS APPROVED TO ACCEPT THEM AS IS.COMPLY WITH FED,ST,& LOCAL REGS.
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.
*** END OF RECORD *** |
|