=====================  Product Identification  =====================

MSDS NAME:ZP-9E,ZYGLO DEVELOPER (POST 87-SEE SUPPL)
NIIN:00-782-2740
Kit Part:Y
MSDS Number: BFPPG
=== Responsible Party ===
Company:MAGNAFLUX CORPORATION
Address:7300 W.LAWRENCE AVENUE
City:CHICAGO
State:IL
ZIP:60656-3504
Country:US
Info Phone Num:312-867-8000
Emergency Phone Num:312-867-8000
Preparer's Name:BRUCE C. GRAHAM
CAGE:37676
=== Contractor Identification ===
Company:ILLINOIS TOOL WORKS INC MAGNAFLUX DIV
Address:3624 WEST LAKE AVENUE
Box:City:GLENVIEW
State:IL
ZIP:60025
Country:US
Phone:847-657-5300/
CAGE:37676

=============  Composition/Information on Ingredients  =============

Name:METHYL CHLOROFORM (1,1,1-TRICHLOROEHANE)  (SARA III)
CAS:71-55-6
RTECS #:KJ2975000
Fraction by Wt: 90.0%
OSHA PEL:350 PPM/450 STEL
ACGIH TLV:350 PPM/450STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ozone Depleting Chemical:1

Name:CARBON DIOXIDE
CAS:124-38-9
RTECS #:FF6400000
Fraction by Wt: 05.0%
OSHA PEL:5000 PPM
ACGIH TLV:5000PPM/30000STEL;93

=====================  Hazards Identification  =====================

Reports of Carcinogenicity:NTP:NO    IARC:NO	OSHA:NO
Health Hazards Acute and Chronic:IRRITATES EYES BY SOLVENT ACTION.
Explanation of Carcinogenicity:1,1,1-TRICHLOROETHANE IS CURRENTLY UNDER
    TEST TO DETERMINE THE POSSIBLE CARCINOGENICITY.
Effects of Overexposure:INHALATION:SPRAY MIST MAY IRRITATE TO BREATHING
    PASSAGES; EYES:LIQUID CONTACT MAY CAUSE IRRITATION; SKIN:SOLVENT IN
    THE PRODUCT MAY IRRITATE SKIN; INGESTION:NOT NOTED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NOT STATED BY MANUFACTURER.

=======================  First Aid Measures  =======================

First Aid:INHALATION:REMOVE TO FRESH AIR.IF BREATHING IS DIFFICULT,GIVE
    OXYGEN; SKIN:REMOVE CONTAMINATED CLOTHES.WASH OFF WITH FLOWING
    WATER.USE SOOTHING LOTION.IF IRRITATION PERSISTS,GET MEDICAL ATTN;
    EYES:IMM EDIATELY RINSE/FLUSH WITH COPIOUS AMOUNTOF RUNNING
    WATER,AND GET MEDICAL ATTENTION.

=====================  Fire Fighting Measures  =====================

Flash Point:NONE
Extinguishing Media:CARBON DIOXIDE,FOAM
Fire Fighting Procedures:KEEP CONTAINERS COOL WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:AEROSOL CANS CAN BURST IF HEATED ABOVE
    130F(54.4C).

==================  Accidental Release Measures  ==================

Spill Release Procedures:LESS THAN ONE QUART:WIPE UP BUT DO NOT BREATHE
    VAPORS;ONE QUART OR MORE:WEAR ALL PERSONAL SAFETY EQUIPMENT TO
    AVOID VAPOR/LIQ CONTACT OR BREATHING.EVACUATE UNPROTECTED
    PERSONS.ELIMINATE IGN SOURCES.DI KE LIQ.PLACE IN COVERED DRUMS.SEND
    TO RECLAIMER.

======================	Handling and Storage  ======================

Handling and Storage Precautions:STORE AWAY FROM HEAT SOURCES TO
    MINIMIZE THE DANGER FROM EXPOSURE TO FIRES.STORE IN
    DRY,COOL,VENTILATED AREA.
Other Precautions:DO NOT USE AROUND FLAMES/RED HOT SURFACES.DO NOT HEAT
    ABOVE 130F.AVOID BREATHING VAPORS.AVOID FREQUENT/PROLONGED EXPOSURE
    TO SKIN.

=============  Exposure Controls/Personal Protection  =============

Respiratory Protection:WEAR RESPIRATOR WITH CHEMICAL CARTRIDGE.IN
    CONFINED AREAS,WEAR A FULL MASK WITH SEPARATE AIR SUPPLY.
Ventilation:GENERAL VENTILATION TO KEEP BELOW 350PPM OF TLV LIMIT.
Protective Gloves:NITRILE RUBBER GLOVES
Eye Protection:FULL GOGGLES
Other Protective Equipment:USE IN SPRAY BOOTH OR NEXT TO AN EXHAUST
    VENT TO CARRY VAPORS AWAY FROM OCCUPIED AREAS.
Work Hygienic Practices:WASH THOROUGHLY AFTR HANDLING MATERIAL.LAUNDER
    CONTAMINATED CLOTHES BEFORE REUSE OF:DEVELOPER ZP-9E
Supplemental Safety and Health
NSN WAS GROUP VII OF MIL-I-25135C & HAD 3 PARTS(SEE PNI A THRU D FOR
    OLD PARTS);UNDER REV "D" OF SPEC,NSN BECAME TYPE I,METH C,LVL 3 &
    STILL HAS 3 PARTS;I/A/W QPL-25135-15,PARTS ARE:DEVELOPR(ZP-9E NOT 
    ZP-9F),CLEANER(SKC-NF/ZC-7B),& PENETRANT(ZL-22D OR
    ZL-27A);KEY1:J7;REF:DGSC-SLM CASE HISTORY #88281H;THIS IS ZP-9E
    DEVL

==================  Physical/Chemical Properties  ==================

HCC:V2
Spec Gravity:1.3 (OF LIQUID)
Evaporation Rate & Reference:0.7 (ETHER=1)
Solubility in Water:PARTIAL
Appearance and Odor:CLOUDY,COLORLESS LIQUID BEFORE FILLING IN AEROSOL
    CANS
Percent Volatiles by Volume:90.0

=================  Stability and Reactivity Data  =================

Stability Indicator/Materials to Avoid:YES
ALKALI METALS
Stability Condition to Avoid:HEAT/HIGH TEMPERATURES
Hazardous Decomposition Products:PHOSGENE,HYDROCHLORIC ACID GAS &
    OXIDES OF CARBON

====================  Disposal Considerations  ====================

Waste Disposal Methods:DISPOSE OF AS EPA HAZARDOUS WASTE NO:F002; MAY
    BE SENT TO SOLVENT RECLAIMER.INSURE THAT AEROSOL CANS ARE EMPTY AND
    DEPRESSURIZED BEFORE DISCARDING,UNLESS A WASTE TREATMENT FACILITY
    IS APPROVED TO ACCE PT THEM AS IS.COMPLY WITH FED,ST,& LOCALREGS.

 Disclaimer (provided with this information by the compiling agencies):
 This information is formulated for use by elements of the Department
 of Defense.  The United States of America in no manner whatsoever,
 expressly or implied, warrants this information to be accurate and
 disclaims all liability for its use.  Any person utilizing this
 document should seek competent professional advice to verify and
 assume responsibility for the suitability of this information to their
 particular situation.

*** END OF RECORD ***