TRIM-TEX, INC.
3700 W. PRATT AVENUE; LINCOLNWOOD, IL 60712
847-679-3000
24 Hour Emergency Phone: 800-424-9300
MATERIAL SAFETY DATA SHEET
SECTION III 鈥? HAZARDS IDENTIFICATION (CONTINUED)
EFFECTS OF OVEREXPOSURE:
飪? Eye Contact: Can cause severe irritation, redness, tearing and blurred vision.
飪? Skin Contact: Prolonged or repeated contact can cause moderate irritation
deffating and dermatitis.
飪? Inhalation: Excessive inhalation of vapors can cause nasal and respiratory
irritation, dizziness, weakness, fatigue, nausea, headache, possible
unconsciousness and even asphyxiation.
飪? Ingestion: No Information
飪? Chronic Hazards: Overexposure to this material (or its components) has
apparently been found to cause the following effects in laboratory animals:
kidney damage.
飪? Primary Route(s) of Entry: Skin contact, inhalation, and eye contact.
SECTION IV 鈥? FIRST AID MEASURES
飪? Eye Contact: Flush with large amounts of water, lifting upper and lower
lids occasionally and get medical attention.
飪? Skin Contact: Thoroughly wash exposed area with soap and water.
Remove contaminated clothing. Launder contaminated
clothing before re-use. Get medical attention if irritation
persists.
飪? Inhalation: Remove individual to fresh air. If breathing is difficult,
administer oxygen. Give artificial respiration if breathing
has stopped. Keep person warm and quiet. Get medical
attention.
飪? Ingestion: Do not induce vomiting. Give two glasses of water if
conscious. Never give anything by mouth to an unconscious
person. Get immediate medical attention.
2 of 7
Trim-Tex 848 Cleaner Issue Date: 03/27/08
TRIM-TEX, INC.
3700 W. PRATT AVENUE; LINCOLNWOOD, IL 60712
847-679-3000
24 Hour Emergency Phone: 800-424-9300
MATERIAL SAFETY DATA SHEET
SECTION V 鈥? FIRE FIGHTING MEASURES
Flash Point: -156潞F Lower Explosive Limit: 0.7%
(Pensky-Martens C.C.) Upper Explosive Limit: 9.5%
Auto-Ignition Temperature: N.D.
Extinguishing Media: CO2, Dry Chemical, Foam, Water Fog
飪? Unusual Fire and Explosion Hazards: Vapors are heavier than air and travel
along the ground or may be moved by ventilation and ignited by ignition sources
at locations distant from material handling point. For aerosol products 鈥?
exposure to temperatures over 130潞F may cause containers to burst releasing
highly flammable gas. As with all unsaturated fats and oils, some porous
materials such as rags, paper, insulation, or organic clay when wetted with this
product may undergo spontaneous combustion. Keep such wetted materials well
ventilated to prevent possible heat buildup.
飪? Special Firefighting Procedures: Wear self-contained breathing apparatus with
a full face piece operated in pressure-demand or other positive pressure mode
when fighting fires. Keep fire exposed containers cool with water fog.
SECTION VI 鈥? ACCIDENTAL RELEASE MEASURES
飪? Steps to be taken in case material is released or spilled: Eliminate sources of
ignition & ventilate area. Persons not properly equipped should be excluded
from area. Stop spill at source 鈥? prevent spreading. Avoid inhalation of vapors.
Avoid skin contact with liquid. Soak up on absorbent material and place into
proper container for disposal. Use non-sparking scoops for flammable materials.
Clean walking surfaces thoroughly to reduce slipping hazard.
SECTION VII 鈥? HANDLING & STORAGE
飪? Handling: Containers of this material may be hazardous when emptied, since
containers retain product residues (vapor, liquid, and/or solid). All hazard
precautions given must be observed. Do not flame cut, braze or use welding
torch on containers. Intentional misuse by deliberately concentrating and
inhaling the vapors from this product may be harmful or fatal.
飪? Storage: Do not store above 120潞F. Do not store in direct sunlight. Keep away
from heat sources, open flame, pilot lights, sparks and other sources of ignition.
3 of 7
Trim-Tex 848 Cleaner Issue Date: 03/27/08
TRIM-TEX, INC.
3700 W. PRATT AVENUE; LINCOLNWOOD, IL 60712
847-679-3000
24 Hour Emergency Phone: 800-424-9300
MATERIAL SAFETY DATA SHEET
SECTION VIII 鈥? EXPOSURE CONTROLS / PERSONAL PROTECTION
飪? Engineering Controls: Provide sufficient mechanical ventilation (general and/or
local exhaust) to maintain exposure below TLV(s).
飪? Respiratory Protection: If workplace exposure limits of product or any
component is exceeded, use a NIOSH/MSHA approved respirator. Consult your
safety equipment supplier for recommendations.
飪? Skin Protection: Wear impervious gloves if method of use involves skin contact
with product. Consult your safety supply vendor for glove recommendations.
飪? Eye Protection: Wear safety glasses at minimum, more extensive protection may
be necessary depending on how the product is to be used.
飪? Other Protective Equipment: Wear impervious clothing if bodily exposure is
anticipated. Consult your safety supply vendor for recommendations.
飪? Hygienic Practices: Wash hands before eating or smoking. Smoke in designated
areas only. Remove and launder clothing if contaminated.
SECTION IX 鈥? PHYSICAL AND CHEMICAL PROPERTIES
Boiling Range: -44潞F to 472潞F
Odor: Citrus
Appearance: Clear liquid
Solubility in H2O: Negligible
Freeze Point: N.D.
Vapor Pressure: N.D.
Physical State: Liquid
Vapor Density: Is heavier than air
Odor Threshold: N.D.
Evaporation Rate: Is faster than Butyl Acetate
Specific Gravity: 0.7372
pH @ 0.0%: N.D.
Viscosity: N.D.
Coefficient of Water/Oil Distribution: N.D.
(See Section 16 for abbreviation legend.)
4 of 7
Trim-Tex 848 Cleaner Issue Date: 03/27/08
TRIM-TEX, INC.
3700 W. PRATT AVENUE; LINCOLNWOOD, IL 60712
847-679-3000
24 Hour Emergency Phone: 800-424-9300
MATERIAL SAFETY DATA SHEET
SECTION X 鈥? STABILITY AND REACTIVITY
飪? Conditions to Avoid: Heat, sparks, welding arcs, open flame, pilot lights, static
electricity or other source of ignition.
飪? Incompatibility: Acids and strong oxidizers.
飪? Hazardous Decomposition Products: Carbon monoxide and carbon dioxide.
飪? Hazardous Polymerization: Will not occur under normal conditions.
飪? Stability: This product is stable under normal storage conditions.
SECTION XI 鈥? TOXICOLOGICAL PROPERTIES
飪? No product or component toxicological information is available.
SECTION XII 鈥? ECOLOGICAL INFORMATION
飪? Ecological Information: No Information
SECTION XIII 鈥? DISPOSAL CONSIDERATIONS
飪? Product Disposal: Dispose of in accordance with all local, state and federal
regulations.
SECTION XIV 鈥? TRANSPORTATION INFORMATION
D.O.T. Proper Shipping Name: Aerosols
D.O.T. Technical Name:
D.O.T. Hazard Class: 2.1
D.O.T. Hazard Subclass: None
D.O.T UN/NA Number: UN1950
Packing Group: None
RESP. Guide Page: 126
Additional Information: For domestic ground and air shipment this product may be
shipped as a Consumer Commodity ORM-D. Outer cartons must have the ORM-D or
ORM-D AIR designation. (Our original cartons are preprinted with the ORM-D
designation for ground shipment.)
5 of 7
Trim-Tex 848 Cleaner Issue Date: 03/27/08
TRIM-TEX, INC.
3700 W. PRATT AVENUE; LINCOLNWOOD, IL 60712
847-679-3000
24 Hour Emergency Phone: 800-424-9300
MATERIAL SAFETY DATA SHEET
SECTION XV 鈥? REGULATORY INFORMATION
U.S. FEDERAL REGULATIONS AS FOLLOWS:
飪? OSHA: Hazardous by definition of Hazard Communication Standard (29 CFR
1910.1200)
飪? CERCLA 鈥? SARA Hazard Category: This product has been reviewed according
to the EPA 鈥楬azard Categories鈥? promulgated under Sections 311 and 312 of the
Superfund Amendment and Reauthorization Act of 1986 (SARA Title III) and is
considered, under applicable definitions, to meet the following categories:
IMMEDIATE HEALTH HAZARD PRESSURIZED GAS HAZARD
FIRE HAZARD
飪? SARA Section 313: This product contains the following substances subject to the
reporting requirements of Section 313 of Title III of the Superfund Amendments
and Reauthorization Act of 1986 and 40 CFR Part 372:
CHEMICAL NAME: CAS NUMBER WT/WT% IS LESS THAN
No SARA Section 313 components exist in this product.
飪? Toxic Substances Control Act: This product contains the following chemical
substances subject to the reporting requirements of TSCA 12(B) if exported from
the United States:
CHEMICAL NAME: CAS NUMBER
No information is available.
INTERNATIONAL REGULATIONS AS FOLLOWS:
飪? CANADIAN WHIMS: This MSDS has been prepared in compliance with Controlled
Product Regulations except for use of the 16 headings.
飪? CANADIAN WHMIS CLASS: No information available.
飪? TSCA Inventory: All components of this product are on the US TSCA inventory.
6 of 7
Trim-Tex 848 Cleaner Issue Date: 03/27/08
TRIM-TEX, INC.
3700 W. PRATT AVENUE; LINCOLNWOOD, IL 60712
847-679-3000
24 Hour Emergency Phone: 800-424-9300
MATERIAL SAFETY DATA SHEET
SECTION XVI 鈥? OTHER INFORMATION
HMIS Ratings 鈥? Health: 2 Flammability: 4 Reactivity: 0
Previous MSDS Revision Date: 07/19/06
Reason for revision: Scheduled Update
VOC Content: 49.0% by weight, 361 grams/liter total product,
696 grams/liter less water and exempt, 0.47 lbs/can.
Legend: N.A. 鈥? Not Applicable
N.D. 鈥? Not Determined
N.E. 鈥? Not Established
The information contained on this MSDS has been checked and should be accurate.
However, it is the responsibility of the user to comply with all Federal, State, and Local
laws and regulations. The environmental information and hazardous materials
identification system have been included by Trim-Tex, Inc. in order to provide
additional health and hazard classification information. The ratings recommended are
based upon the criteria supplied by the developers of these rating systems, together with
Trim-Tex, Inc.鈥檚 interpretation of the available data. Proper personal protective
equipment varies widely with conditions of use and anticipated exposure. We
recommend that a supervisor, or other qualified person, determine proper PPE for
intended use.
7 of 7
Trim-Tex 848 Cleaner Issue Date: 03/27/08
|