SECTION V HEALTH HAZARD DATA
MATERIAL SAFETY DATA SHEET EKG00564
Threshold Limited Value
ALDON RTECS No. MA3740000 Toxicity data: Orl-mus LD50: 6000 mg/kg.
1533 W.Henrietta Rd.
EKG00564
Avon, New York 14414 MSDS No.
庐
CORPORATION January 18, 1995
(716) 226-6177 Effective Date
Effects of Overexposure
May be harmful by inhalation, ingestion or skin absorption. May cause
eye irritation. May cause skin irritation. Exercise appropriate
SECTION I NAME 24 HOUR EMERGENCY ASSISTANCE
procedures to minimize potential hazards.
GLUTARIC ACID
Product CHEMTREC Health 2
800-424-9300
Chemical
Emergency and
Pentanedioic Acid
Synonyms EYES: Flush thoroughly with water for at least 15 minutes, lifting upper
1
Fire
Day 716-226-6177
First Aid Procedures and lower eyelids occasionally. Get immediate medical attention. SKIN:
C5H8O4
Formula 1
Reactivity Flush thoroughly with water, then wash with mild soap and water.
NFPA
INHALATION: Remove to fresh air. If not breathing, give artificial
HAZARD RATING HMIS *
up to 180 Kg.
Unit Size
respiration. If breathing is difficult, give oxygen. Get medical attention.
LEAST SLIGHT MODERATE HIGH EXTREME
0 1 2 3 4 INGESTION: Rinse mouth with water. Call physician. Never give
110-94-1
C.A.S. No.
anything by mouth to an unconscious person.
SECTION II INGREDIENTS OF MIXTURES
SECTION VI REACTIVITY DATA
Principal Component(s) % TLV Units
Conditions to Avoid
Unstable
Stability Excessive temperature.
Glutaric Acid >99% None established.
Stable X
Incompatibility
Bases, oxidizing agents, reducing agents.
(Materials to Avoid)
WARNING! MAY BE HARMFUL BY INHALATION, INGESTION
Hazardous
OR SKIN ABSORPTION. MAY CAUSE IRRITATION. Carbon monoxide, carbon dioxide.
Decomposition Products
SECTION III PHYSICAL DATA
Conditions to Avoid
Hazardous Polymerization
Specific Gravity (H2O = 1)
Melting Point (掳F) 95掳-98掳C (203掳-208掳F) 1.429 @ 15掳C
May Occur Will Not Occur Not applicable.
Percent Volatile
Boiling Point (掳F) 200掳C (392掳F) Not applicable.
by Volume (%) X
Evaporation Rate
SECTION VII SPILL OR LEAK PROCEDURES
Vapor Pressure (mm Hg) Not applicable. Not applicable.
=1)
(
Steps to be taken in case
Vapor Density (Air=1) Not applicable. Ventilate area. Wear self-contained breathing apparatus and
material is released or spilled protective clothing. Avoid raising dust. Sweep up and place in
Solubility in Water 429 g/Lt. @ 0掳C; 639 @ 20掳C a suitable container for proper disposal. Wash spill area with
soap and water.
Appearance & Odor White crystalline solid.
Discharge, treatment, or disposal may be subject to Federal, State or Local laws.
Waste Disposal Method
SECTION IV FIRE AND EXPLOSION HAZARD DATA These disposal guidelines are intended for the disposal of catalog-size quantities only.
Lower
Flammable Limits in Air Upper
Flash Point
Dispose of in an approved incinerator equipped with an afterburner and
% by Volume
(Method Used) Not applicable. NA -------- --------
scrubber or contract with a licensed waste disposal system.
Extinguisher
Use any media suitable for extinguishing supporting fire. SECTION VIII SPECIAL PROTECTION INFORMATION
Media
Respiration Protection
Wear a NIOSH/MSHA approved respirator.
(Specify Type)
SPECIAL FIREFIGHTING
Recommended. No.
Local Exhaust Special
PROCEDURES Ventilation Recommended. No.
Mechanical (General) Other
Wear self-contained breathing apparatus and protective clothing Eye Protection
Protective Gloves Rubber. Chemical safety goggles.
to prevent contact with skin and eyes.
Other Protective
Lab coat, apron, eye wash station, proper gloves.
Equipment
SECTION IX SPECIAL PRECAUTIONS
Precautions to be Taken
UNUSUAL FIRE AND in Handling & Storing Store in a cool place. Wash thoroughly after handling.
EXPLOSION HAZARDS Keep container tightly closed when not in use.
Read label on container before using. Do not wear contact lenses when working with chemicals.
Other Precautions
This material like most material in powder form, is capable of
Avoid contact with eyes, skin and clothing. Do not breathe
creating a dust explosion.
dust. Remove and wash contaminated clothing.
For laboratory use only. Not for drug, food or household use. Keep out of reach of children.
Chemical Safety
Approved
Revision Date
No. 1 Michael Raszeja
1/18/95 MR
Coordinator
D.O.T. NON-REGULATED. The information contained herein is furnished without warranty of any kind. Employers should use this information only as a supplement to other information
gathered by them and must make independent determinations of suitability and completeness of information from all sources to assure proper use of these
Approved by U.S. Department of Labor "essentially similar" to form OSHA-20 materials and the safety and health of employees. * Hazardous Materials Industrial Standards. Printed on recycled paper.
|