TRIM-TEX, INC.
3700 W. PRATT AVENUE; LINCOLNWOOD, IL 60712
847-679-3000
24 Hour Emergency Phone: 800-424-9300
MATERIAL SAFETY DATA SHEET
SECTION III 鈥? HAZARDS IDENTIFICATION
EMERGENCY OVERVIEW ***
Keep from reach of children. Do not puncture, incinerate or place aerosol
product containers in compactors. Containers of this material may be hazardous
when emptied since containers retain product residues (vapor, liquid and/or
solid). All hazard precautions given must be observed. Do not flame cut, braze
or use a welding torch. Intentional misuse by deliberately concentrating and
inhaling this product may be harmful or fatal.
EFFECTS OF OVEREXPOSURE:
飪? Eye Contact: Can cause severe irritation, redness, tearing and blurred vision.
飪? Skin Contact: Prolonged or repeated contact can cause moderate irritation
defatting and dermatitis.
飪? Inhalation: Excessive inhalation of vapors can cause nasal and respiratory
irritation, dizziness, weakness, fatigue, nausea, headache, possible
unconsciousness and even asphyxiation. Possible cardiac arrhythmias at high
concentrations.
飪? Ingestion: No Information
飪? Chronic Hazards: Overexposure to this material (or its components) has
apparently been found to cause the following effects in laboratory animals:
kidney damage, eye damage and liver damage.
飪? Primary Route(s) of Entry: Skin contact, skin absorption, inhalation and eye
contact.
SECTION IV 鈥? FIRST AID MEASURES
飪? Eye Contact: Flush with large amounts of water, lifting upper and lower lids
occasionally and get medical attention.
飪? Skin Contact: Thoroughly wash exposed area with soap and water. Remove
contaminated clothing. Launder contaminated clothing before re-use. Get
medical attention if irritation persists. Mineral oil, baby oil, make-up remover,
mineral spirits or other similar mild solvent may be used to remove the sticky
resin residue left by the adhesive.
飪? Inhalation: Remove individual to fresh air. If breathing is difficult, administer
oxygen. Give artificial respiration if breathing has stopped. Keep person warm
and quiet. Get medical attention.
飪? Ingestion: Do not induce vomiting. Give two glasses of water if conscious. Never
give anything by mouth to an unconscious person. Get immediate medical
attention.
2 of 7
Trim-Tex TEX11 Adhesive Issue Date: 03/20/08
TRIM-TEX, INC.
3700 W. PRATT AVENUE; LINCOLNWOOD, IL 60712
847-679-3000
24 Hour Emergency Phone: 800-424-9300
MATERIAL SAFETY DATA SHEET
SECTION V 鈥? FIRE FIGHTING MEASURES
Flash Point: -156潞F (Pensky-Martens C.C.)
Upper Explosive Limit: 18.0%
Lower Explosive Limit: 1.0%
Auto-Ignition Temperature: N.D.
Extinguishing Media: CO2, Dry Chemical, Foam, Water Fog
飪? Unusual Fire and Explosion Hazards: Vapors are heavier than air and travel
along the ground or may be moved by ventilation and ignited by ignition sources
at locations distant from material handling point. For aerosol products 鈥?
exposure to temperatures over 130潞F may cause containers to burst releasing
highly flammable gas.
飪? Special Firefighting Procedures: Wear self-contained breathing apparatus with
a full face piece operated in pressure-demand or other positive pressure mode
when fighting fires. Keep fire exposed containers cool with water fog.
SECTION VI 鈥? ACCIDENTAL RELEASE MEASURES
飪? Steps to be taken in case material is released or spilled: Eliminate sources of
ignition & ventilate area. Persons not properly equipped should be excluded
from area. Stop spill at source 鈥? prevent spreading. Avoid inhalation of vapors.
Avoid skin contact with liquid. Soak up on absorbent material and place into
proper container for disposal. Use non-sparking scoops for flammable materials.
Clean walking surfaces thoroughly to reduce slipping hazard.
SECTION VII 鈥? HANDLING & STORAGE
飪? Handling: Containers of this material may be hazardous when emptied, since
containers retain product residues (vapor, liquid and/or solid). All hazard
precautions given must be observed. Do not flame cut, braze or use welding
torch on containers. Intentional misuse by deliberately concentrating and
inhaling the vapors from this product may be harmful or fatal.
飪? Storage: Do not store above 120潞F. Do not store in direct sunlight. Keep away
from heat sources, open flame, pilot lights, sparks and other sources of ignition.
3 of 7
Trim-Tex TEX11 Adhesive Issue Date: 03/20/08
TRIM-TEX, INC.
3700 W. PRATT AVENUE; LINCOLNWOOD, IL 60712
847-679-3000
24 Hour Emergency Phone: 800-424-9300
MATERIAL SAFETY DATA SHEET
SECTION VIII 鈥? EXPOSURE CONTROLS / PERSONAL PROTECTION
飪? Engineering Controls: Provide sufficient mechanical ventilation (general and/or
local exhaust) to maintain exposure below TLV(s).
飪? Respiratory Protection: If workplace exposure limits of product or any
component is exceeded, use a NIOSH/MSHA approved respirator. Consult your
safety equipment supplier for recommendations.
飪? Skin Protection: Wear impervious gloves if method of use involves skin contact
with product. Consult your safety supply vendor for glove recommendations.
飪? Eye Protection: Wear safety glasses at minimum, more extensive protection may
be necessary depending on how the product is to be used.
飪? Other Protective Equipment: Wear impervious clothing if bodily exposure is
anticipated. Consult your safety supply vendor for recommendations.
飪? Hygienic Practices: Wash hands before eating or smoking. Smoke in designated
areas only. Remove and launder clothing if contaminated.
SECTION IX 鈥? PHYSICAL AND CHEMICAL PROPERTIES
Boiling Range: -44潞F to 177潞F
Vapor Density: Is heavier than air
Odor: Mint when wet
Odor Threshold: N.D.
Appearance: White opaque liquid
Evaporation Rate: Is faster than Butyl Acetate
Solubility in H2O: Negligible
Freeze Point: N.D.
Specific Gravity: 0.7151
Vapor Pressure: N.D.
pH @ 0.0%: N.D.
Physical State: Liquid
Viscosity: N.D.
Coefficient of Water/Oil Distribution: N.D.
(See Section XVI for abbreviation legend.)
4 of 7
Trim-Tex TEX11 Adhesive Issue Date: 03/20/08
TRIM-TEX, INC.
3700 W. PRATT AVENUE; LINCOLNWOOD, IL 60712
847-679-3000
24 Hour Emergency Phone: 800-424-9300
MATERIAL SAFETY DATA SHEET
SECTION X 鈥? STABILITY AND REACTIVITY
飪? Conditions to Avoid: Heat, sparks, welding arcs, open flame, pilot lights, static
electricity or other source of ignition.
飪? Incompatibility: Oxidizing agents, acids, alkali, alkaline earth metals, amines,
reducing agents, strong oxidizers, very strong acid, caustic or oxidizing agents.
飪? Hazardous Decomposition Products: Hydrofluoric acid and possibly carbonyl
fluoride, carbon monoxide and carbon dioxide, various hydrocarbons, sulfur
dioxide, sulfur monoxide.
飪? Hazardous Polymerization: Will not occur under normal conditions.
飪? Stability: This product is stable under normal storage conditions.
SECTION XI 鈥? TOXICOLOGICAL PROPERTIES
飪? No product or component toxicological information is available.
SECTION XII 鈥? ECOLOGICAL INFORMATION
飪? Ecological Information: No Information
SECTION XIII 鈥? DISPOSAL CONSIDERATIONS
飪? Disposal Method: Dispose of in accordance with all local, state and federal
regulations.
SECTION XIV 鈥? TRANSPORTATION INFORMATION
D.O.T. Proper Shipping Name: Aerosols
D.O.T. Technical Name:
D.O.T. Hazard Class: 2.1
D.O.T. Hazard Subclass: None
D.O.T UN/NA Number: UN1950
Packing Group: None
RESP. Guide Page: 126
5 of 7
Trim-Tex TEX11 Adhesive Issue Date: 03/20/08
TRIM-TEX, INC.
3700 W. PRATT AVENUE; LINCOLNWOOD, IL 60712
847-679-3000
24 Hour Emergency Phone: 800-424-9300
MATERIAL SAFETY DATA SHEET
SECTION XIV 鈥? TRANSPORTATION INFORMATION (CONTINUED)
Additional Information: For domestic ground and air shipment this product may be
shipped as a Consumer Commodity ORM-D. Outer cartons must have the ORM-D or
ORM-D AIR designation. (Our original cartons are preprinted with the ORM-D
designation for ground shipment.)
SECTION XV 鈥? REGULATORY INFORMATION
U.S. FEDERAL REGULATIONS AS FOLLOWS:
飪? OSHA: Hazardous by definition of Hazard Communication Standard (29 CFR
1910.1200)
飪?
飪? CERCLA 鈥? SARA Hazard Category: This product has been reviewed according
to the EPA 鈥楬azard Categories鈥? promulgated under Sections 311 and 312 of the
Superfund Amendment and Reauthorization Act of 1986 (SARA Title III) and is
considered, under applicable definitions, to meet the following categories:
IMMEDIATE HEALTH HAZARD PRESSURIZED GAS HAZARD
FIRE HAZARD
飪? SARA Section 313: This product contains the following substances subject to the
reporting requirements of Section 313 of Title III of the Superfund Amendments
and Reauthorization Act of 1986 and 40 CFR Part 372:
CAS NUMBER CHEMICAL NAME: WT/WT% IS LESS THAN
110-82-7 Cyclohexane 15.0%
飪? Toxic Substances Control Act: This product contains the following chemical
substances subject to the reporting requirements of TSCA 12(B) if exported from
the United States:
CAS NUMBER CHEMICAL NAME:
No information is available.
INTERNATIONAL REGULATIONS AS FOLLOWS:
飪? Canadian WHMIS: This MSDS has been prepared in compliance with
Controlled Product Regulations except for use of the 16 headings.
飪? Canadian WHMIS Class: No information available.
6 of 7
Trim-Tex TEX11 Adhesive Issue Date: 03/20/08
TRIM-TEX, INC.
3700 W. PRATT AVENUE; LINCOLNWOOD, IL 60712
847-679-3000
24 Hour Emergency Phone: 800-424-9300
MATERIAL SAFETY DATA SHEET
SECTION XV 鈥? REGULATORY INFORMATION (CONTINUED)
TSCA Inventory: All components of this product are on the US TSCA inventory.
On June 30, 1993 the OSHA Z-1-A table was revoked and OSHA reverted back
to their prior exposure limits. The values on this MSDS reflect the roll back to
the prior values. Some states may continue to enforce the 1993 limits. On June
16, 1995 the EPA announced in a final rule that acetone would no longer be
considered a VOC for air attainment standards (it is now an exempt compound).
The VOC calculations on this MSDS are based on acetone being an exempt
compound. The June 16, 1995 rule also removed acetone from the list of SARA
313 reportable chemicals.
SECTION XVI 鈥? OTHER INFORMATION
HMIS Ratings 鈥? Health: 2 Flammability: 4 Reactivity: 1
Previous MSDS Revision Date: 07/19/06
Reason for revision: Scheduled Update
Volatile by Weight: 82.8%
Volatile by Volume: 87.6%
VOC Content: 63.9% by weight, 455 grams/liter total product,
544 grams/liter less water and exempt, 0.66 lbs/can.
Legend: N.A. 鈥? Not Applicable
N.D. 鈥? Not Determined
N.E. 鈥? Not Established
The information contained on this MSDS has been checked and should be accurate.
However, it is the responsibility of the user to comply with all Federal, State, and Local
laws and regulations. The environmental information and hazardous materials
identification system have been included by Trim-Tex, Inc. in order to provide
additional health and hazard classification information. The ratings recommended are
based upon the criteria supplied by the developers of these rating systems, together with
Trim-Tex, Inc.鈥檚 interpretation of the available data. Proper personal protective
equipment varies widely with conditions of use and anticipated exposure. We
recommend that a supervisor, or other qualified person, determine proper PPE for
intended use.
7 of 7
Trim-Tex TEX11 Adhesive Issue Date: 03/20/08
|