MATERIAL SAFETY DATA SHEET
SECTION 1- PRODUCT AND SUPPLIER INFORMATION
Product Name: Fluorescent Sublimation Developer
Product Class: Synthetic Organic Colorant
CAS Number: Trade Secret
HMIS Rating: Health: 1 Fire: 1 Reactivity: 0
Supplier Identification: Lightning Powder
13386 International Parkway
Jacksonville, FL 32218
Telephone/Fax: 904-741-5400/904-741-5407
SECTION 2- INGREDIENT AND HAZARD IDENTIFICATION
(No hazardous ingredients known at this time)
SECTION 3- HAZARDS IDENTIFICATION
Eye Contact: May cause irritation.
Skin Contact: May cause irritation.
Inhalation Hazards: Treat as nuisance dust. Avoid breathing.
Ingestion Hazards: Small amounts swallowed are not likely to cause injury.
Target Organs: No organs affected.
Cancer Hazards: No cancer hazards associated with this product.
SECTION 4- FIRST AID MEASURES
Eye Contact: Immediately flush with water for at least 15 minutes while holding eyelids
open. Call a physician.
Skin Contact: Wash with soap and water.
Inhalation: Remove to fresh air. Treat symptoms. Call a physician.
Ingestion: Do not induce vomiting. Give water. Call a physician.
SECTION 5- FIRE FIGHTING PROCEDURES
Flammability Class: NA Flash Point: None Explosive Range: None
Flammable Properties: During a fire, irritation and toxic gases may be formed. Do not
breath smoke or fumes. Wear suitable protective equipment.
Extinguishing Media: Use dry chemical, alcohol foam, carbon dioxide, or water spray.
Fire Fighting Instructions: Wear self-contained breathing apparatus.
SECTION 6- ACCIDENTAL RELEASE MEASURES
Containment: This material is hydrophobic and should be prevented from entering the
sewer system.
Clean-up: Place in an appropriate recovery and salvage drum for disposal.
CERCLA/SARA (Title III): This is not a regulated material under 40 CFR 117, 302.
Notification of spills is not required.
Evacuation: Not normally necessary.
SECTION 7- EXPOSURE CONTROLS/PERSONAL PROTECTION
Occupational Exposure Limits: Although no exposure limits have been established for
this product, the OSHA PEL for nuisance dust of 15 mg/m3 total dust and 5 mg/m3 of
respirable dust is recommended. In addition, the ACGIH TLV for nuisance dust is 10
mg/m3.
Engineering Controls: General ventilation is recommended. Additional local exhaust
ventilation is recommended where dusts, mists, or vapors may be released.
Respiratory Protection: A NIOSH approved dust mask is recommended.
Personal Protective Equipment: Where contact is likely, chemical resistant gloves and
safety glasses or goggles are recommended.
SECTION 8- HANDLING AND STORAGE
Handling: Use in a well ventilated area. Improper handling may lead to dust cloud
formation which, as with any organic dust, may be an explosion hazard.
Storage: Store in a dry area.
SECTION 9- PHYSICAL AND CHEMICAL PROPERTIES
Form, Appearance, Color, Odor: Yellow powder with slight odor.
Solubility in Water: Insoluble
Boiling Range: None
Evaporation Rate: Unavailable
Vapor Density: Non-volatile
Percent Volatile by Weight: NA
Percent VOC: None
Bulk Density: 4 lbs/gal.
SECTION 10- STABILITY AND REACTIVITY
Stability? Yes Hazardous Polymerization? No
Conditions To Avoid: Heat, sparks, and open flame.
Incompatibilities: Strong oxidizers.
Hazardous Decomposition Products: Oxides of carbon and nitrogen (combustion).
SECTION 11- DISPOSAL
Dispose of material in accordance with local, state, and federal regulations.
SECTION 12- TRANSPORTATION INFORMATION
UN Number: Not regulated.
SECTION 13- REGULATORY INFORMATION
SARA Title 111, Section 313: This product contains no chemicals subject to the
reporting requirements of Section 313 of the Emergency Planning and Community
Right-To-Know Act.
OSHA Hazard Communication standard, 29 CFR 1910.1200: This product is not
considered hazardous as defined.
SARA Sections 311 and 312: Reporting of this chemical is not required.
Toxic Substances Control Act: All components in this product are listed, or are
excluded from listing on the U.S. TSCA 8(b) inventory.
Clean Water Act: This product contains no ingredients regulated by the CWA.
Hazardous Air Pollutants: This product contains no HAP s.
Clean Air Act Amendments: This product contains no ozone depleting substances.
Coalition of Northeast Governors: This product is in compliance with CONEG (i.e.
total cadmium, chromium, lead, and mercury < 100 ppm).
SECTION 14- ECOLOGICAL INFORMATION
No studies have been conducted on this product.
|