MATERIAL SAFETY HIGHSIDE CHEMICALS, INC.
DATA SHEET 11114 REICHHOLD ROAD
GULFPORT, MS 39503
(228)-896-9220
EV COIL MAX(R)
THIS MSDS COMPLIES WITH 29 CFR 1900.1200
SECTION 1 - IDENTITY/EMERGENCY INFORMATION
PRODUCT NAME: EV COIL MAX(R) PRODUCT CODES: 56011
CHEMICAL NAME: MIXTURE, POWDER
CHEMICAL FORMULA: MIXTURE
IN CASE OF AN EMERGENCY CALL 1-800-255-3924
SECTION 2 - INGREDIENTS
COMPONENTS CAS NO. PEL/TLV - SOURCE
SODIUM METASILICATE 6834-92-0 RECOMMENDED CEILING
OF 2MG/M3 RESPIRABLE
PENTAHYDRATE
DUST
SODIUM LAUROYL 137-16-6 NOT ESTABLISHED
SARCOSINE
ALL COMPONENTS OF THIS PRODUCT ARE LISTED ON THE U.S. TSCA INVENTORY.
SECTION 3 - PHYSICAL DATA
BOILING POINT: NOT APPLICABLE
VAPOR PRESSURE (mmHg): NO DATA AVAILABLE
VAPOR DENSITY (AIR > 1): NO DATA AVAILABLE
SPECIFIC GRAVITY (H2O = 1): GREATER THAN 1
SOLUBILITY IN WATER: SOLUBLE
APPEARANCE AND ODOR: WHITE GRANULAR POWDER. NO ODOR.
EVAPORATION RATE (n-Butyl Acetate = 1): NOT APPLICABLE
PH: 12-13 (13 WHEN 11.25 OZ DISSOLVED IN 1 GAL. H2O)
BULK DENSITY: ABOUT 66 LBS/CU.FT. UNTAMPED
SECTION 4 - FIRE AND EXPLOSION HAZARD DATA
FLASH POINT (METHOD USED): NON COMBUSTIBLE
AUTOIGNITION TEMPERATURE: NOT APPLICABLE
EXPLOSIVE LIMITS: LOWER: NOT DETERMINED UPPER: NOT DETERMINED
EV COIL MAX 庐 PAGE 1 OF 4
EXTINGUISHING MEDIA: WATER FOG,CARBON DIOXIDE, OR DRY CHEMICAL
SPECIAL FIRE FIGHTING PROCEDURES: IF PRODUCT IS PRESENT IN FIRE AND THREAT OF
DECOMPOSITION EXISTS, WEAR SELF-CONTAINED BREATHING APPARATUS WITH A FULL
FACE PIECE OPERATED IN THE POSITIVE PRESSURE MODE. HAZARDOUS DECOMPOSITION
OR BY-PRODUCTS: UNDER FIRE CONDITIONS:
FUMES, SMOKE, AND OTHER DECOMPOSITION PRODUCTS.
UNUSUAL FIRE AND EXPLOSION HAZARDS: TOXIC FUMES MAY BE RELEASED IF PRODUCT IS
PRESENT IN A FIRE.
HAZARD RATING: HEALTH - 2 FLAMMABILITY - 0 REACTIVITY - 0
SECTION 5 - REACTIVITY DATA
HAZARDOUS POLYMERIZATION: WILL NOT OCCUR
STABILITY: STABLE
SECTION 6 - HEALTH HAZARD DATA
CARCINOGENICITY: NO CONSTITUENT OF THIS PRODUCT IS LISTED BY OSHA, NTP, OR IARC.
PRIMARY ROUTE(S) OF ENTRY: INHALATION, INGESTION, EYE, SKIN CONTACT.
SIGNS OF EXPOSURE: BURNING IN NOSE OR THROAT; ITCHING OR BURNING OF SKIN; PAIN,
REDNESS, OR TEARING OF EYES.
POTENTIAL EFFECTS OF OVEREXPOSURE:
EYE CONTACT:CORROSIVE - CAUSES BURNS
SKIN CONTACT: CORROSIVE - CAUSES BURNS
INHALATION:CORROSIVE - CAUSES BURNS TO RESPIRATORY TRACT
INGESTION:CORROSIVE- HARMFUL OR FATAL IF SWALLOWED
FIRST AID PROCEDURES:
EYE CONTACT: IMMEDIATELY FLUSH WHILE HOLDING EYES OPEN WITH PLENTYOF
WATER FOR AT LEAST 15 MINUTES. CALL A PHYSICIAN.
SKIN CONTACT: IMMEDIATELY FLUSH WITH PLENTY OF WATER FOR AT LEAST 15
MINUTES. REMOVE CONTAMINATED CLOTHING. THOROUGHLY WASH
CLOTHING AND SHOES BEFORE REUSE. CALL A PHYSICIAN.
INGESTION: DO NOT INDUCE VOMITING RINSE MOUTH WTH WATER. 0DILUTE STOMACH
CONTENTS BY DRINKING WATER. CALL A PHYSICIAN.
INHALATION: REMOVE INDIVIDUAL TO FRESH AIR, IF BREATHING IS DIFFICULT,
ADMINISTER OXYGEN. IF BREATHING HAS STOPPED GIVE ARTIFICIAL
RESPIRATION. CALL PHYSICIAN.
MEDICAL CONDITIONS AGGRAVATED BY EXPOSURE: ASTHMA, LUNG DISEASES, SKIN DISEASES
SECTION 7 - SPECIAL PROTECTION
EV COIL MAX 庐 PAGE 2 OF 4
RESPIRATORY PROTECTION: USE A NIOSH CERTIFIED DUST RESPIRATOR WHERE DUST OCCURS.
EYE PROTECTION: CHEMICAL GOGGLES OR FACE SHIELD.
VENTILATION: USE WITH ADEQUATE VENTILATION TO PREVENT EXPOSURE.
PROTECTIVE GLOVES: WEAR RUBBER GLOVES.
OTHER PROTECTIVE EQUIPMENT: TO PREVENT SKIN CONTACT, WEAR PROTECTIVE CLOTHING,
OR BOOTS. WASHING FACILITIES SHOULD BE READILY AVAILABLE.
SECTION 8 - ENVIRONMENTAL INFORMATION
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED:
SINKS AND MIXES WITH WATER. SWEEP, SCOOP, OR VACUUM DISCHARGED MATERIAL. FLUSH
RESIDUE WITH WATER. NEUTRALIZE WITH DILUTE ACID.
WASTE DISPOSAL METHOD:
NEUTRALIZE AND LANDFILL SOLIDS ACCORDING TO LOCAL, STATE, AND FEDERAL
REGULATIONS. FLUSH NEUTRAL LIQUID TO SEWER IN ACCORDANCE WITH FEDERAL, STATE,
AND LOCAL REGULATIONS OR PERMITS.
IF UNNEUTRALIZED AQUEOUS SOLUTIONS CONTAINING THIS MATERIAL BECOME WASTE, THEY
MAY BE RCRA HAZARDOUS WASTE IF THEY EXHIBIT THE CORROSIVE CHARACTERISTIC OF A pH
GREATER THAN OR EQUAL TO 12..5 AS DEFINED IN EPA RULES AT 40 C.F.R. SUBSECTION 261.22
(a)(1). IF SUCH SOLUTIONS AR RCRA HAZARDOUS WASTE, THEIR EPA HAZARDOUS WASTE
NUMBER IS D002.
THE FOLLOWING INFORMATION MAY BE USEFUL IN COMPLYING WITH VARIOUS STATE AND
FEDERAL LAWS AND REGULATIONS UNDER VARIOUS ENVIRONMENTAL STATUTES:
EPA REGULATION 40 CFR 302 (CERCLA SECTION 102):
NO REPORTABLE QUANTITY (RQ) FOR PRODUCT OR ANY CONSTITUENT GREATER THAN
1% OR O.1% (CARCINOGEN).
EPA REGULATION 40 CFR 355 (SARA SECTION 301-302)
NO THRESHOLD PLANNING QUANTITY FOR PRODUCT OR ANY CONSTITUENT GREATER
THAN 1% OR 0.1% (CARCINOGEN).
EPA REGULATION 40 CFR 370 (SARA SECTIONS 311-312):
NOT APPLICABLE FOR PRODUCT.
SECTION 9 - TRANSPORTATION INFORMATION
D.O.T. (49 CFR 172):
2.2 LB. CONTAINER AND UNDER: CONSUMER COMMODITY, ORM-D
OVER 2.2 LB. CONTAINER CORROSIVE SOLID, BASIC, INORGANIC, N.O.S., (SODIUM
METASILICATE PENTAHYDRATE), 8, UN3262, II
BILL OF LADING DESCRIPTION:
CLEANING COMPOUND, IT 48581, CLASS 55
INTERNATIONAL (UN/NA CODE):
5 Kg CONTAINER AND UNDER: CORROSIVE SOLID, BASIC, INORGANIC, N.O.S. (SODIUM
METASILICATE PENTAHYDRATE), 8, UN 3262, II, LTD QTY
OVER 5 Kg CONTAINER: CORROSIVE SOLID, BASIC, INORGANIC, N.O.S. (SODIUM
METASILICATE PENTAHYDRATE), 8, UN3262, II
IMCO:EmS No.: 8-15 CLASS 8
1 Kg CONTAINER AND UNDER: CORROSIVE SOLID, BASIC, INORGANIC, N.O.S. (SODIUM
METASILICATE PENTAHYDRATE), 8, UN 3262, II, LTD QTY
EV COIL MAX 庐 PAGE 3 OF 4
OVER 1 Kg CONTAINER: CORROSIVE SOLID, BASIC, INORGANIC, N.O.S. (SODIUM
METASILICATE PENTAHYDRATE), 8, UN3262, II
DATE PREPARED: 11/1/96 DATE UPDATED: 04/03/03
WHILE HIGHSIDE CHEMICALS, INC. BELIEVES THE DATA SET FORTH HEREIN ARE ACCURATE AS
OF THE DATE HEREOF, HIGHSIDE CHEMICALS, INC. MAKES NO WARRANTY WITH RESPECT
THERETO AND EXPRESSLY DISCLAIMS ALL LIABILITY FOR RELIANCE THEREON. SUCH DATA ARE
OFFERED SOLELY FOR YOUR CONSIDERATION, INVESTIGATION, AND VERIFICATION.
EV COIL MAX 庐 PAGE 4 OF 4
|