MATERIAL SAFETY HIGHSIDE CHEMICALS, INC.
DATA SHEET 11114 REICHHOLD ROAD
GULFPORT, MS 39503
(228) 896-9220
HL COIL BRITE
THIS MSDS COMPLIES WITH 29 CFR 1900.1200
SECTION 1 - IDENTITY/EMERGENCY INFORMATION
PRODUCT NAME: HL COIL BRITE PRODUCT CODE: 57014
CHEMICAL NAME: MIXTURE
CHEMICAL FORMULA: MIXTURE
IN CASE OF AN EMERGENCY CALL 1-800-255-3924
SECTION 2 鈥? INGREDIENTS
COMPONENTS CAS NO. PEL/TVL 鈥? SOURCE
AMMONIUM BIFLUORIDE 1341 - 49 - 7 2.5 mg/m; TWA OSHA & ACGIH
AMMONIUM FLUORIDE 12125 - 01 - 8
ALL COMPONENTS OF THIS PRODUCT ARE LISTED ON THE U.S. TSCA INVENTORY
SECTION 3 - PHYSICAL DATA
BOILING POINT: NOT APPLICABLE
MELTING POINT: 258EF
VAPOR PRESSURE (mmHg): NOT APPLICABLE
VAPOR DENSITY(AIR > 1): NOT APPLICABLE
BULK DENSITY, LOOSE: 43.7 lb/ft ;
SOLUBILITY IN WATER: SOLUBLE @ 630 g/l
APPEARANCE: PINK POWDER / CRYSTALS
ODOR: SLIGHTLY PUNGENT
EVAPORATION RATE (n-Butyl Acetate = 1): NOT APPLICABLE
% VOLATILE (BY WEIGHT): 0
PH: APPROX. 3 - 3.5 (13.6 oz. IN 1 GAL. WATER)
SECTION 4 - FIRE AND EXPLOSION HAZARD DATA
FLASH POINT (METHOD USED): NONE
AUTOIGNITION TEMPERATURE: NOT APPLICABLE
EXPLOSIVE LIMITS: LOWER: NOT APPLICABLE UPPER: NOT APPLICABLE
EXTINGUISHING MEDIA: WATER FOG, FOAM, CARBON DIOXIDE OR DRY CHEMICAL.
HL COIL BRITE庐 1 of 4
SPECIAL FIRE FIGHTING PROCEDURES: WEAR SELF-CONTAINED BREATHING APPARATUS WITH A
FULL FACE PIECE AND IMPERVIOUS PROTECTIVE CLOTHING. PREVENT HUMAN
EXPOSURE TO FIRE, FUMES, SMOKE, AND COMBUSTION PRODUCTS.
HAZARDOUS DECOMPOSITION OR BY-PRODUCTS: UNDER FIRE CONDITIONS: HYDROGEN
FLUORIDE, AMMONIA, CARBON DIOXIDE, CARBON MONOXIDE, AND OTHER
DECOMPOSITION PRODUCTS.
UNUSUAL FIRE AND EXPLOSION HAZARDS: DECOMPOSES ON HEATING, FUMES CORROSIVE AND
TOXIC.
HAZARD RATING: HEALTH - 3 FLAMMABILITY - 0 REACTIVITY - 1
SECTION 5 - REACTIVITY DATA
HAZARDOUS POLYMERIZATION: WILL NOT OCCUR
INCOMPATIBILITIES: GLASS AND SILICATE CONTAINING MATERIALS ARE ATTACKED. CONTACT
WITH STRONG ACIDS LIBERATES HYDROGEN FLUORIDE.
STABILITY: STABLE UNDER NORMAL CONDITIONS
SECTION 6 - HEALTH HAZARD DATA
CARCINOGENICITY: NO CONSTITUENT OF THIS PRODUCT IS LISTED BY OSHA, NTP, OR IARC.
PRIMARY ROUTE(S) OF ENTRY: INHALATION, INGESTION, SKIN CONTACT, EYE
POTENTIAL EFFECTS OF EXPOSURE:
BURN SYMPTONS MAY NOT APPEAR IMMEDIATELY. CHRONIC BONE CHANGES OR LUNG
SCARRING CAN OCCUR.
EYES: CORROSIVE - MAY CAUSE BURNS OR IRRITATION, PAIN, TEARS, EYE DAMAGE,
BLINDNESS.
INGESTION: CORROSIVE - MAY CAUSE BURNS OR IRRITATION, PAIN, SEVERE BURNS,
VOMITING, DIARRHEA, TISSUE PERFORATION.
SKIN: CORROSIVE - MAY CAUSE SEVERE BURNS OR IRRITATION, PAIN, SKIN DAMAGE.
INHALATION: CORROSIVE - MAY CAUSE BURNS OR IRRITATION, COUGHING, CHOKING,
HEADACHE, DIZZINESS, WEAKNESS, BREATHING DIFFICULTY, FLUID RETENTION, TISSUE
DISCOLORATION, EFFECTS MAY BE DELAYED.
OVER EXPOSURE MAY AGGRAVATE DISORDERS OF THE RESPIRATORY SYSTEM OR SKIN.
CAN CAUSE BRITTLE BONES.
FIRST AID PROCEDURES:
EYE CONTACT: IMMEDIATELY RINSE WITH RUNNING WATER FOR 15 MINUTES WHILE
HOLDING EYELIDS APART. CALL PHYSICIAN. CONTINUE RINSING WITH CALCIUM
GLUCONATE SOLUTION.
SKIN CONTACT: IMMEDIATELY FLUSH SKIN WITH PLENTY OF WATER FOR AT LEAST 15
MINUTES. REMOVE CONTAMINATED CLOTHING AND SHOES. CALL PHYSICIAN.
USE LOCAL APPLICATION OF CALCIUM GLUCONATE GEL.
HL COIL BRITE庐 2 of 4
INGESTION: DO NOT INDUCE VOMITING, RINSE MOUTH WITH WATER. DILUTE STOMACH
CONTENTS BY DRINKING WATER OR MILK. IF VOMITING OCCURS, KEEP HEAD
BELOW HIPS. CALL PHYSICIAN IMMEDIATELY.
INHALATION: REMOVE INDIVIDUAL TO FRESH AIR, IF BREATHING IS DIFFICULT,
ADMINISTER OXYGEN. IF BREATHING HAS STOPPED GIVE ARTIFICIAL
RESPIRATION. CALL PHYSICIAN.
SECTION 7 - SPECIAL PROTECTION
RESPIRATORY PROTECTION: USE A NIOSH/MSHA RESPIRATOR APPROVED FOR CONDITIONS OF
EXPOSURE OR IF EXPOSURE LIMITS ARE EXCEEDED.
EYE PROTECTION: CHEMICAL GOGGLES, FACE SHIELD.
VENTILATION: PROVIDE SUFFICIENT MECHANICAL (GENERAL AND/OR LOCAL EXHAUST)
VENTILATION TO MINIMIZE EXPOSURE.
SKIN PROTECTION: ACID PROOF GLOVES, IMPERVIOUS CLOTHING, RUBBER BOOTS.
OTHER PROTECTION: WASHING FACILITIES AND SAFETY SHOWERS SHOULD BE READILY
AVAILABLE.
SECTION 8 - ENVIRONMENTAL INFORMATION
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED:
WEAR PROTECTIVE EQUIPMENT. RECOVER FREE PRODUCT. SPILL SHOULD BE PLACED IN
SUITABLE CONTAINERS FOR DISPOSAL. RESIDUAL ACIDITY MAY BE NEUTRALIZED WITH
HYDRATED LIME, SODA ASH, SODIUM BICARBONATE.
WASTE DISPOSAL METHOD:
SMALL AND LARGE SPILL: DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE, AND
FEDERAL REGULATIONS. DO NOT ALLOW TO ENTER SEWERS & WATERWAYS.
THE FOLLOWING INFORMATION MAY BE USEFUL IN COMPLYING WITH VARIOUS STATE AND
FEDERAL LAWS AND REGULATIONS UNDER VARIOUS ENVIRONMENTAL STATUTES:
EPA REGULATION 302 (CERCLA SECTION 102): REPORTABLE QUANTITY (RQ) FOR AMMONIUM
BIFLUORIDE IS 100 LBS.
EPA REGULATION CFR 355 (SARA SECTION 301-302): NO THRESHOLD PLANNING QUANTITY FOR
PRODUCT OR ANY CONSTITUENT GREATER THAN 1% OR 0.1% (CARCINOGEN).
EPA REGULATION 40 CFR 370 - 372 (SARA SECTIONS 311-312): NONE
SECTION 9 - TRANSPORTATION INFORMATION
D.O.T. (49 CFR172):
11 LBS. CONTAINER AND UNDER: CONSUMER COMMODITY, ORM-D
OVER 11 LBS. CONTAINER: AMMONIUM HYDROGEN DIFLUORIDE, SOLID, 8, UN1727, II
POISON CONSTITUENT: NONE
BILL OF LADING DESCRIPTION:
CLEANING COMPOUND, IT 48581, CLASS 55
INTERNATIONAL (UN/NA CODE):
1KG. CONTAINER AND UNDER: AMMONIUM HYDROGEN DIFLUORIDE, SOLID, 8,
UN1727, II, LTD. QUANTITY
OVER 1KG. CONTAINER: AMMONIUM HYDROGEN DIFLUORIDE, SOLID, 8, UN1727, II
HL COIL BRITE庐 3 of 4
IMCO: EmS No. 8-06 CLASS 8
DATE PREPARED: 10 - 13 - 99 DATE UPDATED: 04/03/03
WHILE HIGHSIDE CHEMICALS, INC. BELIEVES THE DATA SET FORTH HEREIN ARE ACCURATE AS
OF THE DATE HEREOF, HIGHSIDE CHEMICALS, INC. MAKES NO WARRANTY WITH RESPECT
THERETO AND EXPRESSLY DISCLAIMS ALL LIABILITY FOR RELIANCE THEREON. SUCH DATA ARE
OFFERED SOLELY FOR YOUR CONSIDERATION, INVESTIGATION, AND VERIFICATION.
HL COIL BRITE庐 4 of 4
|