MATERIAL SAFETY HIGHSIDE CHEMICALS, INC.
DATA SHEET 11114 REICHHOLD ROAD
GULFPORT, MS 39503
(228)-896-9220
SUPER FLUSH
THIS MSDS COMPLIES WITH 29 CFR 1900.1200
SECTION 1 - IDENTITY/EMERGENCY INFORMATION
PRODUCT NAME: SUPER FLUSH PRODUCT CODES: 55032
CHEMICAL NAME: MIXTURE 55128
CHEMICAL FORMULA: MIXTURE 55055
IN CASE OF AN EMERGENCY CALL 1-800-255-3924
SECTION 2 - INGREDIENTS (HAZARDOUS)
COMPONENTS CAS NO. PEL/TLV - SOURCE
DIPROPYLENE GLYCOL METHYL ETHER 34590-94-8 100 ppm TWA, 150 ppm
STEL
(OSHA,ACGIH)
PROPYLENE GLYCOL BUTYL ETHER 5131-66-8 NOT ESTABLISHED
ALL COMPONENTS OF THIS PRODUCT ARE LISTED ON THE U.S. TSCA INVENTORY OR ARE EXEMPT
FROM TSCA INVENTORY REQUIREMENTS.
SECTION 3 - PHYSICAL DATA
pH : NOT APPLICABLE, NON AQUEOUS
VAPOR DENSITY (AIR = 1): ND
SPECIFIC GRAVITY (H2O = 1): 0.91 - 0.92
POUNDS PER GALLON: 7.6 - 7.7
SOLUBILITY OF WATER IN PRODUCT: >100g / 100g PRODUCT
APPEARANCE AND ODOR: CLEAR COLORLESS LIQUID. SLIGHT ETHER ODOR.
% VOLATILE (BY WEIGHT): 99+
FREEZE POINT: < -100掳 F
% VOLATILE ORGANIC COMPOUNDS: 99+
INITIAL BOILING POINT: 340掳 F
SECTION 4 - FIRE AND EXPLOSION HAZARD DATA
FLASH POINT (METHOD USED): 71.1掳 C (160掳 F) (ASTM D - 93)
EXTINGUISHING MEDIA: USE ALCOHOL FOAM, CARBON DIOXIDE OR DRY CHEMICAL
EXTINGUISHING MEDIA.
SPECIAL FIRE FIGHTING PROCEDURES: WEAR SELF-CONTAINED BREATHING APPARATUS IN THE
POSITIVE PRESSURE DEMAND MODE WHEN FIGHTING FIRES.
UNUSUAL FIRE AND EXPLOSION HAZARDS: AVOID ALL SOURCES OF
IGNITION - HEAT, SPARKS, OPEN FLAME. VAPORS ARE HEAVIER THAN AIR.
HAZARD RATING: HEALTH - 1 FLAMMABILITY - 2 REACTIVITY - 0
SECTION 5 - REACTIVITY DATA
1 of 3
HAZARDOUS POLYMERIZATION: CANNOT OCCUR
STABILITY: STABLE
INCOMPATIBILITY: AVOID CONTACT WITH STRONG OXIDIZING AGENTS. HAZARDOUS
DECOMPOSITION OR BYPRODUCTS: UNDER FIRE CONDITIONS: FUMES, SMOKE,
CARBON DIOXIDE, CARBON MONOXIDE, AND OTHER DECOMPOSITION PRODUCTS.
SECTION 6 - HEALTH HAZARD DATA
CARCINOGENICITY: NOT LISTED FOR ANY COMPONENT AT 0.1% OR GREATER.
PRIMARY ROUTE(S) OF ENTRY: SKIN CONTACT, ABSORPTION, EYE CONTACT, INHALATION
FIRST AID PROCEDURES:
SKIN CONTACT: THOROUGHLY WASH THE EXPOSED AREA WITH SOAP AND WATER.
REMOVE CONTAMINATED CLOTHING. LAUNDER CONTAMINATED CLOTHING BEFORE
RE-USE.
EYE CONTACT: FLUSH WITH LARGE AMOUNTS OF WATER, LIFTING UPPER AND LOWER
LIDS OCCASIONALLY. GET MEDICAL ATTENTION.
INGESTION: IMMEDIATELY DRINK A LARGE AMOUNT OF WATER. NEVER GIVE
ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. DO NOT INDUCE VOMITING. GET
MEDICAL ATTENTION IMMEDIATELY.
INHALATION: IF AFFECTED, REMOVE INDIVIDUAL TO FRESH AIR. IF BREATHING IS
DIFFICULT, ADMINISTER OXYGEN. IF BREATHING HAS STOPPED, GIVE ARTIFICIAL
RESPIRATION. KEEP PERSON WARM, QUIET, AND GET MEDICAL ATTENTION.
SECTION 7 - SPECIAL PRECAUTIONS
RESPIRATORY PROTECTION: IF WORK PLACE EXPOSURE LIMIT(S) OF PRODUCT OR ANY
COMPONENT IS EXCEEDED (SEE SECTION2). A NIOSH/MSHA APPROVED AIR SUPPLIED
RESPIRATOR IS ADVISED IN ABSENCE OF PROPER ENVIRONMENTAL CONTROL
ENGINEERING OR ADMINISTRATIVE CONTROLS SHOULD BE IMPLEMENTED TO REDUCE
EXPOSURE.
EYE PROTECTION: CHEMICAL SPLASH GOGGLES IN COMPLIANCE WITH OSHA REGULATIONS ARE
ADVISED; HOWEVER, OSHA REGULATIONS ALSO PERMIT OTHER TYPE SAFETY GLASSES
(CONSULT YOUR SAFETY EQUIPMENT SUPPLIER).
VENTILATION: PROVIDE SUFFICIENT MECHANICAL (GENERAL AND/OR LOCAL EXHAUST)
VENTILATION TO MAINTAIN EXPOSURE BELOW TLV(S).
PROTECTIVE GLOVES: WEAR RESISTANT GLOVES SUCH AS NEOPRENE.
OTHER PROTECTIVE EQUIPMENT: TO PREVENT REPEATED OR PROLONGED SKIN CONTACT, WEAR
IMPERVIOUS CLOTHING OR BOOTS.
SECTION 8 - ENVIRONMENTAL INFORMATION
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED:
SMALL SPILL OR LARGE SPILL: SPILL SHOULD BE CONTAINED AND PLACED IN SUITABLE
CONTAINER FOR DISPOSAL.
WASTE DISPOSAL METHOD:
SMALL SPILL OR LARGE SPILL: DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE,
AND FEDERAL REGULATIONS.
THE FOLLOWING INFORMATION MAY BE USEFUL IN COMPLYING WITH VARIOUS STATE AND
FEDERAL LAWS AND REGULATIONS UNDER VARIOUS ENVIRONMENTAL STATUTES:
EPA REGULATION CFR 302 (CERCLA SECTION 102):
NOT REGULATED
EPA REGULATION CFR 355 (SARA SECTION 301-302):
NO THRESHOLD PLANNING QUANTITY FOR PRODUCT OR ANY CONSTITUENT GREATER
THAN 1% OR 0.1% (CARCINOGEN).
EPA REGULATION 40 CFR 372 (SARA SECTION 313)
NOT REGULATED
2 of 3
EPA REGULATION 40 CFR 370 (SARA SECTIONS 311 - 312)
NOT REGULATED
SECTION 9 - SHIPPING INFORMATION
DOT (49 CFR 172): NOT REGULATED
BILL OF LADING: CLEANING COMPOUND IT 48580 S3
POISON CONSTITUENT : NONE
MARINE POLLUTANT: NO
DATE PREPARED: 02/01/98 DATE UPDATED: 04/03/03
WHILE HIGHSIDE CHEMICALS, INC. BELIEVES THE DATA SET FORTH HEREIN ARE ACCURATE AS
OF THE DATE HEREOF, HIGHSIDE CHEMICALS, INC. MAKES NO WARRANTY WITH RESPECT
THERETO AND EXPRESSLY DISCLAIMS ALL LIABILITY FOR RELIANCE THEREON. SUCH DATA ARE
OFFERED SOLELY FOR YOUR CONSIDERATION, INVESTIGATION, AND VERIFICATION.
3 of 3
|