MATERIAL SAFETY HIGHSIDE CHEMICALS, INC.
DATA SHEET 11114 REICHHOLD ROAD
GULFPORT, MS 39503
(228)-896-9220
HYPSI TRACE庐
THIS MSDS COMPLIES WITH 29 CFR 1900.1200
SECTION 1 - IDENTITY/EMERGENCY INFORMATION
PRODUCT NAME: HYPSI TRACE庐 PRODUCT CODES: 25004
CHEMICAL NAME: MIXTURE 25016
CHEMICAL FORMULA: MIXTURE 25128
IN CASE OF AN EMERGENCY CALL 1-800-255-3924
SECTION 2 - INGREDIENTS
COMPONENTS CAS NO. PEL/TLV - SOURCE
5 mg / m3 oilmist
PETROLEUM DISTILLATES 64742-52-5
OSHA, ACGIH
STEL 鈥? ACGIH
10mg / m3
ALL COMPONENTS OF THIS PRODUCT ARE LISTED ON THE U.S. TSCA INVENTORY.
SECTION 3 - PHYSICAL DATA
BOILING POINT: 鈩? 260EC
VAPOR PRESSURE: LESS THAN 0.1 mmHg @ 20EC
VAPOR DENSITY (AIR = 1): GREATER THAN 10
SPECIFIC GRAVITY (H2O = 1): 0.88
SOLUBILITY IN WATER: < 0.1%
APPEARANCE AND ODOR: AMBER OILY LIQUID. MILD PETROLEUM ODOR.
EVAPORATION RATE (n-Butyl Acetate = 1): LESS THAN 0.01
% VOLATILE (BY WT.): NEGLIGIBLE; LESS THAN 0.7%
SECTION 4 - FIRE AND EXPLOSION HAZARD DATA
FLASH POINT (METHOD USED): 370EF ASTM D 92 (COC)
AUTOIGNITION TEMPERATURE: GREATER THAN 260 EC (500 EF)
EXPLOSIVE LIMITS: LOWER: 0.9% UPPER: 7%
EXTINGUISHING MEDIA: USE WATER FOG, FOAM, CARBON DIOXIDE OR DRY CHEMICAL .
SPECIAL FIRE FIGHTING PROCEDURES: FIREFIGHTERS SHOULD BE EQUIPPED WITH SELF-
CONTAINED BREATHING APPARATUS AND TURN OUT GEAR. WATER MAY BE
INEFFECTIVE BUT SHOULD BE USED TO KEEP EXPOSED CONTAINERS COOL.
UNUSUAL FIRE AND EXPLOSION HAZARDS: AVOID ALL SOURCES OF IGNITION - HEAT,
SPARKS, OPEN FLAME.
HAZARD RATING: HEALTH - 1 FLAMMABILITY - 1 REACTIVITY - 0
SECTION 5 - REACTIVITY DATA
1 of 3
HYPSI TRACE庐
HAZARDOUS POLYMERIZATION: WILL NOT OCCUR
STABILITY: STABLE
HAZARDOUS DECOMPOSITION OR BYPRODUCTS: UNDER FIRE CONDITIONS: FUMES, SMOKE,
CARBON MONOXIDE, SULFUR OXIDES, ALDEHYDES AND OTHER DECOMPOSITION
PRODUCTS, IN THE CASE OF INCOMPLETE COMBUSTION.
MATERIALS TO AVOID: STRONG OXIDIZERS SUCH AS LIQUID CHLORINE, CONCENTRATED
OXYGEN, SODIUM HYPOCHLORITE, CALCIUM HYPOCHLORITE, ETC.
SECTION 6 - HEALTH HAZARD DATA
CARCINOGENICITY: NO CONSTITUENT OF 0.1% OR GREATER IN THIS PRODUCT IS LISTED BY
OSHA, NTP, OR IARC.
PRIMARY ROUTE(S) OF ENTRY: INHALATION, EYE AND SKIN CONTACT
POTENTIAL EFFECTS OF OVEREXPOSURE:
EYE: MAY CAUSE EYE IRRITATION.
SKIN: MAY CAUSE SKIN IRRITATION, DERMATITIS.
INGESTION: DO NOT TAKE INTERNALLY. MAY CAUSE NAUSEA AND DIARRHEA.
INHALATION: MAY CAUSE RESPIRATORY IRRITATION IF EXPOSED TO MIST.
FIRST AID PROCEDURES:
EYE CONTACT: IMMEDIATELY RINSE WITH RUNNING WATER FOR 15 MINUTES. IF
IRRITATION DEVELOPS, GET MEDICAL ATTENTION.
SKIN CONTACT: WASH AFFECTED AREAS WITH SOAP AND WATER. REMOVE AND
LAUNDER CONTAMINATED CLOTHING BEFORE REUSE. IF IRRITATION
DEVELOPS, GET MEDICAL ATTENTION.
INGESTION: IF INGESTED, DO NOT INDUCE VOMITING; CALL A PHYSICIAN
IMMEDIATELY.
INHALATION: IF AFFECTED, REMOVE INDIVIDUAL TO FRESH AIR, IF BREATHING IS
DIFFICULT, ADMINISTER OXYGEN. IF BREATHING HAS STOPPED GIVE
ARTIFICIAL RESPIRATION. KEEP PERSON WARM, QUIET AND GET MEDICAL
ATTENTION.
SECTION 7 - SPECIAL PROTECTION
RESPIRATORY PROTECTION: IF WORK PLACE EXPOSURE LIMITS OF PRODUCT OR ANY
COMPONENT IS EXCEEDED (SECTION 2), A NIOSH/MSHA APPROVED AIR SUPPLIED
RESPIRATOR IS ADVISED. IN ABSENCE OF PROPER ENVIRONMENTAL CONTROL,
ENGINEERING OR ADMINISTRATIVE CONTROLS SHOULD BE IMPLEMENTED TO REDUCE
EXPOSURE.
EYE PROTECTION: CHEMICAL SPLASH GOGGLES IN COMPLIANCE WITH OSHA REGULATIONS ARE
ADVISED; HOWEVER, OSHA REGULATIONS ALSO PERMIT OTHER TYPE SAFETY GLASSES
(ANSI Z87.1 OR EQUIVALENT).
VENTILATION: PROVIDE SUFFICIENT MECHANICAL (GENERAL AND/OR LOCAL EXHAUST)
VENTILATION TO MAINTAIN EXPOSURE BELOW TLV(S).
PROTECTIVE GLOVES: WEAR RESISTANT GLOVES SUCH AS: NEOPRENE
2 of 3
HYPSI TRACE庐
OTHER PROTECTIVE EQUIPMENT: TO PREVENT REPEATED EXPOSURE OR PROLONGED SKIN
CONTACT, WEAR IMPERVIOUS CLOTHING OR BOOTS.
SECTION 8 - ENVIRONMENTAL INFORMATION
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED:
SMALL AND LARGE SPILL: SPILL SHOULD BE CONTAINED AND PLACED IN SUITABLE
CONTAINERS FOR DISPOSAL.
PREVENT RUN OFF TO SEWERS, STREAMS OR OTHER BODIES OF WATER. IF RUN OFF
OCCURS, NOTIFY PROPER AUTHORITIES AS REQUIRED, THAT SPILL HAS OCCURRED.
WASTE DISPOSAL METHOD:
SMALL AND LARGE SPILL: DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE, AND
FEDERAL REGULATIONS.
THE FOLLOWING INFORMATION MAY BE USEFUL IN COMPLYING WITH VARIOUS STATE AND
FEDERAL LAWS AND REGULATIONS UNDER VARIOUS ENVIRONMENTAL STATUTES:
EPA REGULATION 302 (CERCLA SECTION 102):
NO REPORTABLE QUANTITY (RQ) FOR PRODUCT OR ANY CONSTITUENT
GREATER THAN 1% OR O.1% (CARCINOGEN).
EPA REGULATION CFR 355 (SARA SECTION 301-302):
NO THRESHOLD PLANNING QUANTITY FOR PRODUCT OR ANY CONSTITUENT GREATER
THAN 1% OR 0.1% (CARCINOGEN).
EPA REGULATION 40 CFR 372 (SARA SECTION 313):
QUANTITY PRESENT IS NOT REPORTABLE.
EPA REGULATION 40 CFR 370 (SARA SECTIONS 311-312):
NOT APPLICABLE FOR PRODUCT.
SECTION 9 - SHIPPING INFORMATION
D.O.T (49 CFR 172): NOT REGULATED
POISON CONSTITUENT: NONE
BILL OF LADING DESCRIPTION:
REFRIGERATION OIL IT 145000 S-2
INTERNATIONAL (UN/NA CODE): NONE
DATE PREPARED: 09/30/98 DATE UPDATED: 04/03/03
WHILE HIGHSIDE CHEMICALS, INC. BELIEVES THE DATA SET FORTH HEREIN ARE ACCURATE AS
OF THE DATE HEREOF, HIGHSIDE CHEMICALS, INC. MAKES NO WARRANTY WITH RESPECT
THERETO AND EXPRESSLY DISCLAIMS ALL LIABILITY FOR RELIANCE THEREON. SUCH DATA ARE
OFFERED SOLELY FOR YOUR CONSIDERATION, INVESTIGATION, AND VERIFICATION.
3 of 3
HYPSI TRACE庐
|