Osmose MATERIAL SAFETY DATA SHEET
TIMBERLIFE WOOD PRESERVING COMPOUND
MATERIAL SAFETY DATA SHEET:
SECTION I
148-Osm
MSDS NUMBER:
Osm
MSDS CODE:
N/A
SYNONYMS:
Osmose, Inc.
MANUFACTURED BY:
Utilities Division
DIVISION:
3008-68
EPA REGISTRATION NUMBER:
N/A
VENDOR:
CHEMTREC: 1(800) 424-9300
EMERGENCY PHONE:
716-882-5905
OTHER CALLS:
980 Ellicott Street, Buffalo, NY 14209
ADDRESS:
Teri Muchow
MSDS PREPARED BY:
March 28, 1991
DATE PREPARED:
July 12, 2000
DATE LAST REVISED:
鉁疉DDITIONAL INFORMATION鉁?
鉁?
CHEMTREC'S EMERGENCY TELEPHONE NUMBER IS TO BE USED ONLY IN THE EVENT OF CHEMICAL EMERGENCIES
INVOLVING A SPILL, LEAK, FIRE, EXPOSURE, OR ACCIDENT INVOLVING CHEMICALS.
SECTION II - HAZARDOUS INGREDIENTS/IDENTITY INFORMATION
TRADE NAME: Timberlife Wood
Preserving Compound
CAS OSHA PEL ACGIH TLV OTHER %
INGREDIENT NAME
3 3
Sodium Fluoride 7681-49-4 2.5 mg/M as F 2.5 mg/M as F RQ = 1000 pounds 44.42
0.2 mg/M3 0.2 mg/M3
Creosote Oil 8001-58-9 RQ = 1 pound 45.62
(CTPV) (CTPV)
0.1 mg/M3 0.1 mg/M3
Sodium Dichromate 10588-01-9 RQ = 10 pound 3.20
as Cr as Cr*
* Ceiling Concentration Limit
SECTION III - CHEMICAL CHARACTERISTICS
PERCENT VOLATILE THEORETICAL VOC
BOILING MELTING FREEZING SPECIFIC GRAVITY BY VOLUME CONTENT
POINT POINT POINT (H20 = 1) (PERCENT OF WEIGHT)
N/A N/A 1.41 25% N/A
500掳F
WEIGHT PER VAPOR VAPOR EVAPORATION RATE
GALLON pH: PRESSURE DENSITY DENSITY BASIS (N-BUAC) = 1
11.75 lbs/gal N/A .25 mm Hg N/A N/A 0.1
SOLUBILITY IN WATER: 50% REACTIVITY IN WATER: N/A
APPEARANCE AND ODOR: Black Mastic - Phenolic.
SECTION IV - FIRE AND EXPLOSION HAZARD DATA
FLASH POINT METHOD FLAMMABLE LIMITS IN AIR (%) AUTOIGNITION TEMPERATURE
TCC N/A N/A
155掳F
HEALTH 3 HEALTH 3
NFPA CODES HMIS CODES:
FLAMMABILITY 0 FLAMMABILITY 0
REACTIVITY 1 REACTIVITY 1
OTHER N/A PROTECTION B
EXTINGUISHER MEDIA: Foam, CO2, Dry Chemical
SPECIAL FIRE FIGHTING PROCEDURES: Toxic fume given off in fire. Wear full protective equipment with self-contained air unit.
UNUSUAL FIRE AND EXPLOSION HAZARDS: N/A
Timberlife Wood Preserving Compound
Page 1 of 3
Osmose MATERIAL SAFETY DATA SHEET
SECTION V - REACTIVITY DATA
IS THIS CHEMICAL STABLE UNDER NORMAL CONDITIONS OF HANDLING/STORAGE (Y/N)? Y
CONDITIONS TO AVOID (REGARDING STABILITY): N/A
INCOMPATIBILITY (MATERIALS TO AVOID): N/A
HAZARDOUS DECOMPOSITION PRODUCTS: Thermal: CO, CO2 and organic chlorides may be released at temperatures greater than
266掳 F.
HAZARDOUS POLYMERIZATION POSSIBLE (Y/N)? N
CONDITIONS TO AVOID (REGARDING POLYMERIZATION): N/A
SECTION VI - HEALTH HAZARDS
ROUTES OF ENTRY: Skin, eyes and inhalation.
SIGNS AND SYMPTOMS OF ACUTE OVEREXPOSURE: May be fatal if swallowed, inhaled or absorbed through the skin.
Skin - moderate skin irritant, which is reversible. If product is promptly removed the subject should not experience skin irritation.
Eyes - moderate eye irritant which is reversible. If the contaminant is promptly irrigated form the eye, the subject should not
experience irritation. Inhalation - this is an unlikely exposure. Effects are respiratory difficulty, nausea and salvation.
CHRONIC OVEREXPOSURE: Avoid prolonged and repeated dermal contact.
CHEMICAL LISTED AS A CARCINOGEN OR POTENTIAL CARCINOGEN?:
鈥? NATIONAL TOXICOLOGY PROGRAM (Y/N): Y
鈥? IARC MONOGRAPHS (Y/N): Y
鈥? OSHA (Y/N): Y
MEDICAL CONDITIONS GENERALLY AGGRAVATED BY EXPOSURE: Pre-existing respiratory disease including asthma and emphysema.
TOXICITY DATA
Acute Oral LD50 1,100 mg/kg
Dermal LD50 > 2,000 mg/kg
Primary Eye Irritation severely irritating to unwashed eye
Dermal Irritation Severe skin irritant (PDII was 5.1)
Skin Sensitization NOT a skin sensitizer
EMERGENCY AND FIRST AID PROCEDURES
EMERGENCY PHONE NUMBER OF MANUFACTURER: CHEMTREC 1(800) 424-9300
1. INHALATION: Remove to fresh air. Apply respiration if indicated. Call a physician immediately.
2. EYE CONTACT: Flush eyes with plenty of water. Call a physician immediately.
3. SKIN CONTACT: Remove contaminated clothing and wash affected area with soap and water. Get medical attention
4. INGESTION: Call a physician or Poison Control Center. Drink 1 or 2 glasses of water and induce vomiting by touching the back
of throat with finger. Do not induce vomiting or give anything by mouth to an unconscious person.
SECTION VII - PRECAUTIONS FOR SAFE HANDLING AND USE
US SHIPPING DESCRIPTION: Environmentally Hazardous Substances, Solid, 9, UN3077, III, RQ (Creosote, Sodium Fluoride)
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE: Use good personal hygiene. Wash hands before smoking or eating and
after work. Do not store near open flames. Store in tightly closed containers.
OTHER PRECAUTIONS: Read and follow label instructions.
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED: Scoop up with shovel and place in a metal container. If only
minor contamination with dirt or other foreign matter, recovered product may be reused.
WASTE DISPOSAL METHODS: Used or dirty pails or cartons should be punctured and/or disposed of in an approved dump site or buried in
a sanitary waste landfill. Do not give pails away for other uses or leave in any area not designated for dumping. Dispose in accordance with
Federal, State and local laws.
SECTION VIII - CONTROL MEASURES
RESPIRATORY PROTECTION: Normally not needed (outdoor use).
VENTILATION REQUIREMENTS: None under normal use of product.
PROTECTIVE GLOVES: Polyvinyl acetate (PVA), polyvinyl chloride (PVC) or neoprene.
EYE PROTECTION: Chemical goggles recommended or safety glasses with side shields.
OTHER PROTECTIVE CLOTHING OR EQUIPMENT: Applicators must wear long sleeves, long pants, and an impermeable apron
during the application process.
WORK/HYGIENIC PRACTICES: Launder contaminated clothing before reuse. Use good personal hygiene. Wash hands before eating or
smoking.
Timberlife Wood Preserving Compound
Page 2 of 3
Osmose MATERIAL SAFETY DATA SHEET
SECTION IX - REGULATORY INFORMATION:
CALIFORNIA PROPOSITION 65:
WARNING - This product contains CEOSOTE and a CHROMIUM COMPOUND, chemicals known to the State of California to
cause cancer.
SARA/TITLE III ;SECTION 312 - HAZARD CATEGORIES:
Immediate (Acute) Health: Yes Reactive Hazard: No
Delayed (Chronic) Health: Yes Sudden Release of Pressure: No
Fire Hazard: Yes
SECTION 302:
N/A
SECTION 304:
Creosote has a reportable quantity of 1 pound, potassium bichromate has a reportable quantity of 10 pounds.
SECTION 311 & 312:
Report if inventory exceeds 10,000 pounds on any given day.
SECTION 313:
This mixture contains CREOSOTE and POTASSIUM BICHROMATE, chemicals subject to the reporting requirements of section 313 of Title
III of the Superfund Amendments and Reauthorization Act of 1986 and 40 CFR Part 372.
HAZARDOUS MATERIALS INFORMATION SYSTEM (HMIS)
PERSONAL PROTECTION INDEX
N/A = Not Applicable
NOTICE: The information herein is given in good faith but no warranty, expressed or implied, is made, and Osmose, Inc.
expressly disclaims liability from reliance on such information.
Information on this form is furnished for the purpose of compliance with the Occupational Safety and Health Act of
1970 and shall not be used for any other purpose. Use or dissemination of all or any part of this information for any
other purpose may result in a violation of law or constitute grounds for legal action.
Timberlife Wood Preserving Compound
Page 3 of 3
|