09000
SHERWIN-WILLIAMS CO -- PROMAR 200 INTERIOR LATEX EG-SHEL ENAMEL, PURE
WHITE BASE X -- 0000-
=======================================================
MSDS Safety Information
=======================================================
MSDS Date: 05/19/1998
MSDS Num: CKYGR
Tech Review: 02/05/2001
Product ID: PROMAR 200 INTERIOR LATEX EG-SHEL ENAMEL, PURE WHITE BASE X
Responsible Party
Cage: DO693
Name: THE SHERWIN-WILLIAMS CO
Address: 101 PROSPECT AVENUE N.W.
City: CLEVELAND OH 44115
Country: NK
Info Phone Number: (216) 556-2917
Emergency Phone Number: 216-566-2917
=======================================================
Contractor Summary
=======================================================
Cage: DO693
Name: THE SHERWIN-WILLIAMS CO
Address: 101 PROSPECT AVENUE N.W.
City: CLEVELAND OH 44115 US
Phone: 216-566-2902
=======================================================
Ingredients
=======================================================
Cas: 112-34-5
RTECS #: KJ9100000
Name: 2-(2-BUTOXYETHOXY)ETHANOL
Percent by Wt: 2.
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
Ozone Depleting Chemical: N
------------------------------
Cas: 107-21-1
RTECS #: KW2975000
Name: ETHYLENE GLYCOL
= Wt: 3.
Code: C
OSHA PEL: 50 PPM
ACGIH TLV: 50 PPM
EPA Rpt Qty: 1 LB
DOT Rpt Qty: 1 LB
Ozone Depleting Chemical: N
------------------------------
Cas: 1332-58-7
RTECS #: GF1670500
Name: KAOLIN
= Wt: 6.
OSHA PEL: 5 MG/M3
ACGIH TLV: 2 MG/M3
ACGIH STEL: NOT ESTABLISHED
Ozone Depleting Chemical: N
------------------------------
Cas: 471-34-1
RTECS #: FF9335000
Name: CALCIUM CARBONATE
= Wt: 2.
OSHA PEL: 15 MG/M3
ACGIH TLV: 10 MG/M3
Ozone Depleting Chemical: N
------------------------------
Cas: 13463-67-7
RTECS #: XR2275000
Name: TITANIUM DIOXIDE
= Wt: 14.
OSHA PEL: 15 MG/M3
ACGIH TLV: 10 MG/M3
ACGIH STEL: NOT ESTABLISHED
Ozone Depleting Chemical: N
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Explanation Of Carcinogenicity: ETHYLENE GLYCOL IS CONSIDERED AN ANIMAL
TERATOGEN. IT HAS BEEN SHOWN TO CAUSE BIRTH DEFECTS IN RATS AND MICE
AT HIGH DOSES WHEN GIVEN IN DRINKING WATER OR BY GAVAGE. THERE IS NO
EVIDENCE TO INDICATE IT CAUSES BIRTH DEFECTS IN HUMANS. PROLONGED
OVEREXPOSURE TO SOLVENT INGREDIENTS IN SECTION II MAY CAUSE ADVERSE
EFFECTS TO THE LIVER AND URINARY SYSTEM.
Signs And Symptions Of Overexposure: IRRITATION OF EYES, SKIN AND UPPER
RESPIRATORY SYSTEM. IN A CONFINED AREA VAPORS IN HIGH CONCENTRATION
MAY CAUSE HEADACHE, NAUSEA OR DIZZINESS. REDNESS AND ITCHING OR BURNING
SENSATION MAY INDICATE EYE OR EXCESSIVE SKIN EXPOSURE.
Medical Cond Aggravated By Exposure: NONE GENERALLY RECOGNIZED.
First Aid: INHALATION: IF AFFECTED, REMOVE FROM EXPOSURE. RESTORE
BREATHING. KEEP WARM AND QUIET. SKIN: WASH AFFECTED AREA THOROUGHLY
WITH SOAP AND WATER. REMOVE CONTAMINATED CLOTHING AND LAUNDER BEFORE
RE-U SE. EYES: FLUSH EYES WITH LARGE AMOUNTS OF WATER FOR 15
MINUTES.
GET MEDICAL ATTENTION. INGESTION: GET MEDICAL ATTENTION.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: REMOVE ALL SOURCES OF IGNITION. VENTILATE
AND
REMOVE WITH INERT ABSORBENT.
Waste Disposal Methods: WASTE FROM THIS PRODUCT IS NOT HAZARDOUS AS
DEFINED UNDER THE RESOURCE CONSERVATION AND RECOVERY ACT 40 CFR 261.
INCINERATE IN APPROVED FACILITY. DO NOT INCINERATE CLOSED CONTAINER.
DISPOSE OF IN A CCORDANCE WITH FEDERAL, STATE, AND LOCAL REGULATIONS
REGARDING POLLUTION.
Handling And Storage Precautions: KEEP CONTAINER CLOSED WHEN NOT IN
USE.
TRANSFER ONLY TO APPROVED CONTAINERS WITH COMPLETE AND APPROPRIATE
LABELING. DO NOT TAKE INTERNALLY. KEEP OUT OF THE REACH OF
CHILDREN.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Extinguishing Media: CARBON DIOXIDE, DRY CHEMICAL, ALCOHOL FOAM
Fire Fighting Procedures: FULL PROTECTIVE EQUIPMENT INCLUDING
SELF-CONTAINED BREATHING APPARATUS SHOULD BE USED. WATER SPRAY MAY
BE INEFFECTIVE. IF WATER IS USED, FOG NOZZLES ARE PREFERABLE. WATER MAY
BE USED TO COOL CONTAI NERS TO PREVENT PRESSURE BUILD-UP AND POSSIBLE
AUTOIGNITION OR EXPLOSION WHEN EXPOSED TO EXTREME HEAT.
Unusual Fire/Explosion Hazard: CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT.
=======================================================
Control Measures
=======================================================
Respiratory Protection: IF PERSONAL EXPOSURE CANNOT BE CONTROLLED BELOW
APPLICABLE LIMITS BY VENTILATION, WEAR A PROPERLY FITTED ORGANIC
VAPOR/PARTICULATE RESPIRATOR APPROVED BY NIOSH/MSHA FOR PROTECTION
AGAINST MATERIALS IN SECTION II. WHEN SANDING OR ABRADING THE DRIED
FILM, WEAR A DUST/MIST RESPIRATOR APPROVED BY NIOSH FOR DUST WHICH
MAY
BE GENERATED FROM THIS PRODUCT.
Ventilation: LOCAL EXHAUST PREFERABLE. GENERAL EXHAUST ACCEPTABLE IF THE
EXPOSURE TO MATERIALS IN SEC II IS MAINTAINED BELOW APPLICABLE
EXPOSURE LIMITS.
Protective Gloves: WEAR GLOVES WHICH ARE RECOMMENDED BY GLOVE SUPPLIER.
Eye Protection: WEAR SAFETY SPECTACLES WITH UNPERFORATED SIDESHIELDS.
Supplemental Safety and Health: WT/GAL = 10.59 LBS/GAL. CODES:
HEALTH=2;FLAMMABILITY=0;REACTIVITY=0.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: 212-448 F
Vapor Density: >AIR
Spec Gravity: 1.27
VOC Pounds/Gallon: 1.21
PH: 9.5
Evaporation Rate & Reference: SLOWER THAN ETHER
Percent Volatiles by Volume: 60%
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE KNOWN.
Materials To Avoid: NONE KNOWN.
Hazardous Decomposition Products: BY FIRE: CARBON DIOXIDE, CARBON
MONOXIDE
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
Toxicological Information: RATS EXPOSED TO TITANIUM DIOXIDE DUST AT 250
MG/M3 DEVELOPED LUNG CANCER, HOWEVER, SUCH EXPOSURE LEVELS ARE NOT
ATTAINABLE IN THE WORKPLACE.
=======================================================
Ecological Information
=======================================================
=======================================================
MSDS Transport Information
=======================================================
=======================================================
Regulatory Information
=======================================================
Sara Title III Information: SARA 313 SUPPLIER NOTIFICATION: ETHYLENE
GLYCOL
Federal Regulatory Information: TSCA CERTIFICATION: ALL CHEMICALS IN
THIS PRODUCT ARE LISTED, OR ARE EXEMPT FROM LISTING ON THE TSCA
INVENTORY.
State Regulatory Information: CALIFORNIA PROPOSITION 65: WARNING! THIS
PRODUCT CONTAINS CHEMICALS KNOWN TO THE STATE OF CALIFORNIA TO CAUSE
CANCER. ETHYLENE GLYCOL
=======================================================
Other Information
=======================================================
Other Information: THE ABOVE INFORMATION PERTAINS TO THIS PRODUCT AS
CURRENTLY FORMULATED, AND IS BASED ON THE INFORMATION AVAILABLE AT
THIS TIME. ADDITION OF REDUCERS OR OTHER ADDITIVES TO THIS PRODUCT MAY
SUBSTANTIAL LY ALTER THE COMPOSITION AND HAZARDS OF THE PRODUCT.
SINCE
CONDITIONS OF USE ARE OUTSIDE OUR CONTROL, WE MAKE NO WARRANTIES,
EXPRESS OR IMPLIED, AND ASSUME NO LIABILITY IN CONNECTION WITH ANY
USE OF THIS INFORMATION.
=======================================================
HAZCOM Label
=======================================================
Product ID: PROMAR 200 INTERIOR LATEX EG-SHEL ENAMEL, PURE WHITE BASE X
Cage: DO693
Company Name: THE SHERWIN-WILLIAMS CO
Street: 101 PROSPECT AVENUE N.W.
City: CLEVELAND OH
Zipcode: 44115 US
Health Emergency Phone: 216-566-2917
Date Of Label Review: 02/05/2001
=======================================================
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever
expressly or implied warrants, states, or intends said information to
have any application, use or viability by or to any person or persons
outside the Department of Defense nor any person or persons contracting
with any instrumentality of the United States of America and disclaims
all liability for such use. Any person utilizing this instruction who
is not a military or civilian employee of the United States of America
should seek competent professional advice to verify and assume
responsibility for the suitability of this information to their
particular situation regardless of similarity to a corresponding
Department of Defense or other government situation.
|