Part Number(s):
MATERIAL SAFETY DATA SHEET 55-00X-XX
Form WI04-11A Rev. 1
Product Name: GAC Alginate Regular Release Date: March 14, 2007
1. Product and Company Identification
Trade Name & Synonyms MSDS Code Number
GAC Alginate Regular Refer to part number
Chemical Name Manufacture / Distributor
NA GAC International Inc.
C.A.S. Number Address
NA 355 Knickerbocker Ave.
Bohemia, NY USA 11716
Grades or Minor Variant Identities Information Telephone Number
NA 1-631-419-1700
Product Use (for Canada) Emergency Telephone Number
NA 1-631-419-1700
2. Composition of Ingredients
Hazardous Components OSHA PEL ACGIH TLV C.A.S. Number Exposure Limits %
( MG/M3) (MG/M3)
Crystalline silica-cristobalite 0.05 0.05 NA NA NA
Crystalline silica- Quartz NA NA NA
0.05 0.05
Amorphous silica- 1.2 10 NA NA NA
Diatomaceous earth
Calcium sulfate 10 10 NA NA NA
Tetrasodium pyrophosphate 5 5 NA NA NA
Sodium alginate 15 10 NA NA NA
(as nuisance dust)
Magnesium oxide 15 10 NA NA NA
(as nuisance dust)
NA NA NA
WARNING: This product contains silica, crystalline
(airborne particles of respirable size) which is known by
the state of California to cause cancer.
Other information: Product contains synthetic yellow iron
oxide as colorant.
Page 1 of 5
Part Number(s):
MATERIAL SAFETY DATA SHEET 55-00X-XX
Form WI04-11A Rev. 1
Product Name: GAC Alginate Regular Release Date: March 14, 2007
3. Hazard Identification
Emergency Overview
NA
Routes of Signs and Symptoms Single, Repeated, or Severity (Mild, Acute and Chronic Target
Exposure Lifetime Exposure Moderate, Severe) Health Effect(s) Organ(s)
Temporary irritation or Acute: Eye irritation.
Eye NA NA NA
inflammation.
NA NA
Skin NA NA NA
No
Irritation and soreness in Acute: Transitory upper respiratory
Inhalation NA NA NA
throat and nose. In irritation.
Yes
extreme exposures some Chronic: Inhalation of crystalline
congestion may occur. silica has been classified by IARC
as carcinogenic for humans (Group
1). Inhalation of crystalline silica is
also a known cause of silicosis, a
non-cancerous lung disease caused
by excessive exposure to crystalline
silica. Respirable dust from this
product may contain up to 52% free
crystalline silica (Cristobalite). As
such it represents a risk to the
respiratory system. Long term.
Unprotected exposure to dust levels
in excess of the TLV or PEL may
cause lung disease (silicosis).
Not hazardous when
Ingestion NA NA NA NA
ingested.
Yes
NA NA NA NA NA
Other
Medical Conditions Aggravated by Exposure
Pre-existing upper respiratory and lung diseases such as, but not limited to, bronchitis, emphysema, and asthma. Target organs: Lungs, eyes.
Carcinogenicity (IARC, NTP)
NTP?: Proposed IARC Monographs?: Yes (group1) OSHA regulated?: Yes
Potential Environmental Effects
NA
4. First Aid Measures
Routes of Exposure First Aid Instructions Immediate Medical Attention Delayed Effects
For eyes flush with copious If irritation persists consult a
Eye NA
amounts of water for 15 minutes. physician.
Skin NA NA
Remove to fresh air. Drink water
Inhalation NA NA
to clear throat and blow nose to
evacuate dust.
Ingestion NA NA NA
Other NA NA NA
Note to Physicians (Treatment, Testing, and Monitoring)
NA
Page 2 of 5
Part Number(s):
MATERIAL SAFETY DATA SHEET 55-00X-XX
Form WI04-11A Rev. 1
Product Name: GAC Alginate Regular Release Date: March 14, 2007
5. Fire and Explosion Data
Flashpoint & Method: Flammable (Explosive) Limits in Air Autoignition Temperature Other
掳C / 掳F N/A LEL: N/A UEL: N/A NA
NA
Properties Contributing to Flammability Classification
Flame Propagation or Burning
Fire Intensity Health- 2, Flammability-0, Reactivity-0
NA
NA Specific hazard N/E. NFPA-National
fire protection association.
Extinguishing Media Extinguishing Media to Avoid
N/A NA
Protection and Procedures for Firefighters
N/A
Unusual Fire and Explosion Hazards
In common with most organic materials, this product should be treated as a combustible dust in the finely divided and suspended state.
6. Accidental Release Measures
Containment Techniques
NA
Spill/Leak Clean-Up Procedures and Equipment
Vacuum clean dust with equipment fitted with a HEPA filter. Use dust suppression such as water if sweeping is necessary. Sweep up spilled
material and place in closed containers for disposal.
Evacuation Procedures
NA
Special Instructions
NA
Reporting Requirements
NA
7. Handling and Storage
Handling Practices and Warnings
Minimize dust generation and accumulation. Avoid breathing dust, avoid contact with eyes. Return cap to canisters immediately. Close pouches
immediately after use. Continue to follow all MSDS/ label warnings when handling empty containers. Observe normal warehouse handling
procedures.
Storage Practices and Warnings
(掳C / 掳F). Store in a cool dry area. Store away from foodstuffs and beverages.
Other precautions: The avoidance of any air contaminant is always a recommended practice. Adherence to work place ventilation standards is an
assurance of general personnel health and comfort.
Page 3 of 5
Part Number(s):
MATERIAL SAFETY DATA SHEET 55-00X-XX
Form WI04-11A Rev. 1
Product Name: GAC Alginate Regular Release Date: March 14, 2007
8. Exposure Control/Personal Protection
Ventilation Other Engineering Controls
Use sufficient natural or mechanical ventilation to keep dust level NA
below PEL.
Routes of Entry: Personal Protective Equipment (PPE) for Normal Use: PPE for Emergencies:
Eye/Face NA
Goggles or safety glasses with side shields.
Skin NA
Rubber gloves.
Inhalation NA
Recommended NIOSH approved nuisance dust mask. <10 X PEL, use
3M 9900 ;< 100 X PEL, use MSA ultra-twin with H filter; <200 X PEL,
use MSA 01-00-06 with type C supplied air unit (continuous flow
mode); or equivalent.
General Hygiene Considerations and Work Practices
Avoid dusting when in use, Observe normal care when working with chemicals.
Protective Measures During Repair and Maintenance of Contaminated Equipment
NA
Other Protective Measures and Equipment
Rubber apron.
9. Physical and Chemical Characteristics
Appearance Odor
Yellow colored, dry fluffy powder. Spearmint odor
Boiling Point 掳C / 掳F N/A
Normal Physical State:
Liquid Gas
Melting Point 掳C / 掳F N/A
Solid powder (Other) Freezing Point 掳C / 掳F NA
Specific Gravity or Density (H20=1) Solubility in Water pH
0.3 g / cm3 Partially soluble. NA
Vapor Pressure (mm Hg @ 20掳C) Vapor Density (AIR= 1) Evaporation Rate (Butyl Acetate = 1)
N/A N/A N/A
Other
NA
10. Stability and Reactivity Data
Incompatibility (Materials to Avoid)
Hydrofluoric acid
Hazardous Products Produced During Decomposition
N/A
Hazardous Polymerization? Conditions to Avoid
High humidity and water contamination will cause material to gel.
May Occur May Not Occur
Prolonged exposure to heat greater than 60 掳C / (140)掳F
Stability? Conditions to Avoid
Stable Unstable High humidity and prolonged heat greater than 60掳C / 掳F
11. Toxicological Information
Toxicity Data, Epidemiology Studies, Carcinogenicity, Neurological Effects, Genetic or Reproductive Effects, or Structure Activity Data
NA
Page 4 of 5
Part Number(s):
MATERIAL SAFETY DATA SHEET 55-00X-XX
Form WI04-11A Rev. 1
Product Name: GAC Alginate Regular Release Date: March 14, 2007
12. Ecological Information
Toxicity, Environmental Fate, Physical/Chemical Data, or Other Data Supporting Environmental Hazard Statements
NA
13. Disposal Considerations
Regulations
Dispose of in accordance with federal, state and local regulations.
Properties (Physical/Chemical) Affecting Disposal
NA
14. Transport Information
Regulated for shipping? Proper Shipping Name Packing Group
GAC Alginate NA
Yes No NA
Hazard Class Identification Number
Do changes in quantity, packaging, or shipment method change product classification?
NA NA
Yes No NA
Other
NA
15. Regulatory Information
Federal Regulations
NA
International Regulations
NA
Other
NA
16. Other Information
Supplier Number: 2/ 55 Supplier Release: October 18, 1999
N/A = not applicable. NA = not available, N/E = not established. N/D = not determined.
Page 5 of 5
|