SECTION 4: FIRE AND EXPLOSION HAZARD DATA
MATERIAL SAFETY DATA SHEET Extinguishing Media: N/A
COTRONICS 700 SERIES CASTABLE CERAMICS Flash Point (Method Used) : N/A
Flammable Limit: N/A
RTC-60 Castable Alumina Ceramic 760 Liquid Zirconium Oxide Unusual Fire And Explosive Hazards: LEL = N/A
RTC-70 Castable Alumina Ceramic 770 Liquid Silicon Carbide Special Fire Fighting Procedures: UEL = N/A
740 Liquid Alumina Silica 780 Liquid Alumina
750 Liquid Fused Silica 310LF Liquid Ceramic Foam SECTION 5: HEALTH HAZARD DATA
Primary Route Of Entry: Inhalation.
Effects of Overexposure: Nuisance dust may cause Nasal, Throat or Lung irritation or
Manufactures Name: COTRONICS CORPORATION
discomfort May aggravate Bronchial disorders. Slight dermatological irritation after
3379 Shore Parkway Brooklyn, NY 11235
prolonged skin contact.
Emergency Telephone Number: 718-646-7996
Emergency And First Aid Procedures: Flush eyes and skin with copious quantities of
water. Get immediate medical attention for eyes. If swallowed, consult physician
SECTION ONE
immediately.
Chemical Name And Synonyms: N/A Mixture
Formula: N/A
SECTION 6: FIRE, EXPLOSIVE AND REACTIVITY DATA
Base (part A) : Powder
Stability: Stable
Chemical Family: Refractory Ceramic Composition. Proprietary Alumina, Zirconia,
Incompatibility (Materials to Avoid) : None
Silica, Silicon Carbide.
Hazardous Decomposition Products: None
Activator (Part B) : Liquid
Hazardous Polymerization: Will Not Occur
Chemical Family: Proprietary Water Based Colloid Composition (Alumina, Silica)
All materials contained within are listed on the TOSCA Inventory list.
SECTION 7: SPILL OR LEAK PROCEDURES
Steps to be Taken in Case Material is Released or Spilled:
SECTION 2: COMPOSITION INFORMATION
Sweep up spilled powder and dispose in approved industrial waste container.
A. As Manufactured WT. % TVL/PEL
Hose spilled neat cement paste with water, immediately. Cement is not water soluble
Base: Respirable Nuisance Dust 100 5 mg/cu m*
after setting up. Waste Disposal Method: Approved industrial waste disposal means.
* (1984-85 ACGIH TLV Booklet, Page 50)
SECTION 8: SPECIAL PROTECTION INFORMATION
SECTION 3A: BASE (POWDER) PHYSICAL DATA Respiratory Protection (Specify Type) :
Boiling Point (掳F) : N/A Dust respirator in compliance with OSHA Standard currently 29 CFR 1910.134
Specific Gravity Range (H2O = 1) : 0.9 - 3.1 (NIOSH approved, air purifying , half mask or full face-piece respirator with appropriate
Vapor Pressure (mm Hg.) : N/A filter pad or cartridge (s)).
Vapor Density (Air=1) : N/A Ventilation: Local Exhaust: Follow OSHA Standard 29 CFR 1910.94.
Percent Volatile by Volume (%) : N/A Mechanical (General) : Follow OSHA Standard 29 CFR 1910.94.
Solubility in Water: Insoluble
Evaporation Rate (=1) : N/A SECTION 8: SPECIAL PRECAUTIONS
Appearance and Odor: Fine Powdered Matrix with Coarse Aggregate. This product as manufactured contains silicate which could transform upon heating to mullet and
No Odor. crystolbalite (a form of crystalline silica). Removal of this product after use may result in the generation
of dust. Repeated inhalation of respirable free crystalline silica is derived from the formula
10 mg/cu m
SECTION 3B: ACTIVATOR (LIQUID) PHYSICAL DATA
陆(----------)#
Activator Supplied with RTC-70, 740, 750, 760, 780, 360LF
% Respirable quartz +
Boiling Point (掳F) : 212
*(Reference 1984-85 ACGIH TLV Booklet, Page 34). Appropriate ventilation should be provided
Specific Gravity Range (H2O = 1) : 1.25 - 2.1
and protective equipment should be worn in compliance with OSHA standard currently 29 CFR
Vapor Pressure (mm Hg.) : 24 @ 77掳F
1910.134 (NIOSH approved, air purifying, half mask or full face-piece respirator with appropriate
Vapor Density (Air=1) : Water
filter pad or cartridge(s)).
Percent Volatile by Weight (%) : 50- 70
Solubility in Water: Soluble Disclaimer: The information supplied is not to be taken as a warranty or representation for which
Evaporation Rate (=1) : 1 Cotronics Corp. assumes legal responsibility. It is offered solely for your consideration,
Appearance and Odor: Opalescent liquid No Odor. investigation and verification. all risk of use, singly or in combination with other products, whether
or not in accordance with the instructions, directions, or suggestions is borne by the user.
DATE PREPARED: 11/01/85 DATE REVISED: 08/5/03
HIMS RATING Health = 1 Fire = 0 Reactivity = 0 HAZARD RATING: 0 = Insignificant 1 = Non-Toxic, Slight 2 = Moderate 3 = High 4 = Extreme
|