Toxicity: Liquid is an eye irritant.
Primary Routes of Entry: Skin, ingestion, inhalation
LOCTITE CORPORATION 09/11/96
ROCKY HILL, CONNECTICUT 06067
EMERGENCY PHONE: (860) 571-5100
MATERIAL SAFETY DATA SHEET Page 02 of 05
Product Name: Super Weatherstrip Adhesive
Item No.: 81731
3. HAZARDS IDENTIFICATION (continued)
Signs and symptoms
of Exposure: Vapors can irritate eyes, nose, throat and skin
and can cause headache, nausea. Possible narcosis
at high concentrations.
Existing Conditions
Aggravated by Exposure: None known
Literature Referenced Carcinogen
Ingredients Target Organ and Other Health Effects NTP IARC OSHA
Neoprene No Data NO N/A NO
ACETONE BLO CNS IRR NO NO NO
METHYL ETHYL KETONE CNS IRR NO N/A NO
Rubber solvent (naphtha) No Data NO NO NO
TOLUENE CAR CNS DEV IRR NO NO NO
-------------------------------------------------------------------------------
Abbreviations
N/A Not Applicable BLO Blood
CAR Cardiac CNS Central nervous system
DEV Developmental IRR Irritant
4. FIRST AID MEASURES
Ingestion: Do not induce vomiting. Keep individual calm.
Obtain medical attention.
Inhalation: Remove to fresh air. If symptoms persist, obtain
medical attention.
Skin Contact: Wash with soap and water.
Eye Contact: Flush with water at least 15 minutes. Obtain
medical attention.
5. FIRE FIGHTING MEASURES
Flash Point: Less than 0掳F Method: Tag Closed Cup
Recommended
Extinguishing Agents: Carbon dioxide, foam, dry chemical
Hazardous Products formed
by Fire or Thermal Decomp Irritating Organic Vapors.
Unusual Fire or
Explosion Hazards: Vapors may cause flash fires and may ignite
explosively. Heat will cause build up of pressure
in closed container.
Product Name: Super Weatherstrip Adhesive
Item No.: 81731
5. FIRE FIGHTING MEASURES (continued)
(% by volume in air)Lower 1.2%
(% by volume in air)Upper 13%
6. ACCIDENTAL RELEASE MEASURES
Steps to be taken in case
of spill or leak: Remove all sources of ignition. Maintain adequate
ventilation. Soak up in an inert absorbent and
store in a closed container until disposal.
7. HANDLING AND STORAGE
Safe Storage: Store away from heat and flames.
(Contact Loctite Customer Service 1-800-243-4874 for shelf Life information)
Handling: Avoid prolonged breathing of vapors. Keep away
from eyes. Avoid prolonged skin contact.
Do not use near sources of ignition.
8. EXPOSURE CONTROLS, PERSONAL PROTECTION
Eyes: Safety glasses or goggles.
Skin: Rubber or plastic gloves.
Ventilation: Sufficient to maintain vapor concentration below
TLV and lower explosive limit. Explosive proof
equipment should be used.
See Section 2 for Exposure Limits.
9. PHYSICAL AND CHEMICAL PROPERTIES
Appearance: Yellow, stringy liquid.
Odor: Ketone
Boiling Point: 115掳F
pH: Does not apply
Solubility in Water: Slight
Specific Gravity 0.89
Volatile Organic Compound
(EPA Method 24) 69.8%
Vapor Pressure: 185mm at 100掳F
Vapor Density: 2.0
Evaporation Rate
(Ether = 1) Not available
10. STABILITY AND REACTIVITY
Stability: Stable
Hazardous Polymerization: Will not occur
Incompatibility: Strong oxidizers.
LOCTITE CORPORATION 09/11/96
ROCKY HILL, CONNECTICUT 06067
EMERGENCY PHONE: (860) 571-5100
MATERIAL SAFETY DATA SHEET Page 04 of 05
Product Name: Super Weatherstrip Adhesive
Item No.: 81731
Recommended methods of
disposal: Incinerate following EPA and local regulations.
EPA Hazardous Waste
Number D001/D035 - Hazardous waste per 40CFR 261.21 and
a TCLP waste per 261.24/Methyl Ethyl Ketone.
14. TRANSPORT INFORMATION
DOT (49 CFR 172)
Domestic Ground Transport
Proper Shipping Name: Consumer Commodity (Not more than one liter);
Adhesives (More than one liter)
Hazard Class or
Division: ORM-D (Not more than one liter);
Class 3, Packing Group II (More than one liter)
Identification Number: None (Not more than one liter);
UN 1133 (More than one liter)
Marine Pollutant: None
IATA
Proper Shipping Name: Adhesives
Class or Division: Class 3, Packing Group II
UN or ID Number: UN 1133
15. REGULATORY INFORMATION
CA Proposition 65: WARNING: This product contains a chemical known to
the State of California to cause birth
defects or other reproductive harm.
16. OTHER INFORMATION
Estimated NFPA(R) Code:
Health Hazard: 3
Fire Hazard: 3
Reactivity Hazard: 0
LOCTITE CORPORATION 09/11/96
ROCKY HILL, CONNECTICUT 06067
EMERGENCY PHONE: (860) 571-5100
MATERIAL SAFETY DATA SHEET Page 05 of 05
Product Name: Super Weatherstrip Adhesive
Item No.: 81731
16. OTHER INFORMATION (continued)
Specific Hazard: Does not apply
Estimated HMIS(R) Code:
Health Hazard: 3
Flammability Hazard: 3
Reactivity Hazards: 0
Personal Protection: See Section 8.
NFPA is a registered trademark of the National Fire Protection Assn.
HMIS is a registered trademark of the National Paint and Coatings Assn.
Prepared By: Stephen Repetto
Title: Research Chemist, Health and Safety
Company: Loctite Corp., 1001 Tr Br Cr, Rocky Hill CT 06067
(24hr.) Phone: (860) 571-5100
Revision Date: January 22, 1996 Revision: 0025
ALL Chemical Property And Toxicity Analysis PAGES IN THIS GROUP