MATERIAL SAFETY DATA SHEET
BK101 Page: 1
PRODUCT NAME: MIGHTY VS7 CHLORINATED BRAKE CLEANER HMIS CODES: H F R P
PRODUCT CODE: BK101 2*2 0
================== SECTION I - DISTRIBUTOR IDENTIFICATION ==================
DISTRIBUTOR'S NAME : MIGHTY DISTRIBUTING SYSTEM OF AMERICA
ADDRESS : 650 ENGINEERING DRIVE
NORCROSS, GA 30092
EMERGENCY PHONE : 770-448-3900 DATE PRINTED : 6/13/2003
INFORMATION PHONE : 770-448-3900 NAME OF PREPARER : ESP
========== SECTION II -HAZARDOUS INGREDIENTS/SARA III INFORMATION =========
VAPOR PRESSURE WEIGHT
REPORTABLE COMPONENTS CAS NUMBER mm Hg @ TEMP PERCENT
--------------------------------------------------------------------------------
* PERCHLOROETHYLENE 127-18-4 13 68 97.5
OSHA PEL: 100 PPM, ACGIH TLV: 50 PPM, STEL: 200 PPM
CARBON DIOXIDE 124-38-9 38650 60 3
OSHA PEL: 10000 PPM, ACGIH TLV: 5000 PPM
* Indicates toxic chemical(s) subject to the reporting requirements of
section 313 of Title III and of 40 CFR 372.
=============== SECTION III - PHYSICAL/CHEMICAL CHARACTERISTICS ============
BOILING RANGE: 250 deg F SPECIFIC GRAVITY (H2O=1): 1.58
VAPOR DENSITY: HEAVIER THAN AIR EVAPORATION RATE: SLOWER THAN ETHER
SOLUBILITY IN WATER: NIL
APPEARANCE AND ODOR: AEROSOL PRODUCT; COLORLESS LIQUID; MILDLY SWEET
================= SECTION IV - FIRE AND EXPLOSION HAZARD DATA ==============
FLASH POINT: None METHOD USED: n/a
FLAMMABLE LIMITS IN AIR BY VOLUME- LOWER: n/a UPPER: n/a
EXTINGUISHING MEDIA: FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG
SPECIAL FIREFIGHTING PROCEDURES
WATER MAY BE USED TO COOL CONTAINERS TO PREVENT PRESSURE BUILD-UP AND EXPLOSION
WHEN EXPOSED TO EXTREME HEAT. IF WATER IS USED, FOG NOZZLES ARE PREFERRED. WEAR
GOGGLES AND SELF-CONTAINED BREATHING APPARATUS.
UNUSUAL FIRE AND EXPLOSION HAZARDS
KEEP CONTAINERS FROM HEAT AND OPEN FLAME. CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. OVEREXPOSURE TO DECOMPOSITION PRODUCTS MAY CAUSE A
HEALTH HAZARD. SYMPTOMS MAY NOT BE READILY APPARENT. OBTAIN MEDICAL ATTENTION.
======================== SECTION V - REACTIVITY DATA =======================
STABILITY: STABLE
CONDITIONS TO AVOID
APPLICATION TO HOT SURFACES.
INCOMPATIBILITY (MATERIALS TO AVOID)
UNKNOWN.
HAZARDOUS DECOMPOSITION OR BYPRODUCTS
MATERIAL SAFETY DATA SHEET
BK101 Page: 2
MAY PRODUCE FUMES WHEN HEATED TO DECOMPOSITION. FUMES MAY CONTAIN CARBON
MONOXIDE, CHLORINE, AND HYDROGEN CHLORIDE.
HAZARDOUS POLYMERIZATION: WILL NOT OCCUR
==================== SECTION VI - HEALTH HAZARD DATA =======================
INHALATION HEALTH RISKS AND SYMPTOMS OF EXPOSURE
RESPIRATORY IRRITATION, HEADACHE, NAUSEA, FATIGUE, DROWSINESS, IMPAIRED CO-
ORDINATION.
SKIN AND EYE CONTACT HEALTH RISKS AND SYMPTOMS OF EXPOSURE
SKIN: CONTACT MAY DRY THE SKIN; PROLONGED CONTACT MAY CAUSE IRRITATION. EYES:
LIQUID OR VAPOR CAN IRRITATE; PROLONGED CONTACT MAY LEAD TO CORNEAL DAMAGE.
SKIN ABSORPTION HEALTH RISKS AND SYMPTOMS OF EXPOSURE
NOT EASILY ABSORBED. SOLVENT ACTION CAN DRY AND DEFAT THE SKIN CAUSING THE SKIN
TO CRACK, LEADING TO DERMATITIS.
INGESTION HEALTH RISKS AND SYMPTOMS OF EXPOSURE
NOT A LIKELY ROUTE OF EXPOSURE. IF SWALLOWED, DO NOT INDUCE VOMITING. SEEK
IMMEDIATE MEDICAL ADVICE AND/OR ATTENTION.
HEALTH HAZARDS (ACUTE AND CHRONIC)
ACUTE: EYE IRRITANT. SKIN IRRITANT. NARCOTIC IN HIGH CONCENTRATIONS. CHRONIC:
LIVER AND KIDNEY DISEASE. SKIN IRRITATION AND DERMATITIS.
CARCINOGENICITY: NTP CARCINOGEN: Yes IARC MONOGRAPHS: Yes OSHA REGULATED: Yes
THIS PRODUCT CONTAINS A CHEMICAL KNOWN TO THE STATE OF CALIFORNIA TO CAUSE
CANCER.
MEDICAL CONDITIONS GENERALLY AGGRAVATED BY EXPOSURE
ACUTE AND CHRONIC LIVER AND KIDNEY DISEASE, ANEMIA, CORONARY DISEASE OR RHYTHM
DISORDERS OF THE HEART.
EMERGENCY AND FIRST AID PROCEDURES
INHALATION: REMOVE TO FRESH AIR. ADMINISTER OXYGEN IF NEEDED. APPLY ARTIFICIAL
RESPIRATION IF BREATHING HAS STOPPED. GET MEDICAL ATTENTION. INGESTION: DO NOT
INDUCE VOMITING; CALL A DOCTOR. IF CONDITIONS REMAIN, GET MEDICAL ATTENTION.
SKIN: WIPE OFF WITH TOWEL. WASH WITH SOAP AND WATER. GET MEDICAL ATTENTION IF
IRRITATION PERSISTS. EYES: WASH IMMEDIATELY WITH LARGE VOLUMES OF FRESH WATER
FOR AT LEAST 15 MINUTES. GET MEDICAL ATTENTION.
=========== SECTION VII - PRECAUTIONS FOR SAFE HANDLING AND USE ============
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED
AVOID BREATHING VAPORS. VENTILATE AREA. DIKE AREA TO CONTAIN SPILL. CLEAN UP
AREA WITH ABSORBENT MATERIAL AND PLACE IN CLOSED CONTAINERS FOR DISPOSAL.
WASTE DISPOSAL METHOD
DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE, AND FEDERAL REGULATIONS. BEFORE
ATTEMPTING CLEAN UP, REFER TO OTHER SECTIONS OF THIS MSDS FOR HAZARD CAUTION
INFORMATION.
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING
STORE AND USE IN COOL, DRY, WELL-VENTILATED AREAS. AVOID CONTACT WITH HOT METAL
SURFACES. KEEP AWAY FROM EXCESSIVE HEAT OR OPEN FLAME. CONTENTS UNDER PRESSURE.
DO NOT PUNCTURE OR INCINERATE CONTAINER OR STORE ABOVE 120 DEGREES F.
MATERIAL SAFETY DATA SHEET
BK101 Page: 3
OTHER PRECAUTIONS
TO RETARD OR PREVENT THE RELEASE OF AIRBORNE PARTICULATE MATTER DURING THE USE
OF THIS PRODUCT, CAREFULLY FOLLOW THE LABEL DIRECTIONS FOR USE. THE STORAGE OF
NON-FLAMMABLE PRODUCTS WITH NON-FLAMMABLE OR FLAMMABLE PRESSURIZING AGENT, IN
CARTONS, IS THE SAME AS FOR ORDINARY CANNED GOODS IN CARTONS. STORAGE SHOULD BE
IN AREAS SUITABLE FOR LEVEL 1 AEROSOLS.
===================== SECTION VIII - CONTROL MEASURES ======================
RESPIRATORY PROTECTION
IN RESTRICTED AREAS, USE APPROVED CHEMICAL/MECHANICAL FILTERS DESIGNED TO REMOVE
A COMBINATION OF PARTICLES AND VAPOR. IN CONFINED AREAS, USE APPROVED AIR LINE
TYPE RESPIRATOR OR HOOD. SELF-CONTAINED BREATHING APPARATUS IS REQUIRED FOR
VAPOR CONCENTRATIONS ABOVE PEL/TLV LIMITS.
VENTILATION
SUFFICIENT TO PREVENT INHALATION OF SOLVENT VAPORS. GENERAL DILUTION AND/OR
LOCAL EXHAUST VENTILATION IN VOLUME OR PATTERN TO KEEP PEL/TLV OF MOST HAZARDOUS
INGREDIENT BELOW ACCEPTABLE LIMIT AND LEL BELOW STATED LIMIT.
PROTECTIVE GLOVES
SOLVENT RESISTANT REQUIRED FOR PROLONGED OR REPEATED CONTACT.
EYE PROTECTION
SAFETY GLASSES WITH SPLASH GUARDS OR FULL FACE SHIELD.
OTHER PROTECTIVE CLOTHING OR EQUIPMENT
SOLVENT RESISTANT APRON.
WORK/HYGIENIC PRACTICES
EYE WASHES AND SAFETY SHOWERS IN THE WORKPLACE ARE RECOMMENDED.
========================= SECTION IX - DISCLAIMER ==========================
THE INFORMATION CONTAINED HEREIN IS BASED ON DATA CONSIDERED ACCURATE. HOWEVER,
NO WARRANTY IS EXPRESSED OR IMPLIED REGARDING THE ACCURACY OF THE DATA OR THE
RESULTS TO BE OBTAINED FROM THE USE THEREOF. BECAUSE THE INFORMATION CONTAINED
HEREIN MAY BE APPLIED UNDER CONDITIONS BEYOND OUR CONTROL, WE ASSUME NO
RESPONSIBILITY FOR ITS USE.
|