SUPERCOOL PAG 46, 100, 150
MATERIAL SAFETY DATA SHEET
Emergency Phone Number: 561-582-2245 Date: May 15, 2000
SECTION 1 COMPANY IDENTIFICATION AND CHEMICAL PRODUCT
Company Name: TSI, Inc.
Address: 932 South Dixie Highway, Lake Worth, Florida 33460
Phone/Fax: 561-582-2245 / 561-582-1499
Trade Name: PAG Refrigeration Compressor Lubricant.
Chemical Name: Synthetic Polyalkylene glycol hydrocarbon mixture
Chemical Family: Synthetic Polyalkylene glycol hydrocarbon mixture
Formula: Proprietary
CAS#: Proprietary
Applications: PAG Refrigeration Compressor Lubricant is used as a fluid in HFC and other
refrigeration systems.
SECTION 2 COMPOSITION / INFORMATION ON INGREDIENTS
General: This Product contains No Known Carcinogens. No Special Warning Labels Are Required
Under OSHA 29 CFR 1910.1200.
FDA Statement: N/A
SECTION 3 HAZARDS IDENTIFICATION
Appearance: Clear liquid, orange tint.
Known Hazards: This product does not require any special warning labels under OSHA 29 CFR 1910.1200
and contains no hazardous ingredients. Product is slight Eye and Skin irritant.
SECTION 4 FIRST AID MEASURES
Eyes: Flush with clean, lukewarm water (low pressure) occasionally lifting eyelids. Physician
assessment if eyes are inflamed.
Skin: Wash affected areas thoroughly with soap and water. Wash contaminated clothing before
reuse.
Inhalation: Avoid breathing oil mists. Remove to fresh air. Give artificial respiration if not breathing.
Oxygen may be given by qualified personnel if breathing is difficult. Get medical
attention.
Ingestion: Do not induce vomiting. Force fluids. Has laxative effect.
SECTION 5 FIRE FIGHTING MEASURES
Flash Point: 440潞F min
Flammable Limits: N/A
Auto Ignition Temp: N/A
Fire & Explosion Hazards: LOW FIRE HAZARD - Do not cut, drill, or weld empty containers.
Extinguishing Media: Dry chemical foam, water spray, carbon dioxide for small fires.
Fire Fighting Procedures: Contain liquid, cover with extinguishing agent, use water spray to cool fire exposed
containers and as protective screen. Do not point solid water stream directly into burning
fluid to avoid spreading.
SECTION 6 ACCIDENTAL RELEASE MEASURES
Spill or Leak: Contain Spill, absorb with inert absorbent such as dry clay, sand, diatomaceous earth,
commercial sorbents or recover using pumps. Scoop up used absorbents into approved
receptacles.
Waste Disposal: Dispose in approved, secure landfill site or through a licensed waste reclaimer.
TSI-4055-100-1-05/00 NR-Not Regulated N/A-Not Applicable U-Unknown Page 1 of 2
SECTION 7 HANDLING AND STORAGE
Storage Temp - min / max: None / 104潞F recommended
Shelf Life: Indefinite in original container
Precautions: Not for internal use. Avoid contact with skin, eyes, clothing.
SECTION 8 EXPOSURE CONTROL / PERSONAL PROTECTION
Eye Protection: Chemical Goggles if splashing is likely or high pressure systems are used.
Skin Protection: For direct contact of more than 2 hours, PVC or Nitrile gloves are recommended.
Respiratory Protection: Normally not necessary. If mist is generated, wear approved organic respirator suitable
for oil mist areas with sufficient oxygen.
Ventilation: General ventilation.
Exposure Limits: Acute LD50 > 2000 mg/Kg (rat : oral)
SECTION 9 PHYSICAL AND CHEMICAL PROPERTIES
Appearance: Clear liquid, orange tint.
Boiling Point: >200潞C
Vapor Pressure: <0.001 kPa @ 25潞C
Specific Gravity: 0.85-.097
Volatiles, % Volume: 0%
Odor: Characteristic odor
Solubility in Water: Slight
Evaporation Rate: Nil
Viscosity: @40潞C Varies depending on grade
SECTION 10 REACTIVITY
Stability: Product is STABLE
Hazardous Polymerization: Will not occur.
Incompatibilities: Strong oxidizers.
Decomposition Products: Analogous compounds evolve, carbon monoxide, carbon dioxide, and other undefined
fragments when burned.
SECTION 11 TOXICOLOGICAL INFORMATION
General: Acute LD50 > 2000 mg/Kg (rat : oral)
SECTION 12 ECOLOGICAL INFORMATION
General: Biodegradable CEC L33A93 > 80% @ 45 Days.
SECTION 13 DISPOSAL CONSIDERATIONS
Waste Disposal: Used product must be disposed of in accordance with Federal, State, and Local
environmental control regulations. Incineration is preferred. DO NOT HEAT OR CUT
EMPTY CONTAINERS WITH ELECTRIC OR GAS TORCH.
SECTION 14 TRANSPORTATION INFORMATION
Technical Name: Synthetic Polyalkylene glycol hydrocarbon mixture
D.O.T. Hazard Class: NR
U.N. / N.A. #: NR
Product Label: PAG Refrigeration Compressor Lubricant
SECTION 15 REGULATORY INFORMATION
OSHA STATUS: Non-Hazardous under 29 CFR 1910.1200
TSCA STATUS: N/A
RCRA STATUS: If discarded in its purchased form this product would not be a hazardous waste either by
listing or characteristic. However, it is the responsibility of the product user to determine
at the time of disposal, whether the material being disposed of is a hazardous waste (40
CFR 261.20-24).
SECTION 16 OTHER INFORMATION
General: This information is furnished without warranty, expressed or implied, except that is
accurate to the best knowledge of TSI, Inc. The data on this sheet related only to the
specific material designed herein. TSI, Inc. assumes no legal responsibility for the use or
reliance upon these data.
TSI-4055-100-1-05/00 NR-Not Regulated N/A-Not Applicable U-Unknown Page 2 of 2
|