NAPHTHA (PETROLEUM), HEAVY ALKYLATE 1382
March 2001
Low boiling point modified naphtha
CAS No: 64741-65-7
Aliphatic HC's, iso-paraffins
RTECS No:
UN No: 1268
EC No: 649-275-00-4
TYPES OF
ACUTE HAZARDS/SYMPTOMS PREVENTION FIRST AID/FIRE FIGHTING
HAZARD/
EXPOSURE
Flammable. NO open flames, NO sparks, and Water spray, alcohol-resistant
FIRE
NO smoking. foam, powder, carbon dioxide.
Above 44掳C explosive vapour/air Above 44掳C use a closed system, In case of fire: keep drums, etc.,
EXPLOSION
mixtures may be formed. ventilation, and explosion-proof cool by spraying with water.
electrical equipment.
EXPOSURE PREVENT GENERATION OF
MISTS!
Dizziness. Headache. Drowsiness. Ventilation, local exhaust, or Fresh air, rest. Refer for medical
Inhalation
Nausea. Unconsciousness. breathing protection. attention.
Dry skin. Protective gloves. Remove contaminated clothes.
Skin
Rinse skin with plenty of water or
shower.
Redness. Safety goggles. First rinse with plenty of water for
Eyes
several minutes (remove contact
lenses if easily possible), then take
to a doctor.
Cough. Diarrhoea. Sore throat. Do not eat, drink, or smoke during Do NOT induce vomiting. Refer for
Ingestion
Vomiting. (Further see Inhalation). work. medical attention. See Notes.
SPILLAGE DISPOSAL PACKAGING & LABELLING
Ventilation. Collect leaking and spilled liquid in T Symbol
sealable containers as far as possible. Absorb R: 45-65
remaining liquid in sand or inert absorbent and S: 53-45
remove to safe place. Do NOT wash away into Note: H, P
sewer. (Extra personal protection: filter respirator for UN Hazard Class: 3
organic vapours of low boiling compounds.) UN Pack Group: III
EMERGENCY RESPONSE STORAGE
Transport Emergency Card: TEC (R)-30G35 Fireproof. Separated from strong oxidants. Well closed.
NFPA Code: H1; F3; R0
Prepared in the context of cooperation between the International
IPCS Programme on Chemical Safety and the European Commission
International 漏 IPCS 2000
Programme on
Chemical Safety SEE IMPORTANT INFORMATION ON THE BACK.
1382 NAPHTHA (PETROLEUM), HEAVY ALKYLATE
IMPORTANT DATA
Physical State; Appearance Routes of exposure
COLOURLESS LIQUID The substance can be absorbed into the body by inhalation of
its vapour and by ingestion.
Physical dangers
Inhalation risk
The vapour is heavier than air and may travel along the ground;
distant ignition possible. No indication can be given about the rate in which a harmful
concentration in the air is reached on evaporation of this
substance at 20掳C.
Chemical dangers
Reacts with strong oxidants, causing fire and explosion hazard.
Effects of short-term exposure
The vapour is slightly irritating to the eyes. The substance may
Occupational exposure limits
cause effects on the central nervous system. Exposure to high
TLV not established. MAK not established.
concentration of vapours may result in unconsciousness.
Swallowing the liquid may cause aspiration into the lungs with
the risk of chemical pneumonitis.
Effects of long-term or repeated exposure
The liquid defats the skin. See Notes.
PHYSICAL PROPERTIES
Boiling point: 172-215掳C Vapour pressure, kPa at 20掳C: 0.1-0.2
Melting point: -30掳C Flash point: = 44掳C c.c. Auto-ignition temperature: 355 掳C
Density: 0.75-0.79 g/cm3 Explosive limits, vol% in air: 0.6-8.0
Solubility in water: none
ENVIRONMENTAL DATA
The substance is toxic to aquatic organisms.
NOTES
This is a mixture of C9-C14 iso- and n-paraffins. Neither the concentration of aromatics nor of hexane is greater than 0.1 % by
volume. Note P: the EU classification as carcinogen (R45) does not apply if it can be shown that the benzene content is below 0.1%
by volume. Depending on the raw material and the production processes, the composition and physical properties of this solvent
can vary considerably. The symptoms of chemical pneumonitis do not become manifest until a few hours or even a few days have
passed. Isopar G / L / M, Shellsol T / TK / TD, Soltrol 100 / 130, among others, are trade names.
ADDITIONAL INFORMATION
Neither the EC nor the IPCS nor any person acting on behalf of the EC or the IPCS is responsible
LEGAL NOTICE for the use which might be made of this information
漏IPCS 2000
|