MATERIAL SAFETY DATA SHEET
-------------------------------------------- I. PRODUCT IDENTIFICATION -------------------------------
TRADE NAME (as labeled LATAPOXY庐 300 Epoxy Adhesive Part C
CHEMICAL FAMILY: Proprietary Blend
MANUFACTURER'S NAME: LATICRETE INTERNATIONAL, INC.
1 Laticrete Park, N. Reviewed & Approved By:
Steven B. Fine
Bethany, CT 06524-3423 USA
Steven B. Fine
Sr. Research Chemist/Safety Officer
Phone number for additional information: (203) 393-0010
Date prepared or revised: 6/04 Name of preparer: S.B. Fine
-------------------------------------------- II. HAZARDOUS INGREDIENTS ----------------------------
OTHER
CHEMICAL NAMES CAS PERCENT ACGIH TLV OSHA PEL (SPECIFY)
NUMBERS
Silica Sand 14808-60-7 50 - 90 50 micro g/m鲁 10 mg/m鲁 N/A
Aluminum Oxide 1344-28-1 0-4 10 mg/m鲁 15 mg/m鲁 N/A
Titanium Dioxide 13463-67-1 0 - 12 10 mg/m鲁 15 mg/m鲁 N/A
N/A = Not applicable or available
------------------------------------------ III. HEALTH HAZARD INFORMATION -----------------------
SYMPTOMS OF OVEREXPOSURE for each potential route of exposure. (Possible Longer Term
Effects) Inhaled: Symptoms are dyspnea-caused by many lung scars that develop from the dust-pain
in chest, decreased vital Chronic lung scarring leads to a progressive massive fibrosis that is often
accompanied by increased susceptibility to the risk of impaired health due to a combination of
smoking and dust exposure. Persons with reduced pulmonary function may be at increased risk.
capacity and cough. Inhalation of the dust can cause silicosis and may cause lung cancer depending
on duration and level of exposure
SIGNS AND SYMPTOMS OF EXPOSURE (Acute effects) Eye contact may cause eye irritation.
Inhalation of dust may cause lung irritation.
SUSPECTED CANCER AGENT?
NO: This product's ingredients are not found in the lists below.
YES: Federal OSHA NTP x IARC
------------------------------IV. FIRST AID: EMERGENCY PROCEDURES-----------------------------------------
300c.doc Page 1
Eye Contact: Hold eyelids apart and immediately flush eyes with plenty of water for at least 15
minutes. Get medical attention immediately.
Skin Contact: If irritation occurs, remove affected clothing and wash the skin exposed.
Inhaled: Remove to fresh area. For extreme respiratory distress, administer oxygen.
Swallowed Refer to physician
---------------------------------------------- V. FIRE AND EXPLOSION ------------------------------------------
Flash Point method): Non Flammable or combustible
Auto ignition temperature,掳F: N/A
Flammable limits in air, volume %: Lower (LEL) Upper (UEL)
Fire extinguishing materials:
x water spray x carbon dioxide other:
x foam x dry chemical
Special fire fighting procedures: Wear self-contained breathing apparatus with full face piece and
protective clothing.
Unusual fire and explosion hazards: This product may form explosive dust clouds in air.
----------------------------------- VI. SPILL, LEAK, AND DISPOSAL PROCEDURES -----------------------
Spill response procedures (include employee protection measures): Clean up with dustless method
(use vacuum or wet sweeping). Wear NIOSH approved dust mask, safety glasses, gloves.
Preparing wastes for disposal (container types, neutralization, etc.): N/A
NOTE: Dispose of all wastes in accordance with federal, state and local regulations.
------------------------------------------VII. Handling and Storage----------------------------------------------------------
Store in cool dry area.
-------------------------------------- VIII. Exposure Controls and Personal Protection ------------------------------
Ventilation and engineering controls: normal ventilation
Respiratory protection (type): NIOSH approved disposable dust mask if PEL is exceeded
Eye protection (type): safety glasses
Gloves (specify material): cloth or impermeable gloves
Other clothing and equipment: long sleeved clothing
Work practices, hygienic practices: normal good housekeeping
Other handling and storage requirements: keep away from strong alkalis and oxidizers
Protective measures during maintenance of contaminated equipment: Wear NIOSH approved dust
mask, safety glasses, gloves
------------------------------------------------ IX. PHYSICAL PROPERTIES ----------------------------
300c.doc Page 2
Vapor density (air=1): N/A Melting point or range,掳F: N/A
Boiling point or range, 掳F: N/A
Specific gravity: 2.3
Solubility in water: Insoluble Evaporation rate (butyl acetate = 1): N/A
Vapor pressure, mmHg at 20掳C: N/A VOC: 0 lb/gal
Appearance and odor: odorless free flowing colored powder
HOW TO DETECT THIS SUBSTANCE (warning properties of substance as a gas, vapor, dust, or
mist): N/A
---------------------------------------------------- X. REACTIVITY DATA -----------------------------------------------
Stability: x Stable Unstable
Conditions to avoid: N/A
Incompatibility (materials to avoid): Exposure to hydrofluoric acid or strong alkalis or oxidizers.
Hazardous decomposition products (including combustion products): (from burning, heating, or
reaction with other materials). May release carbon monoxide, carbon dioxide, nitrogen oxide,
ammonia upon combustion.
Hazardous polymerization: May occur x Will not occur
Conditions to avoid: Exposure to strong oxidizers or alkalis
-----------------------------------------------XI. Toxicology Information-------------------------------------------------
N/A
-----------------------------------------------XII. Ecological Information-------------------------------------------------
N/A
-----------------------------------------------XIII. Disposal Information--------------------------------------------------
Dispose in compliance with local, state, and federal regulations.
------------------------------------------------XIV. Transport Information---------------------------------------------------
No special labeling or transportation placarding is required.
------------------------------------------------XV. Regulatory Information--------------------------------------------------
All ingredients are listed on the U.S. EPA TSCA inventory of chemical substances.
This product contains a chemical known to the State of California to cause cancer or reproductive
harm.
------------------------------------------------XVI Other Information---------------------------------------------------------
This information is furnished without warranty, representation, inducement or license of any kind;
except that it is accurate to the best of our knowledge, or obtained from sources believed by us to be
accurate.
300c.doc Page 3
|