MATERIAL SAFETY DATA SHEET
-------------------------------------------- I. PRODUCT IDENTIFICATION -------------------------------
TRADE NAME (as labeled): LATAPOXY庐 310 Rapid Setting Stone Adhesive Part B
CHEMICAL FAMILY: Epoxy Resin
MANUFACTURER'S NAME: LATICRETE INTERNATIONAL, INC.
1 Laticrete Park, N. Reviewed & Approved By:
Steven B. Fine
Bethany, CT 06524-3423 USA
Steven B. Fine
Sr. Research Chemist/Safety Officer
Phone number for additional information: (203) 393-0010
Date prepared or revised: 10/05 Name of preparer: S.B. Fine
-------------------------------------------- II. HAZARDOUS INGREDIENTS ----------------------------
OTHER
CHEMICAL NAMES CAS PERCENT ACGIH TLV OSHA PEL (SPECIFY)
NUMBERS
Epoxy Resin 25068-38-6 <50% NE
Surfactant 9004-87-9 <5% NE
Wolastinite 13983-17-0 <5% 10 Mg/M3
Ti02 13463-67-7 <5% 10 Mg/M3
Limestone 16389-88-1 >25% 10 Mg/M3
Alumina Silicate (Fly 68131-74-8 >10% 10 Mg/M3
Ash)
N/A = Not applicable or available
------------------------------------------ III. HEALTH HAZARD INFORMATION -----------------------
SYMPTOMS OF OVEREXPOSURE for each potential route of exposure. (Possible Longer Term
Effects) Skin 鈥? Prolonged and repeated contact may cause irritation and result in sensitization and
allergic reaction.
SIGNS AND SYMPTOMS OF EXPOSURE (Acute effects)
Skin Contact 鈥? May cause irritation, sensitization and dermatitis.
Inhalation 鈥? May cause Irritation or sensitization.
Eyes 鈥? Vapor may cause irritation, redness and tearing. Paste may cause severe irritation with
possible irreversible injury
SUSPECTED CANCER AGENT?
x NO: This product's ingredients are not found in the lists below.
YES: Federal OSHA NTP IARC
------------------------------IV. FIRST AID: EMERGENCY PROCEDURES-----------------------------------------
310rsb.doc Page 1
Eye Contact: Hold eyelids apart and immediately flush eyes with plenty of water for at least 15
minutes. Get medical attention immediately.
Skin Contact: Wash thoroughly with soap and water. If irritation develops and persists, see a
physician. Wash clothes before reuse.
Inhaled: Remove to fresh air. If not breathing give artificial respiration, preferably mouth to mouth. If
breathing is difficult, give oxygen, call a physician.
Swallowed May cause gastrointestinal distress, irritation ulceration. Drink large quantities of water,
consult a physician.
---------------------------------------------- V. FIRE AND EXPLOSION ------------------------------------------
Flash Point method): 4900F
Auto ignition temperature,掳F: N/A
Flammable limits in air, volume %: Lower (LEL) Upper (UEL)
Fire extinguishing materials:
x water spray x carbon dioxide other:
foam x dry chemical
Special fire fighting procedures: Wear full protective gear and NIOSH/MSHA approved self-contained
breathing apparatus.
Unusual fire and explosion hazards: Decomposition and combustion products may be toxic.
----------------------------------- VI. SPILL, LEAK, AND DISPOSAL PROCEDURES -----------------------
Spill response procedures (include employee protection measures): Absorb spill on sand, earth or
vermiculite. Carefully collect into closed containers for disposal according to federal, state or local
regulation. Wear safety glasses, Organic chemical cartridge respirator, impermeable gloves, and
long sleeved clothing.
Preparing wastes for disposal (container types, neutralization, etc.):
NOTE: Dispose of all wastes in accordance with federal, state and local regulations.
------------------------------------------VII. Handling and Storage----------------------------------------------------------
Store in cool dry area.
-------------------------------------- VIII. Exposure Controls and Personal Protection ------------------------------
310rsb.doc Page 2
Ventilation and engineering controls: Normal ventilation
Respiratory protection (type): Organic chemical cartridge respirator, if TLV exceeded.
Eye protection (type): Safety glasses or goggles
Gloves (specify material): Rubber or polyethylene gloves
Other clothing and equipment: long sleeved clothing
Work practices, hygienic practices: Normal good housekeeping
Other handling and storage requirements: N/A
Protective measures during maintenance of contaminated equipment: See above.
------------------------------------------------ IX. PHYSICAL PROPERTIES ----------------------------
Vapor density (air=1): N/A Melting point or range,掳F: N/A
Boiling point or range, 掳F: >200
Specific gravity: 1.5
Solubility in water: Insoluble Evaporation rate (butyl acetate = 1): N/A
Vapor pressure, mmHg at 20掳C: N/A
Appearance and odor: Off white paste
HOW TO DETECT THIS SUBSTANCE (warning properties of substance as a gas, vapor, dust, or
mist):
---------------------------------------------------- X. REACTIVITY DATA -----------------------------------------------
Stability: x Stable Unstable
Conditions to avoid: N/A
Incompatibility (materials to avoid): Strong oxidizers, acids and epoxy curing agents.
Hazardous decomposition products (including combustion products): (from burning, heating, or
reaction with other materials).N/A
Hazardous polymerization: May occur x Will not occur
Conditions to avoid: N/A
-----------------------------------------------XI. Toxicology Information-------------------------------------------------
N/A
-----------------------------------------------XII. Ecological Information-------------------------------------------------
N/A
-----------------------------------------------XIII. Disposal Information--------------------------------------------------
310rsb.doc Page 3
Dispose in compliance with local, state, and federal regulations.
------------------------------------------------XIV. Transport Information---------------------------------------------------
No special labeling or transportation placarding is required.
------------------------------------------------XV. Regulatory Information--------------------------------------------------
All ingredients are listed on the U.S. EPA TSCA inventory of chemical substances.
W.H.M.I.S. Code: D.2
------------------------------------------------XVI Other Information---------------------------------------------------------
This information is furnished without warranty, representation, inducement or license of any kind;
except that it is accurate to the best of our knowledge, or obtained from sources believed by us to be
accurate.
310rsb.doc Page 4
|