Supplier:
Permatex, Inc.
10 Columbus Blvd.
Hartford, CT 06106
Telephone: 1-87-Permatex
(877) 376-2839
Material Safety Data Sheet
1. PRODUCT IDENTIFICATION
Product Name: 14D THREAD SEALANT WITH TEFLON 1PT
Item No: 80633
Product Type: Sealant
2. COMPOSITION/INFORMATION ON INGREDIENTS
Ingredients Percent ACGIH 8 Hr. TWA: OSHA 8 Hr. TWA:
2-PROPANOL 35-45 400 ppm TWA; 983 mg/m3 TWA 400 ppm TWA
67-63-0
TALC 20-30 2 mg/m3 respir. dust TWA 2 mg/m3 TWA
14807-96-6
CASTOR OIL 20-30
8001-79-4
VINYL TERPOLYMER 5-15 10 mg/m3 TWA total dust 15 mg/m3 TWA total dust; 5 mg/m3 respir dust
27360-07-2
TITANIUM DIOXIDE 1-10 10 mg/m3 15 mg/m3 total dust
13463-67-7
3. HAZARDS IDENTIFICATION
May cause eye, skin and respiratory irritation.
Toxicity:
Eye and skin contact, ingestion, inhalation.
Primary Routes of Entry:
Excessive accidental exposure may cause headache, dizziness, nausea and mild respiratory
Signs and Symptoms of Exposure:
irritation. Overexposure may cause eye and skin redness.
ACGIH Carcinogens IARC:
Ingredients Percent NTP:
TITANIUM DIOXIDE 1-10 Group 3
13463-67-7
Medical Conditions Recognized as Being Preexisting eye, skin and respiratory disorders may be aggravated by overexposure to this product.
Aggravated by Exposure:
4. FIRST AID MEASURES
If swallowed, DO NOT induce vomiting. Keep individual calm. Obtain medical attention.
Ingestion:
If inhaled, remove to fresh air. If not breathing give artificial respiration, preferably mouth-to-mouth. If
Inhalation:
breathing is difficult give oxygen. Get medical attention.
Remove contaminated clothing. Wash area with soap and water. If irritation persists, seek medical
Skin Contact:
attention.
In case of contact, immediately flush eyes with plenty of water for at least 15 minutes and get
Eye Contact:
medical attention if irritation persists.
5. FIRE FIGHTING MEASURES
74 degrees F. Method: Tag Closed Cup
Flash Point (掳F/C):
Carbon Dioxide, Dry Chemicals, Foam.
Recommended Extinguishing Media:
Firefighters should wear self-contained breathing apparatus. Water spray may be ineffective on
Special Fire-Fighting Procedures:
flames but should be used to keep fire-exposed containers cool.
Fluoride compounds
Hazardous Products Formed by Fire or
Thermal Decomposition:
Page 1 of 3
Product Name: 14D THREAD SEALANT WITH TEFLON 1PT
Item No: 80633
Closed containers may rupture or explode when exposed to extreme heat.
Unusual Fire/Explosion Hazards:
2.3
Lower Explosive Limit:
12.7
Upper Explosive Limit:
6. ACCIDENTAL RELEASE MEASURES
Eliminate all sources of ignition. Maintain good ventilation. Take up with an inert absorbent. Store in a
Spill Procedures:
closed waste container until disposal. Residues may be cleaned up with isopropyl alcohol.
7. HANDLING AND STORAGE
Store away from heat, sparks or open flame. Do not store at temperatures above 120 degrees F.
Storage:
Avoid contact with skin and eyes. Do not inhale vapors. Keep container closed when not in use.
Handling:
8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Safety glasses or goggles.
Eyes:
Rubber or plastic gloves
Skin:
General; local exhaust ventilation as necessary to control any air contaminants to within their
Ventilation:
exposure limits during the use of this product.
An approved respirator (i.e. NIOSH, etc.) should be worn when exposures are expected to exceed
Respiratory Protection:
the applicable limits.
9. PHYSICAL AND CHEMICAL PROPERTIES
White paste
Appearance:
Alcohol Odor
Odor:
180 degrees F.
Boiling Point (掳F):
Does not apply
pH:
Partial
Solubility in Water:
1.12
Specific Gravity:
37.9% by weight; 425.5 g/l
VOC Content(Wt.%):
33 mm Hg @ 68 degrees F.
Vapor Pressure:
2.07
Vapor Density (Air=1):
7.7 (ether = 1)
Evaporation Rate:
10. STABILITY AND REACTIVITY
Stable at normal conditions
Chemical Stability:
WILL NOT OCCUR
Hazardous Polymerization:
Strong oxidizers.
Incompatabilities:
Do not expose to heat or store at temperatures above 120 F.
Conditions to Avoid:
Fluoride compounds
Hazardous Products Formed by Fire or
Thermal Decomposition:
11. TOXICOLOGICAL INFORMATION
See Section 3
12. ECOLOGICAL INFORMATION
No data available
13. DISPOSAL CONSIDERATIONS
Disposal should be made in accordance with federal, state and local regulations.
Recommended Method of Disposal:
D001 as per 40CFR 261.21
US EPA Waste Number:
14. TRANSPORT INFORMATION
DOT (49CFR 172)
Domestic Ground Transport
DOT Shipping Name: Consumer Commodity (Not more than five liters)
Hazard Class: ORM-D
UN/ID Number: None
Page 2 of 3
Product Name: 14D THREAD SEALANT WITH TEFLON 1PT
Item No: 80633
Marine Pollutant: None
IATA
Proper Shipping Name: Consumer Commodity (Not more than 500 ml)
Class or Division: Class 9
UN/NA Number: ID 8000
IMDG
Proper Shipping: Adhesives, Limited Quantity
Hazard Class: Class 3.3
UN Number: UN 1133
15. REGULATORY INFORMATION
SARA 313 Chemicals: The following component(s) is listed as a SARA Section 313 Toxic Chemical.
NONE
CALIFORNIA PROP 65:
No California Prop 65 chemicals are known to be present.
TSCA Inventory Status:
All components of this product are listed (or exempt) on the EPA TSCA inventory.
16. OTHER INFORMATION
HEALTH 2, FLAMMABILITY 3 , REACTIVITY 0
Estimated NFPA Rating:
FLAMMABILITY 3 , REACTIVITY 0 , HEALTH 2
Estimated HMIS Classification:
NFPA is a registered trademark of the National Fire Protection Assn.
HMIS is a registered trademark of the National Paint and Coatings Assn.
Prepared By: Denise Boyd Health and Safety Manager
Company: Permatex. Inc. 10 Columbus Blvd. Hartford, CT 06106
Telephone Number: 1-87-Permatex (877) 376-2839
03/02/2001
Revision Date:
Page 3 of 3
|