MATERIAL SAFETY DATA SHEET
PRODUCT NAME: X-TRA SOLV PRODUCT NO. 130.00
SAVIN PRODUCTS COMPANY, INC
1. CHEMICAL PRODUCT AND COMPANY IDENTIFICATION
Product Name: X-TRA SOLV
Emergency phone: Chemtrec: 800-424-9300 Product Information: 781-961-2744
Company: SAVIN PRODUCTS COMPANY, INC.
214 HIGH STREET
RANDOLPH, MA 02368
Date Prepared: 04-07-04 Supersedes: 06-13-94 Prepared by: KJS
2. COMPOSITION/INFORMATION ON INGREDIENTS
Typical
Component CAS No. Exposure Limits % by Weight
1. Sodium Tallowate 8052-48-0 N/A 1-5
2. Tetrasodium salt of 64-02-8 N/A 1-5
Ethylenediamine tetraacetic acid
3. Nonylphenol Ethoxylate 9016-45-9 N/A 1-5
OSHA PEL: TWA 50 ppm (240 mg/m3) skin
4. 2-Butoxyethanol 111-76-2 5-10
TLV: 25 ppm; 121 mg/m3 (as TWA) (skin)
(ACGIH 1992-1993)
3. HAZARDS IDENTIFICATION
EMERGENCY OVERVIEW
WARNING: Severe Eye Irritant. Causes skin irritation with prolonged contact. Vapors or mist may cause respiratory tract irritation.
Harmful if swallowed. Avoid contact with eyes, skin and clothing. Wash thoroughly after handling.
EFFECTS of OVEREXPOSURE:
CARCINOGENICITY:
NTP: No IARC: No OSHA: No
EYES: Severe Eye irritant.
SKIN: Repeated or prolonged contact causes skin irritation
INHALATION: May cause dizziness, nausea and breathing difficulties.
INGESTION: Causes gastric distress and nausea. Can result in damage to mouth, throat, esophagus and stomach.
CHRONIC EFFECTS and MEDICAL CONDITIONS: The effects of long-term, low-level exposures to this product have not been
determined. Safe handling of this material on a long-term basis should emphasize the avoidance of all effects from repetitive acute
exposure. This product may aggravate existing eye, skin and respiratory conditions.
4. FIRST AID MEASURES
EYES: Flush with copious amounts of water for at least 15 minutes, lifting upper and lower lids occasionally. Get immediate medical
attention.
SKIN: Immediately flush with water. Remove contaminated clothing. Launder contaminated clothing before reuse.
INHALATION: Remove to fresh air. I breathing is difficult, oxygen may be given, preferably with a physicians advice. Get medical
attention.
INGESTION: If swallowed, give several glasses of water. Do not induce vomiting. If vomiting does occur, give fluids again and keep
head below hips to help prevent aspiration. Do not give anything by mouth to an unconscious person. Get immediate medical
attention.
Page 1 of 4
MATERIAL SAFETY DATA SHEET
PRODUCT NAME: X-TRA SOLV PRODUCT NO. 130.00
5. FIRE FIGHTING MEASURES
FLAMMABLE PROPERTIES:
Flash Point: >200 F Test: SETA CC. ASTM D-3278
Explosive Limits: LEL: N/A UEL: N/A
EXTINGUISHING MEDIA: Use procedures appropriate to surrounding fire..
SPECIAL PROCEDURES & UNUSUAL HAZARDS: Not Combustible under test conditions, however large spills in a confined area
may produce combustible vapors. Use water to deluge spill and cool containers.
FIREFIGHTING INSTRUCTIONS: Firefighters should wear NIOSH approved, positive pressure, self-contained breathing apparatus
and full protective clothing when appropriate.
6. ACCIDENTAL RELEASE MEASURES
SMALL SPILLS: Soak up small spills with inert solids. Use suitable disposal container. May be neutralized with vinegar and
discharged to local sewer if permitted.
LARGE SPILLS: Limit access to area. Dike and contain spill with inert material (sand, earth, etc.) and transfer the liquid and solid
separately to containers for recovery or disposal. Keep spill out of sewers and open bodies of water. CAUTION: Floor may become
slippery.
7. HANDLING AND STORAGE
Handle according to good manufacturing and warehousing practices. Keep containers tightly closed when not in use. Use good
personal hygiene practices. Wash hand before eating, drinking, smoking or using toilet facilities. Promptly remove soiled clothing and
wash thoroughly before reuse. Store only in tightly closed containers not made of aluminum. Always add product to water when
making solutions. Do Not Freeze.
8. EXPOSURE CONTROLS/PERSONAL PROTECTION
EYE PROTECTION: Avoid splashing. Wear chemical-resistant safety goggles if necessary. Contact lenses must not be worn.
PROTECTIVE GLOVES: Depending on conditions of use, protective gloves should be worn.
RESPIRATORY PROTECTION: No occupational exposure standards have been developed for this material. Where exposure through
inhalation may occur from use, NIOSH/MSHA approved respiratory protection equipment is recommended.
VENTILATION: Ventilation is required in case of mist conditions. Either local exhaust or general room ventilation is usually
adequate.
OTHER PROTECTIVE EQUIPMENT: Emergency eye wash fountains and safety showers should be available in the immediate
vicinity of any potential exposure.
9. PHYSICAL AND CHEMICAL PROPERTIES
APPEARANCE: Clear, Thin, Foamy, Light Red, liquid
BOILING POINT: >200 F @1 ATM
FREEZE/MELT POINT: 32 F
VAPOR PRESSURE (mm): N/A
VAPOR DENSITY (air=1): ca Air
EVAPORATION RATE: ca water
SOLUBILITY IN WATER: Complete
SPECIFIC GRAVITY: 1.012 @ 20 C
DENSITY: 8.4 lb/gal @ 20C
pH( as is ): 13.5
ODOR: Mild
ODOR THRESHOLD (ppm): Not determined.
Page 2 of 4
MATERIAL SAFETY DATA SHEET
PRODUCT NAME: X-TRA SOLV PRODUCT NO. 130.00
10. STABILITY AND REACTIVITY
CHEMICAL STABILITY (CONDITIONS TO AVOID): Keep away from aluminum.
INCOMPATIBILITY:
HAZARDOUS DECOMPOSITION PRODUCTS: Carbon dioxide, Nitrogen oxide, hydrogen gas resulting from contact with reactive
metals.
HAZARDOUS POLYMERIZATION: None
11. TOXICOLOGICAL INFORMATION
No LD50 or LC50 found for oral, dermal or inhalation routes of administration.
12. ECOLOGICAL INFORMATION
Toxic to aquatic life. Do not discharge to streams, ponds, or waterways. Surfactant components are biodegradable.
13. DISPOSAL CONSIDERATIONS
RCRA: This product, if disposed as shipped, is considered a hazardous waste as specified in 40 CFR 261.22. Solutions of this product
with a pH of >12.5 are also classified as hazardous waste.
Dispose in accordance with all applicable federal, state and local regulations.
14. TRANSPORT INFORMATION
SHIPPING NAME: CLEANING COMPOUND, LIQUID
HAZARD CLASS: Not Regulated as Hazmat
ID# N/A
PACKING GROUP: N/A
LABEL: N/A
15. REGULATORY INFORMATION
This material does not contain nor was it manufactured using ozone-depleting chemicals.
U.S. FEDERAL REGULATIONS:
TSCA STATUS: All ingredients on Toxic Substance Control Act Inventory.
CERCLA REPORTABLE QUANTITY: None
SARA TITLE III:
Section 302 Extremely Hazardous Substances: None.
Section 311/312 Hazardous Categories: Immediate (Acute)
Section 313 Toxic Chemicals: Glycol Ether Category N230 ; 2 Butoxyethanol (CAS#111-76-2)
16. OTHER INFORMATION
All label precautions must be observed when handling, storing and transporting empty containers due to product residues. Do not
reuse this container unless it is professionally cleaned and reconditioned.
REFERENCES:
鈥? U.S. Dept. of Health and Human Services, NIOSH: Registry of Toxic Effects of Chemical Substances, 1985-86 Edition.
鈥? Sax, N. Irving and Lewis, R.J.: Dangerous Properties of Industrial Materials, 7th Edition, Van Nostrand Reinhold Co., 1989.
鈥? Lewis, R.J.: Hawley鈥檚 Condensed Chemical Dictionary,12th Edition, Van Nostrand Reinhold Co., 1993.
鈥? U.S. Dept. of Transportation, U.S. Coast Guard: CHRIS Hazardous Chemical Data, 1982.
鈥? U.S. Dept. of Labor, OSHA: Air Contaminants - Permissible Exposure Limits, 1989.
鈥? National Fire Protection Association (NFPA): Fire Protection Guide on Hazardous Materials (NFPA 325M/49/491M/704), 9th
Edition, 1986.
鈥? National Fire Protection Association (NFPA): Hazardous Materials Response Handbook, Henry, M.F., Editor, 1989.
Page 3 of 4
MATERIAL SAFETY DATA SHEET
PRODUCT NAME: X-TRA SOLV PRODUCT NO. 130.00
鈥? Merck & Co., Inc.: The Merck Index, 11th Edition, 1989.
Information herein is given in good faith as authoritative and valid; no warranty, express or implied can be made.
Page 4 of 4
|