MATERIAL SAFETY DATA SHEET
James Alexander Corporation 845 Route 94 Blairstown, NJ 07825
Product Name: IODINE TINCTURE USP
MSDS Effective Date: September 10, 2004 Page 1 of 5
CHEMTREC 24 Hour Emergency Phone: (800) 424-9300 Note: The CHEMTREC emergency
number is to be used only in the event of chemical emergencies involving a spill, leak, fire, exposure, or accident
involving chemicals. All non-emergency questions should be directed to JAC at (908) 362-9266.
------------------------------I. PRODUCT IDENTIFICATION -------------------------------
Manufacturer鈥檚 Name: James Alexander Corporation Phone: (908)362-9266
Emergency Telephone No.: (800)424-9300 (CHEMTREC)
Address: 845 Route 94 Blairstown, NJ 07825
Product Name: IODINE TINCTURE USP
Synonyms: N/A
D.O.T. Shipping Name: Consumer Commodity ORM-D for ground shipments only
Air shipments: Flammable Liquid NOS, 3; UN1993, PGII
(Ethanol, Iodine)
NFPA Ratings: Health - 2 Flammability - 3 Instability - 1
------------------------------II. HAZARDOUS INGREDIENTS ------------------------------
---------OSHA-------- ---------ACGIH---------
Component CAS No. % PEL/TWA TLV/TWA TLV/STEL
Iodine 7553-56-2 2% 0.1 ppm (ceiling limit) 0.1 ppm (ceiling limit)
Ethyl Alcohol 64-17-5 50% 1000 ppm 1000 ppm Not listed
---------------------------------------III. PHYSICAL DATA --------------------------------------
Boiling Point: N/A for mixtures Melting Point: Unknown
Specific Gravity: 0.948 25/25 Vapor Pressure: Unknown
Vapor Density: Unknown Solubility in water: Very soluble
% volatiles by vol.: 47% Evaporation Rate (Butyl acetate=1): Unknown
Appearance and odor: Clear, dark reddish brown liquid. Odor of alcohol.
pH: Unknown
-----------------------IV FIRE & EXPLOSION INFORMATION ------------------------
Flash Point: 80 degrees F Test Method: Pensky Martens Closed Cup
Autoignition temp: Ethyl Alcohol: 685 degrees F (363oC)
MATERIAL SAFETY DATA SHEET
James Alexander Corporation 845 Route 94 Blairstown, NJ 07825
Product Name: IODINE TINCTURE USP
MSDS Effective Date: September 10, 2004 Page 2 of 5
CHEMTREC 24 Hour Emergency Phone: (800) 424-9300 Note: The CHEMTREC emergency
number is to be used only in the event of chemical emergencies involving a spill, leak, fire, exposure, or accident
involving chemicals. All non-emergency questions should be directed to JAC at (908) 362-9266.
Flammable limits in air % by volume: Lower (Unknown) Upper(Unknown)
Extinguishing media: 鈥淎lcohol resistant鈥? foam, CO2 or dry chemical.
Special fire fighting procedures:
NOTE: Individuals should perform only those fire-fighting procedures for which they
have been trained.
Remove all sources of ignition. Move exposed containers from fire area if it can be done
without risk. Firefighters should wear proper protective equipment and self-contained breathing
apparatus with full facepiece operated in positive pressure mode. Spray extinguishing media
directly into base of flames. Water may be used to keep fire-exposed containers cool.
Unusual fire and explosion hazard: When heated, mixture may give off carbon monoxide and
carbon dioxide. Closed containers exposed to heat may develop pressure and explode.
Alcohol vapors are heavier than air and may travel a considerable distance to a source of
ignition and flash back. Alcohols burn with a pale blue flame which may be extremely hard to
see under normal lighting conditions. Personnel may be able to feel the heat of the fire without
seeing flames. Extreme caution must be exercised in fighting alcohol fires.
-------------------------V. HEALTH HAZARD INFORMATION -------------------------
Primary routes of exposure: Inhalation, eye contact, skin contact, ingestion.
Signs and symptoms of overexposure:
Inhalation: Irritation of mucous membranes, severe irritation or burns of the respiratory
system, pulmonary edema, lung inflammation. Headache, dizziness, drowsiness, loss of appetite
and an inability to concentrate.
Eye contact: Severe irritation or burns, prolonged contact may cause permanent corneal
damage, may lead to blindness.
Skin contact: Local irritation, dry skin, burns.
Ingestion: Burning pain in mouth, throat, constriction of throat, coughing, followed by
nausea and vomiting. Fever, shock, bloody urine, difficult breathing. Ingestion may prove fatal.
Medical Conditions Aggravated by Exposure: Individuals with pre-existing nervous system
disorders, skin disorders, eye problems, or impaired respiratory function may be more
susceptible to the effects of overexposure.
MATERIAL SAFETY DATA SHEET
James Alexander Corporation 845 Route 94 Blairstown, NJ 07825
Product Name: IODINE TINCTURE USP
MSDS Effective Date: September 10, 2004 Page 3 of 5
CHEMTREC 24 Hour Emergency Phone: (800) 424-9300 Note: The CHEMTREC emergency
number is to be used only in the event of chemical emergencies involving a spill, leak, fire, exposure, or accident
involving chemicals. All non-emergency questions should be directed to JAC at (908) 362-9266.
----------------VI. EMERGENCY AND FIRST AID PROCEDURES ----------------
For Inhalation: Remove subject immediately to fresh air. Give artificial respiration if
victim is not breathing. If breathing is difficult, give oxygen. Get immediate medical attention.
For Eye Contact: Immediately flush eyes with copious amounts of water for at least 15
minutes. Eyelids should be held apart and away from eyeball for thorough rinsing. Do not permit
victim to rub eyes. Get immediate medical attention.
For Skin Contact: Immediately flush skin with copious amounts of water for at least 15
minutes while removing contaminated clothing and shoes. Do not rub or apply ointment to
affected area. Obtain medical attention if irritation persists. Wash clothing before re-use.
For Ingestion: Contact a Poison Control Center immediately. Do NOT induce vomiting.
If conscious, have victim swallow large amounts of water. Do not give anything by mouth to an
unconscious or convulsing person. Get immediate medical attention.
-------------------------------------VII. TOXICITY DATA ---------------------------------------
None of the components present in this formulation are currently classified as
carcinogens in the NTP Annual Report on Carcinogens, IARC Monographs or by OSHA.
------------------------------VIII. PERSONAL PROTECTION ------------------------------
Storage Requirements: Protect containers from physical damage. Detached or outside
storage is preferred. Inside storage should be in an NFPA approved flammable liquids storage
room or cabinet. Store in corrosion-proof area at temperatures below 77 degrees F (25oC). Do
not store in direct sunlight. Isolate from incompatible materials. Keep containers tightly closed.
Handling Requirements: All ignition sources should be eliminated. Remove closure
carefully; internal pressure may be present. Keep closure up to prevent leakage. When contents
are being transferred, metallic containers must be bonded to the receiving container and
grounded to avoid static discharges. Never use pressure to empty containers. Replace closure
carefully after each opening.
Ventilation: Not required for product (JAC unit dose swab) use. When handling bulk
material, use general or local exhaust ventilation to meet TLV requirements. Where engineering
controls are not feasible or sufficient to achieve full conformance with acceptable exposure
limits, use NIOSH approved respiratory protection equipment. Care must be taken to assure that
any respirator chosen is capable of protecting the user from both iodine and ethyl alcohol
vapors. In some cases, a self-contained breathing apparatus may be advisable.
MATERIAL SAFETY DATA SHEET
James Alexander Corporation 845 Route 94 Blairstown, NJ 07825
Product Name: IODINE TINCTURE USP
MSDS Effective Date: September 10, 2004 Page 4 of 5
CHEMTREC 24 Hour Emergency Phone: (800) 424-9300 Note: The CHEMTREC emergency
number is to be used only in the event of chemical emergencies involving a spill, leak, fire, exposure, or accident
involving chemicals. All non-emergency questions should be directed to JAC at (908) 362-9266.
Eye Protection: Not required for product (JAC unit dose swab) use. When handling bulk
material, always wear gas-tight, splash-proof chemical safety goggles meeting OSHA 29CFR
1910.133 specifications.
Skin Protection: Not required for product (JAC unit dose swab) use. Use rubber gloves,
protective suit, face shield and overshoes when handling bulk product.
-------------------------------IX. HAZARDOUS REACTIVITY -------------------------------
Stable at room temperature. Hazardous polymerization will not occur. However, product
may give off carbon monoxide and carbon dioxide when heated.
Conditions To Avoid: Sunlight, heat (heating above ambient temperatures causes the
vapor pressure of the solution to increase).
Avoid mixing with strong reducing agents, ammonia, ammonium salts, acetylene,
acetaldehyde, aluminum, chemically active metals, powdered metals, carbides, ammonium
hydroxide, and acetyl chloride.
-----------------X SPILL, LEAK AND DISPOSAL PROCEDURES ------------------
For large spills, stop leak if you can do so without risk. Extinguish all sources of ignition.
Wear self-contained breathing apparatus, chemical safety goggles and full protective clothing.
Ventilate area. Spilled liquids should be contained and not washed into sewers or ground water.
Contain by diking with non-combustible absorbent materials and place residue in DOT approved
waste container.
Comply with all applicable local, state and federal regulations on spill reporting, handling
and disposal of waste.
Other Precautions: Containers, even those that have been emptied, will retain product
residue and vapors. Handle empty containers as if they were full.
Prepared By: David Robinson
Title: Vice President
Date of Initial Preparation: June 1989
Latest Revision Date: September 10, 2004
------------------------------------------------------------------------------------------------------------------
NOTE: This Material Safety Data Sheet is intended only as a guide to the appropriate
precautionary handling of the material by a person trained in, or supervised by a person trained
in, the safe handling of chemical materials. James Alexander Corporation (JAC), expressly
disclaims all express or implied warranties of merchantability and fitness for a particular purpose
with respect to the product or information provided herein.
MATERIAL SAFETY DATA SHEET
James Alexander Corporation 845 Route 94 Blairstown, NJ 07825
Product Name: IODINE TINCTURE USP
MSDS Effective Date: September 10, 2004 Page 5 of 5
CHEMTREC 24 Hour Emergency Phone: (800) 424-9300 Note: The CHEMTREC emergency
number is to be used only in the event of chemical emergencies involving a spill, leak, fire, exposure, or accident
involving chemicals. All non-emergency questions should be directed to JAC at (908) 362-9266.
All information appearing herein is based upon data obtained from the manufacturer(s)
and/or recognized technical sources. While the information is believed to be accurate, JAC
makes no representations as to its accuracy or sufficiency. Conditions of use are beyond JAC鈥檚
control and therefore, users are responsible to verify this data under their own operating
conditions to determine whether the product is suitable for their particular purposes and they
assume all risks of their use, handling, and disposal of the product, or from the publication or use
of, or reliance upon, information contained herein. This information relates only to the product
designated herein and does not relate to its use in combination with any other material or in any
other process.
|