MATERIAL SAFETY DATA SHEET
SECTION 1: CHEMICAL PRODUCT IDENTIFICATION
: Kobo Products, Inc.
Manufacturer/Distributor
Address : 690 Montrose Avenue, So. Plainfield, NJ 07080
Emergency Telephone # : (908) 757-0033 Facsimile Number : (908) 757-0905
: CM3EK25VM
Trade Name
INCI Name : Cyclopentasiloxane (And) Ethyl Trisiloxane (And) Titanium Dioxide (And) Methicone
(And) PEG-10 Dimethicone
SECTION 2: COMPOSITION / INFORMATION ON INGREDIENTS
Ingredient: CAS #: EINECS #:
Cyclopentasiloxane 541-02-6 208-764-9
Ethyl Trisiloxane 17861-60-8
Titanium Dioxide 13463-67-7 236-675-5
Methicone 9004-73-3 ---
PEG-10 Dimethicone 68937-54-2 ----
SECTION 3: HAZARD IDENTIFICATION
EMERGENCY OVERVIEW:
Caution! Combustible Liquid and Vapor.
Keep away from heat, sparks, and flame.
Refer to other MSDS sections for detailed information.
SECTION 4: FIRST AID MEASURES
Emergency First Aid:
Eye Contact : Flush eyes with water for at least 15 min. See physician if irritation persists.
Skin Contact : Flush skin with soap and water.
Ingestion : None needed for small amounts. For large amounts, if conscious, give water and call
physician. Do not induce vomiting.
SECTION 5: FIRE FIGHTING MEASURES
Flash Point (Closed Cup) : >76.6潞C
Flammable Limits LEL/UEL % : N/A
Extinguishing Media : Water spray, Dry Chemical, Foam, CO2
Special Fire Fighting Procedures : Combustible.
Unusual Fire And Explosion Hazards : Can burn in fire, releasing toxic vapors.
SECTION 6: ACCIDENTAL RELEASE MEASURES
Personal Precautions : Avoid skin and eye contact.
Environmental Precautions: : Prevent material from contaminating soil or entering sewerage and drainage systems.
Spill response : Use appropriate NIOHS/MSHA approved respirator. Wear chemical gloves, goggles,
and lab coat. Carefully contain spilled material. Deposit spilled material in appropriate
waste container. Wash spill area with soap and water.
SECTION 7: HANDLING AND STORAGE
Handling : Avoid contact with eyes. Wash thoroughly after handling and before mealtimes. Follow all
MSDS and label precautions even after container is emptied since it may contain residual
material.
Storage : Store containers closed in ambient temperature location away from all possible combustion.
Recommended storage below 30掳C.
SECTION 8: EXPOSURE CONTROL / PERSONAL PROTECTION
Exposure Levels: OSHA ACGIH
TWA PEL TWA TLV
15 mg/m3 10 mg/m3
TiO2
Personal Protection:
p. 1 of 3
KOBO Products, Inc.
CM3EK25VM
Eye Protection : Safety glasses with side shields or goggles
Skin Protection : Rubber gloves, wash at meals and end of shifts
Respiratory Protection : Use NIOSH/MSHA approved air purifying respirator as needed to control exposure.
SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES
Boiling Point (掳C) : >210掳C Percent Volatile By Vol. (%) : About 63 %
Freezing Point (掳C) : Unknown Vapor Density (Air=1) : N/A
Melting Point (掳C) : N/A Evaporation Rate (Buac=1) : N/A
Vapor Pressure (mm hg) : N/A Solubility In Water : Insoluble
Bulk Density (g/cu. in.) : N/A Appearance & Odor : White slurry
Specific Gravity (H2O=1) : about 1.16 Slight odor
SECTION 10: STABILITY AND REACTIVITY
Stable : Yes.
Hazardous Polymerization : Will not occur.
Conditions To Avoid : Open flames and sparks, extreme heat, oxidizing materials.
Incompatibility : Oxidizing materials and strong caustic materials can cause a reaction.
Hazardous Decomposition Products : Incomplete combustion can form CO, CO2, and dense smoke.
SECTION 11: TOXICOLOGICAL INFORMATION
Titanium Dioxide* Cyclopentasiloxane
Skin Irritation : Dermal LD50 > 10 g/kg (Rabbit) Dermal LD50 > 10 mL/kg (Rat)
Acute Oral Toxicity : Non-toxic, LD50 > 25 g/kg (rat) LD50 > 5 g/kg (Rat)
Inhalation LC50 : >6.82 mg/L (4 hour) Saturated vapor 8 hrs no deaths (Rat)
*: Trochimowicz.. et. Al., J. Appl. Tox., 8, 383-385 (1998) Non-irritating to eyes and skin (rbt), Non-
sensitizing to the skin based upon results of the
Buehler Sensitization Test (gpg)
SECTION 12: ECOLOGICAL INFORMATION
No information is available.
SECTION 13: DISPOSAL CONSIDERATIONS
Method of Disposal : Dispose in accordance with all applicable federal, state, and local regulations. Material may be
sent to an approved landfill or licensed treatment, storage, and disposal facility.
SECTION 14: TRANSPORT INFORMATION
DOT SHIPPING NAME: FOR BULK CONTAINERS (>119 GAL) ONLY: COMBUSTIBLE
LIQUID N.O.S. (DECAMETHYLCYCLOPENTASILOXANE)
11 DOT HAZARD CLASS: BULK CONTAINERS ONLY: COMBUSTIBLE LIQUID
DOT LABEL(S): NONE
UN/NA NUMBER: FOR BULK CONTAINERS ONLY: NA1993
PLACARDS: FOR BULK CONTAINERS ONLY: COMBUSTIBLE
IATA:
NOT REGULATED BY IATA
IMO IMDG-code: NA
EMS No: NA
EUROPEAN CLASS:
RID (OCTI): NA
ADR (ECE) : NA
RAR (IATA): NA
SECTION 15: REGULATORY INFORMATION
International List
Australia (NICNAS): TITANIUM DIOXIDE
p. 2 of 3
KOBO Products, Inc.
CM3EK25VM
JAPAN (MITI): TITANIUM DIOXIDE
Korea (TCCL): TITANIUM DIOXIDE
Philippines (RA6969): TITANIUM DIOXIDE
State Regulations Pennsylvania RTK: TITANIUM DIOXIDE: (generic environmental hazard)
Massachusetts RTK: TITANIUM DIOXIDE
New Jersey: TITANIUM DIOXIDE
SECTION 16: OTHER INFORMATION
Hazardous Material Information System [Ratings Key: 4= Highest hazard, 0= Lowest hazard]
(U.S.A.)
Health 1
Fire Hazard 2
Reactivity 0
Personal Protection C
Date Prepared : June 22, 2006
Prepared By : Eric Smith
Note: The statements made here are intended to describe the product with regard to necessary safety precautions. They do
not guarantee special characteristics. This information is furnished without warranty, expressed or implied, except that it is
accurate to the best of our current knowledge.
p. 3 of 3
|