MATERIAL SAFETY DATA SHEET
SECTION 1: CHEMICAL PRODUCT IDENTIFICATION
: Kobo Products, Inc.
Manufacturer/Distributor
: 690 Montrose Avenue
Address
So. Plainfield, NJ 07080
: (908) 757-0033
Emergency Telephone #
: (908) 757-0905
Facsimile Number
: AC-10 TiO2 CR-50
Trade Name
Chemical Name/ Synonyms : Titanium Dioxide (And) Cellulose Gum (And) Aluminum Hydroxide (And) Microcrystalline
Cellulose
SECTION 2: COMPOSTION / INFORMATION ON INGREDIENTS
Chemical Name CAS # ENEICS #
Titanium Dioxide 13463-67-7 236-675-5
Cellulose Gum 9004-32-4 -------
Aluminum Hydroxide 21645-51-2 --------
Microcrystalline Cellulose 9004-34-6 232-674-9
SECTION 3: HAZARD IDENTIFICATION
Hazards Classification: None
SECTION 4: FIRST AID MEASURES
Emergency First Aid:
Eye Contact : Flush eyes with water for at least 15 min. See physician if irritation persists.
Skin Contact : Flush skin with soap and water for at least 15 min.
Inhalation : Remove to fresh air. If breathing is difficult give oxygen. See physician.
Ingestion : None needed for small amounts. For large amounts, if conscious, induce vomiting. Call
physician.
Note to Physician : Treat symptomatically.
SECTION 5: FIRE FIGHTING MEASURES
Flammable Properties : Non-flammable
Explosive Properties : Incombustible
Extinguishing Media : Water, Dry chemical. Foam, CO2
Fire Fighting Procedures : Wear self-contained breathing apparatus and full protective equipment.
Unusual Fire and Explosion Hazards : None
SECTION 6: ACCIDENTAL RELEASE MEASURES
Land Spill : Sweep up or vacuum into suitable containers for disposal.
Water Spill : Dike spill. Prevent material from entering sewers, waterways or low areas.
SECTION 7: HANDLING AND STORAGE
Handling :
Use with adequate ventilation. Avoid contact with eyes, skin and clothing. Wash thoroughly after handling and before
mealtimes. Handling of fine powders may result in static charges. Proper grounding of processing equipment is
recommended. Follow all MSDS and label precautions even after container is emptied since it may contain residual
material.
Storage :
Store in a normal temperature and a normal humidity room. Avoid a high temperature and high humidity.
SECTION 8: EXPOSURE CONTROL / PERSONAL PROTECTION
Exposure Levels: OSHA ACGIH
Component TWA PEL TWA TLV
Page 1 of 2
KOBO Products, Inc.
AC-10 TiO2 CR-50
15 mg/m3 10 mg/m3
TiO2
*
Effects of overexposure; Irritating to respiratory organs
Personal Protection:
Eye Protection : Safety glasses with side shields or goggles.
Skin Protection : Shield made from plastic film or rubber.
Respiratory Protection : Use NIOSH/MSHA approved air purifying respirator as needed to control exposure.
General : Full-body covering clothing.
Ventilation : Provide adequate general mechanical exhaust.
SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES
Boiling Point (掳C) : N/A Percent Volatile By Vol. (%) : N/A
Freezing Point (掳C) : N/A Vapor Density (Air=1) : N/A
Melting Point (掳C) : N/A Evaporation Rate (Buac=1) : N/A
Vapor Pressure (mm hg) : N/A Solubility In Water : Insoluble
Specific Gravity (g/cc.) : N/A Appearance & Odor : white micro odorless powder.
SECTION 10: STABILITY AND REACTIVITY
Chemical Stable : Inert to most chemicals, reagents. Stable under all conditions.
Hazardous Polymerization : Will not occur
Conditions to Avoid : None.
Hazardous Decomposition Products : None.
Incompatibility with other materials : No information.
SECTION 11: TOXICOLOGICAL INFORMATION
Titanium Dioxide*
Skin Irritation : Dermal LD50 > 10 g/kg (Rabbit)
Primary Eye Irritation : Non-irritating, Draize score = 0.00 (rabbit)
Acute Oral Toxicity : Non-toxic, LD50 > 25 g/kg (rat)
Inhalation LC50 : >6.82 mg/L (4 hour)
*: Trochimowicz.. et. Al., J. Appl. Tox., 8, 383-385 (1998)
SECTION 12: ECOLOGICAL INFORMATION
No Data Available.
SECTION 13: DISPOSAL CONSIDERATIONS
Method of Disposal : Dispose of in accordance with all applicable federal, state, and local regulations. Material may be
sent to an approved landfill or licensed treatment, storage, and disposal facility. Do not dump into
sewers, on the ground or into any body of water.
SECTION 14: TRANSPORT INFORMATION
Never drop container while transporting. Take care to avoid breaking the packages. To ventilate and avoid getting wet.
SECTION 15: REGULATORY INFORMATION
Ensure this material in compliance with federal requirements and ensure conformity to local regulations.
SECTION 16: OTHER INFORMATION
Date Prepared : January 25, 2002
Note:
The statements made here are intended to describe the product with regard to necessary safety precautions. They do not
guarantee special characteristics. This information is furnished without warranty, expressed or implied, except that it is
accurate to the best of our current knowledge.
Page 2 of 2
|