MATERIAL SAFETY DATA SHEET
SECTION 1: CHEMICAL PRODUCT IDENTIFICATION
Manufacturer/Distributor : Kobo Products, Inc.
Address : 690 Montrose Avenue
So. Plainfield, NJ 07080
Emergency Telephone # : (908) 757-0033
Facsimile Number : (908) 757-0905
Trade Name : DIDW55DBF
Chemical Name/ Synonyms : Black Iron Oxide (And) Diisopropyl Dimer Dilinoleate (And) Polyglyceryl-4
Isostearate (And) Cetyl PEG/Ppg-10/1 Dimethicone (And) Hexyl Laurate (And) C9-
15 Fluoroalcohol Phosphates
SECTION 2: COMPOSTION / INFORMATION ON INGREDIENTS
Chemical Name CAS # EINECS #
Black Iron Oxide 1309-38-2 215-169-8
Diisopropyl Dimer Dilinoleate 103213-20-3 ---
Polyglyceryl-4 Isostearate 91824-88-3 ---
Cetyl PEG/Ppg-10/1 Dimethicone 134737-04-5 ---
Hexyl Laurate 34316-64-8 251-932-1
C9-15 Fluoroalcohol Phosphate --- ---
SECTION 3: HAZARD IDENTIFICATION
No particular danger
SECTION 4: FIRST AID MEASURES
Emergency First Aid:
Eye Contact : Flush eyes with water for at least 15 min. See physician if irritation persists.
Skin Contact : Flush skin with soap and water for at least 15 min.
Inhalation : Remove to fresh air. If breathing is difficult give oxygen. See physician.
Ingestion : None needed for small amounts. For large amounts, if conscious, give milk to
drink, induce vomiting, and call physician.
SECTION 5: FIRE FIGHTING MEASURES
Flash Point (Closed Cup) : > 105掳 C
Flammable Limits LEL/UEL % : N/A
Extinguishing Media : Water, Dry Chemical, Foam, CO2
Special Fire Fighting Procedures : Self-contained breathing apparatus and protective clothing.
Unusual Fire And Explosion Hazards : Vapors are heavier than air and can travel along ground to remote ignition
sources.
SECTION 6: ACCIDENTAL RELEASE MEASURES
Personal Precautions : Avoid skin and eye contact
Environmental Precautions: : Prevent material from contaminating soil or entering sewerage and drainage
systems.
Spill response : Use appropriate NIOHS/MSHA approved respirator. Wear chemical gloves,
goggles, and lab coat. Carefully contain spilled material . Deposit spilled
material in appropriate waste container. Wash spill area with soap and water.
SECTION 7: HANDLING AND STORAGE
Handling : Use with adequate ventilation. Avoid contact with eyes. Wash thoroughly after handling and
before mealtimes. Follow all MSDS and label precautions even after container is emptied since it
may contain residual material.
Page 1 of 3
KOBO Products, Inc. April 6, 2004
DIDW55DBF
Storage : Store containers closed in ambient location.
SECTION 8: EXPOSURE CONTROL / PERSONAL PROTECTION
Exposure Levels: OSHA ACGIH
Component TWA PEL TWA TLV
Iron Oxide 15mg/m3 10mg/m3
Personal Protection:
Eye Protection : Safety glasses with side shields or goggles
Skin Protection : Rubber gloves, wash at meals and end of shifts
Respiratory Protection : Use NIOSH/MSHA approved air purifying respirator as needed to control
exposure.
Ventilation : Provide adequate general mechanical exhaust.
SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES
Boiling Point (掳C) : N/A Percent Volatile By Vol. (%) : N/A
Freezing Point (掳C) : N/A Vapor Density (Air=1) : N/A
Melting Point (掳C) : N/A Evaporation Rate (Buac=1) : N/A
Vapor Pressure (mm hg) : N/A Solubility In Water : Insoluble
Bulk Density (g/cbi.) : N/A Appearance & Odor : Viscous Black Liquid,
Specific Gravity (H2O=1) : 1.4 Slight Odor
SECTION 10: STABILITY AND REACTIVITY
Stable : Yes
Hazardous Polymerization : Will not occur
Conditions To Avoid : Open flames and sparks
Incompatibility : Oxidizing material can cause a reaction
Hazardous Decomposition Products : SiO2, CO, CO2, Acetaldehyde, Formaldehyde, Traces of incompletely
burned carbon compounds
SECTION 11: TOXICOLOGICAL INFORMATION
Iron Oxide
Skin Irritation (rabbit) : No data
Primary Eye Irritation : Mild-irritant
(rabbit) Average Draize score = 0.00
Acute Oral Toxicity (rat) : Non-toxic, LD 50 > 15 g/kg (rat)
Sensitization : Non-toxic
SECTION 12: ECOLOGICAL INFORMATION
No data.
SECTION 13: DISPOSAL CONSIDERATIONS
Method of Disposal : Dispose of in accordance with all applicable federal, state, and local regulations. Material
may be sent to an approved landfill or licensed treatment, storage, and disposal facility.
SECTION 14: TRANSPORT INFORMATION
Not regulated as hazardous material.
SECTION 15: REGULATORY INFORMATION
No information is available.
Page 2 of 3
KOBO Products, Inc. April 6, 2004
DIDW55DBF
SECTION 16: OTHER INFORMATION
HMIS Ratings : Health - 0 Flammability 鈥?1 Reactivity - 0
Ratings Key : 4= Highest hazard, 0= Lowest hazard,
Date Prepared : November 4, 2004
Date Revised : July 19, 2002
Last Revised : April 6, 2004
Note:
The statements made here are intended to describe the product with regard to necessary safety precautions. They do
not guarantee special characteristics. This information is furnished without warranty, expressed or implied, except
that it is accurate to the best of our current knowledge.
Page 3 of 3
|