MATERIAL SAFETY DATA SHEET
SECTION 1: CHEMICAL PRODUCT IDENTIFICATION
: Kobo Products, Inc.
Manufacturer/Distributor
: 690 Montrose Avenue
Address
So. Plainfield, NJ 07080
: (908) 757-0033
Emergency Telephone #
: (908) 757-0905
Facsimile Number
Trade Name : CT-2 NYLON SP-500
Chemical Name/ Synonyms : Nylon 12 (and ) Chitosna
INCI Name : Nylon 12 (and ) Chitosna
SECTION 2: COMPOSTION / INFORMATION ON INGREDIENTS
Chemical Name CAS # EINECS #
Nylon 12 25038-74-8 polymer
Chitosan 9012-76-4
SECTION 3: HAZARD IDENTIFICATION
No particular danger
SECTION 4: FIRST AID MEASURES
Effects and Symptoms:
Toxicity Data:
Effects of Overexposure to Dust : May cause mechanical irritation to eyes.
Medical Conditions Aggravated by Exposure : Persons with respiratory conditions may be at increased risk.
Primary Route(s) of Entry : Inhalation or skin and eye contact.
Emergency First Aid:
Eye Contact : Flush eyes with water for at least 15 min. See physician if irritation persists.
Skin Contact : Flush skin with soap and water for at least 15 min.
Inhalation : Remove to fresh air. If breathing is difficult give oxygen. See physician.
Ingestion : None needed for small amounts. For large amounts, if conscious, give water to
drink, induce vomiting, and call physician.
SECTION 5: FIRE FIGHTING MEASURES
Flash Point (Closed Cup) : N/A
Flammable Limits LEL/UEL % : N/A
Extinguishing Media : Water, Dry Chemical, Foam, CO2
Special Fire Fighting Procedures : Self-contained breathing apparatus and protective clothing.
Unusual Fire And Explosion Hazards : May burn or explode upon ignition if suspended in air as a dust.
SECTION 6: ACCIDENTAL RELEASE MEASURES
Personal Precautions : Avoid skin and eye contact
Environmental Precautions: : Prevent material from contaminating soil or entering sewerage and drainage
systems.
Spill response : Use appropriate NIOHS/MSHA approved respirator. Wear chemical gloves,
goggles, and lab coat. Carefully contain spilled material . Deposit spilled
material in appropriate waste container. Wash spill area with soap and water.
SECTION 7: HANDLING AND STORAGE
Handling : Use with adequate ventilation. Avoid contact with eyes. Wash thoroughly after handling and
before mealtimes. Follow all MSDS and label precautions even after container is emptied since it
may contain residual material.
p. 1 of 3
KOBO Products, Inc.
CT-2 NYLON SP-500
Storage : Store containers closed in ambient location.
SECTION 8: EXPOSURE CONTROL / PERSONAL PROTECTION
Exposure Levels: OSHA ACGIH
Component TWA PEL TWA TLV
No information available
Personal Protection:
Eye Protection : Safety glasses with side shields or goggles
Skin Protection : Rubber gloves, wash at meals and end of shifts
Respiratory Protection : Use NIOSH/MSHA approved air purifying respirator as needed to control
exposure.
Ventilation : Provide adequate general mechanical exhaust.
SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES
Boiling Point (掳C) : N/A Percent Volatile By Vol. (%) : N/A
Freezing Point (掳C) : N/A Vapor Density (Air=1) : N/A
Melting Point (掳C) : 173 掳C Evaporation Rate (Buac=1) : N/A
Vapor Pressure (mm hg) : N/A Solubility In Water : N/A
Bulk Density (g/cbi.) : N/A Appearance & Odor : Off white powder
Specific Gravity (H2O=1) : > 1.0 Odorless
SECTION 10: STABILITY AND REACTIVITY
Stable : Yes
Hazardous Polymerization : Will not occur
Conditions To Avoid : None
Incompatibility : strong oxidizing agents, strong caustic or acidic solutions
Hazardous Decomposition Products : CO, CO2
SECTION 11: TOXICOLOGICAL INFORMATION
Nylon:
Skin Irritation : Primary dermal irritation in rabbits - primary irritation index: 0.00, non irritant
Eye Irritation : Primary ocular irritation, average Draize scores = 0.3, 24hrs 0.0, 48hrs 0.0, 72hrs.
Oral Toxicity : LD50 > 9.6 g/kg
Sensitization : No data
CT-2 SP-500:
Mutagenicity : Non toxic to stain TA100 at dose of 156~5000碌 grams/plate, both in the absence and
presence of rat liver S9 metabolic activation system. No mutagenic activity was seen at
doses of156~5000 碌 grams/plate.
Oral Toxicity : LD50>9.6 g/kg (mouse)
SECTION 12: ECOLOGICAL INFORMATION
No Data
SECTION 13: DISPOSAL CONSIDERATIONS
Method of Disposal : Dispose of in accordance with all applicable federal, state, and local regulations. Material
may be sent to an approved landfill or licensed treatment, storage, and disposal facility.
SECTION 14: TRANSPORT INFORMATION
Classification: Non-hazardous
SECTION 15: REGULATORY INFORMATION
p. 2 of 3
KOBO Products, Inc.
CT-2 NYLON SP-500
Label Name : CT-2 NYLON SP-500
SECTION 16: OTHER INFORMATION
Date Prepared : June 2, 2001
Last Revised : January 10, 2003
Note:
The statements made here are intended to describe the product with regard to necessary safety precautions. They do
not guarantee special characteristics. This information is furnished without warranty, expressed or implied, except
that it is accurate to the best of our current knowledge.
p. 3 of 3
|