MATERIAL SAFETY DATA SHEET
SECTION 1: CHEMICAL PRODUCT IDENTIFICATION
Manufacturer/Distributor : Kobo Products, Inc.
Address : 3474 South Clinton Avenue
South Plainfield, NJ 07080
Emergency Telephone # : (908) 757-0033
Facsimile Number : (908) 757-0905
Trade Name : COMPOSITE POWDER AL-40
Chemical Name : Dimethicone/Vinyl Dimethicone Crosspolymer (And) Alumina
SECTION 2: COMPOSITION / INFORMATION ON INGREDIENTS
Ingredient: CAS #: EINECS #:
Dimethicone/Vinyl Dimethicone Crosspolymer --- Polymer
Alumina 1333-84-2 215-691-6
SECTION 3: HAZARD IDENTIFICATION
No known hazards.
SECTION 4: FIRST AID MEASURES
Eye Contact: Check for and remove any contact lenses. In case of contact, immediately flush eyes with plenty of water for
at least 15 minutes. If symptoms persist, seek medical attention.
Skin Contact: In case of contact, flush skin with plenty of water for at least 15 minutes while removing contaminated
clothing and shoes. Wash contaminated clothing before reusing. Thoroughly clean shoes before reuse. If
symptoms develop, seek medical attention.
Inhalation: If inhaled, remove to fresh air. If breathing is difficult, give oxygen. If not breathing, give artificial
respiration. If symptoms persist, seek medical attention.
Ingestion: Do not ingest. If this material is swallowed, call a physician immediately. Do NOT induce vomiting unless
directed to do so by medical personnel. Never give anything by mouth to an unconscious person.
SECTION 5: FIRE FIGHTING MEASURES
Flammability: N/A
Fire Fighting Media And Instructions: In case of fire, use water spray (fog), foam, dry chemical, or CO2
Protective Clothing (fire): Wear self-contained breathing apparatus and full protective clothing.
SECTION 6: ACCIDENTAL RELEASE MEASURES
Small Spill and Leak Use a tool to scoop up solid or absorbed material and place into appropriate labeled waste
container. Finish cleaning by spreading water on the contaminated surface and dispose of
according to local and regional regulatory requirements.
Large Spill and Leak Use appropriate tools to put the spill material into a labeled waste disposal container. Finish
cleaning by spreading water on the contaminated surface and dispose of according to local and
regional regulatory requirements. Check TLV in section 8 of MSDS and with local authorities.
Spill Kit information No specific spill kit required for this product.
SECTION 7: HANDLING AND STORAGE
Handling : Avoid generating dust. Avoid breathing dust. Use only with adequate ventilation. Avoid prolonged or
repeated contact with skin. Avoid contact with eyes. Keep container closed. Wash thoroughly after
handling.
Storage : Keep container dry. Keep containers sealed until ready for use.
SECTION 8: EXPOSURE CONTROL / PERSONAL PROTECTION
Exposure Levels: OSHA ACGIH
Component TWA PEL TWA TLV
Not Established
Page 1 of 2
KOBO Products, Inc.
COMPOSITE POWDER AL-40
Personal Protection:
Eye: Safety glasses with side shields or goggles
Body: Lab coat
Respiratory: Use NIOSH/MSHA approved air-purifying respirator as needed to control exposure.
Hand: Recommended: Gloves
SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES
Boiling Point (掳C) : N/A Percent Volatile By Vol. (%) : N/A
Freezing Point (掳C) : N/A Vapor Density (Air=1) : N/A
Melting Point (掳C) : N/A Evaporation Rate (Buac=1) : N/A
Vapor Pressure (mm hg) : N/A Solubility In Water : Insoluble
Bulk Density (g/cbi.) : N/A Appearance & Odor : White powder with characteristic odor
SECTION 10: STABILITY AND REACTIVITY
Stable: Stable
Hazardous Polymerization: None
Incompatibility: Unknown
Hazardous Decomposition Products: Nature of decomposition products is not known.
SECTION 11: TOXICOLOGICAL INFORMATION
No information is available.
SECTION 12: ECOLOGICAL INFORMATION
Toxicity of the Products of Biodegradation: N/A
SECTION 13: DISPOSAL CONSIDERATIONS
Dispose of according to all federal, state and local regulations.
SECTION 14: TRANSPORT INFORMATION
Not Regulated
SECTION 15: REGULATORY INFORMATION
No information is available.
SECTION 16: OTHER INFORMATION
Hazardous Material Information System [Ratings Key: 4= Highest hazard, 0= Lowest hazard]
(U.S.A.)
Health 0
Fire Hazard 1
Reactivity 0
Personal Protection E
Date Prepared : March 9, 2007
Prepared By : Eric Smith
Note:
The statements made here are based upon technical data that Kobo Products Inc. believes to be reliable, are intended to describe the
product with regard to necessary safety precautions. They do not guarantee special characteristics. This information is furnished
without warranty, expressed or implied, except that it is accurate to the best of our current knowledge.
Page 2 of 2
|