MATERIAL SAFETY DATA SHEET
SECTION 1: CHEMICAL PRODUCT IDENTIFICATION
: Kobo Products, Inc.
Manufacturer/Distributor
: 690 Montrose Avenue
Address
So. Plainfield, NJ 07080
: (908) 757-0033
Emergency Telephone #
: (908) 757-0905
Facsimile Number
: Daitosol 5000AD
Trade Name
Chemical Name/ Synonyms : Ethyl Acrylate/Methyl Methacrylate Copolymer Emulsion
INCI Name : Water (And) Acrylates Copolymer
SECTION 2: COMPOSTION / INFORMATION ON INGREDIENTS
Chemical Name CAS # EINECS #
Water 7732-18-5 231-791-2
Ethyl Acrylate/Methyl Methacrylate Copolymer 21135-39-1 Polymer
Sodium Dehydroacetate 4418-26-2 224-580-1
Laureth-20 (Laulyl Alcohol + Oxirane) 9002-92-0 203-928-0, 200-849-9
SECTION 3: HAZARD IDENTIFICATION
No particular danger
SECTION 4: FIRST AID MEASURES
Emergency First Aid:
Eye Contact : Flush eyes with water for at least 15 min. See physician if irritation persists.
Skin Contact : Flush skin with soap and water for at least 15 min.
Ingestion : None needed for small amounts. In case of excessive ingestion, drink more than
two glasses of water or milk and induce vomiting, and call a physician,
SECTION 5: FIRE FIGHTING MEASURES
Flash Point (Closed Cup) : > 300 F
Flammable Limits LEL/UEL % : N/A
Extinguishing Media : Dry Chemical, Foam, CO2
Special Fire Fighting Procedures : Extinguishing on intercepting air preferably.
Unusual Fire And Explosion Hazards : None.
SECTION 6: ACCIDENTAL RELEASE MEASURES
Personal Precautions : Eye contact and excessive skin contact.
Environmental Precautions: : Prevent material from contaminating soil or entering sewerage and drainage
systems.
Spill response : Use appropriate NIOHS/MSHA approved respirator. Wear chemical gloves,
goggles, and lab coat. Soak up with absorbent materials and clean up by cloth
and thin wash by soap and water.
SECTION 7: HANDLING AND STORAGE
Handling : Use with adequate ventilation. Avoid contact with eyes. Wash thoroughly after handling
and before mealtimes. Follow all MSDS and label precautions even after container is
emptied since it may contain residual material.
Storage : Store containers closed in ambient location. Avoid high temperature and high humidity.
SECTION 8: EXPOSURE CONTROL / PERSONAL PROTECTION
Exposure Levels: OSHA ACGIH
Page 1 of 3
KOBO Products, Inc.
DAITOSOL 5000AD
Component TWA PEL TWA TLV
None established
Personal Protection:
Eye Protection : Safety glasses with side shields or goggles
Skin Protection : Rubber gloves, wash at meals and end of shifts
Respiratory Protection : No special protection is needed.
Ventilation : Provide adequate general mechanical exhaust.
SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES
Boiling Point (掳C) : 100掳C Percent Volatile By Vol. (%) : 49.5 %
Freezing Point (掳C) : < -10掳C Vapor Density (Air=1) : <1
Melting Point (掳C) : N/A Evaporation Rate (Buac=1) : >1
Vapor Pressure (mm Hg) : N/A Solubility In Water : Dispersible
Bulk Density (g/cbi.) : N/A Appearance & Odor : White milky emulsion,
Specific Gravity (H2O=1) : 0.9 鈥? 1.0 Characteristic Odor
SECTION 10: STABILITY AND REACTIVITY
Stable : Yes
Hazardous Polymerization : Will not occur
Conditions To Avoid : Open flames and sparks, extreme heat.
Incompatibility : None.
Hazardous Decomposition Products : Incomplete combustion can form CO, CO2, acrylate monomers and dense
smoke
SECTION 11: TOXICOLOGICAL INFORMATION
Skin Irritation : Non-irritant (Human patch test)
Primary Eye Irritation : No data.
Acute Oral Toxicity : Not determined.
Sensitization : Negative.
SECTION 12: ECOLOGICAL INFORMATION
No information is available.
SECTION 13: DISPOSAL CONSIDERATIONS
Method of Disposal : Dispose of in accordance with all applicable federal, state, and local regulations. Material
may be sent to an approved landfill or licensed treatment, storage, and disposal facility.
SECTION 14: TRANSPORT INFORMATION
No information is available.
SECTION 15: REGULATORY INFORMATION
No information is available.
SECTION 16: OTHER INFORMATION
Date Prepared : January 16, 1998
Date last revised : January 10, 2003
Note:
The statements made here are intended to describe the product with regard to necessary safety precautions. They do
not guarantee special characteristics. This information is furnished without warranty, expressed or implied, except
that it is accurate to the best of our current knowledge.
Page 2 of 3
|