P/N-48000E
Material Safety Data Sheet U.S. Department of Labor
May be used to comply with Occupational Safety and Health Administration
OSHA鈥檚 Hazard Communication Standard, (Non-Mandatory Form)
29 CFR 1910.1200 Standard must be Form Approved
consulted for specific requirements. OMB No. 1218-0072
IDENTITY (as used on label a nd list) Note: Blank spaces are not permitted. If any item is not applicable, or no information is available, the space must be marked to
indicate that.
Ultracare Disinfectant Cleaner/Deodorizer Concentrate
Section I
Manufacture鈥檚 Name Emergency Telephone Number
Ultronics Inc. 330-916-7070
Address (Number, Street, City, State, and Zip Code) Telephone Number for Information
235 Ascot Parkway 330-916-7070
Date Prepared
Cuyahoga Falls, OH 44223 April 18, 2004
Signature of Preparer (0ptional)\
Section II - Hazardous Ingredients/Identity Information
Hazardous Components (Specific Chemical Identity: Common Name(s)) OSHA PEL ACGOH TLV Other Limits Recommended % (optional)
1. Dual-Quaternary Ammonium Compound
n-Alkyl (60% C14, 30% C16, 5% C12, 5% C18) dimethyl benzyl ammonium chloride
n-Alkyl (68% C12, 32% C14) dimethylethyl benzyl ammonium chloride
2. Ethul Alcohol 1000ppm 1000ppm
Section III - Physical/Chemical Characteristics
Boiling Point Specific Gravity (H20=1)
121藲F 1.0390
Vapor Pressure (mm Hg.) Melting Point
22.3 N/A
Vapor Density (AIR-1) Evaporation Rate (Butyl Acetate=1)
(lb/ft3) 0.02 0.4
Solubility in Water
Completely miscible
Appearance and Odor
Concentrate-Purple, transparent liquid with slightly pungent scent
Section IV - Fire and Explosion Hazard Data
Flash Point (Method Used) Flammable Limits LEL UEL
Non-flammable (tag closed cup)No flashpoint below 200藲F N/A N/A N/A
Extinguishing Media
N/A
Special Fire Fighting Procedures
N/A
Unusual Fire and Explosion Hazards
N/A
(Reproduce locally) OSHA 174 Sept 1988
P/N-48000E
Section V - Reactivity Data
Stability Unstable Conditions to Avoid
None Known
Stable
X
Incompatibility (Materials to Avoid)
None Known
Hazardous Decomposition or Byproducts
Hazardous Polymerization May Occur Conditions to Avoid
None Known
Will Not Occur
X
Section VI - Health Hazard Data
Route(s) of Entry: Inhalation? Skin? Ingestion?
Most likely routes of entry are eye and skin. Only if swallowed
Health Hazards (Acute and Chroic)
For concentrate-Oral LD50: 5g/kg(Rat), Dermal LD50(Rabbit):鈮?2.0g/kg. Skin Irritation
(Rabbit):Not corrosive. Eye irritation(Rabbit):0.1ml without washing produced severe irritation
not reversible. However, the product produces practically no eye irritation when tested at a
concentration more typical of use(1:42or1:64). Not a skin sensitizer in guinea pigs when tested
by the Buehler sensitization contact allergy method.
Carcinogenicity: NTP? IARC Monographs? OSHA Regulated?
No No Not listed
Signs and Symptoms of Exposure
Direct skin contact can cause moderate to sever redness and swelling. Direct eye con-
tact can cause damage. Solvent vapors may irritate mucous membranes.
Medical Conditions (generally agrravated by exposure)
None Known
Emergency and First Aid Procedures
Eyes-flush with water 15 minutes-contact physician. Skin-wash area with large amounts of water
and soap for 15 minutes.
Section VII - Precausions for Safe Handling and Use
Steps to be taken in case material is released or spilled
Caution, floors may become slippery. For large spills, wear appropriate protective
clothing and like for recovery of disposal. For small spills, absorption sand or ver-
miculite and place in compatible chemical container for disposal.
Waste Disposal Method
Dispose of incompliance with all federal, state and local laws and regulations.
Precausions to be taken in handling and storing
Store upright, indoors in a clean, organized area. Make certain seals are firmly closed.
Other Precautions
N/A
Section VIII - Control Measures
Respiratory Protection (Specify Type)
Product is not administered as a vapor. If product is misused wear Nioch Respirator.
Ventilation Ploymerization Local Exhaust Special
N/A None
Mechanical (General) Other
X N/A
Protective Gloves Eye Protection
Rubber or Neoprene Chemical goggles or face shield
Other Protective Clothing or Equipment
Protective clothing, eye wash, shower
Work/Hygenic Practices
N/A
|