MATERIAL SAFETY DATA SHEET Printed 03/15/04
For Non-Skid Coatings and Paints Revised 03/15/04
SECTION I - PRODUCT IDENTIFICATION
Manufacturer: SURE-FOOT INDUSTRIES Information Phone: 1-440-234-4446
20260 First Avenue CHEM?TEL Phone: 1-800-255-3924
Cleveland, OH 44130
Series : MASTER STEP 750
Product Class : RUBBER PAINT Hazardous Rating: Health - 1
Trade Name : Non-Skid none -----> extreme Fire - 0
Product Code : 91002 , 91003, 91004, 91008 0 -------------> 4 Reactivity - 0
91023, & 91024
SECTION 11 - HAZARDOUS INGREDIENTS
Chemical Name CAS REG # Units TWA STEL TWA STEL
Acrylic copolymer Not Hazardous None None None None
Residual monomers Not Required NR NR NR NR
Aqua ammonia 1336-21-6 ppm None 35/A 25/A 35/A
Water 7732-18-5 None None None None
Rubber 139497-04-4 None None None None
NR - NOT REQUIRED A 鈥? As Ammonia
SECTION 111 - PHYSICAL DATA
APPEARANCE : Visible Solids ODOR : Slight Ammonia odor
STATE : Liquid VISCOSITY : 400 to 1500 CPS
PH : 8.9 to 9.7 MELTING POINT : 0C/32F Water
BOILING RANGE : 100?C/ 212?F Water VAPOR DENSITY (AIR + 1) : <1 Water
VAPOR PRESSURE : 17 mm hg @20?C/68?F Water SPECIFIC GRAVITY : 1.0 to 1.2 lbs/gal
EVAPORATION RATE : (Bac =1) <1 Water SOLUBILITY IN WATER : DILUTABLE
PERCENT VOLATILITY : 39 to 40% Water
SECTION IV - FIRE AND EXPLOSION HAZARD DATA
Flammability Class: Flash Point: LEL: VEL:
NON-COMBUSTIBLE
--UNUSUAL FIRE AND EXPLOSION HAZARDS: MATERIAL CAN SPLATTTER ABOVE 100C/212C. DRIED PRODUCT CAN
BURN
-- EXTINGUISHING AGENTS: USE EXTINGUISHING MEDIA APPROPRIATE FOR SURROUNDING AREA.
--PERSONAL PROTECTIVE EQUIPMENT: WEAR SELF CONTAINED BREATHING APPARATUS (PRESSURE-DEMAND NIOSH
APPROVED OR EQUIVALENT) AND FULL PROTECTIVE GREAR.
SECTION V - HEALTH HAZARD DATA
EFFECTS OF OVEREXPOSURE:
INHALATION: INHALATION OF VAPOR OR MIST CAN CAUSE THE FOLLOWING: HEADACHE, NAUSEA,
IRRITATION OF THE NOSE, THROAT, AND LUNGS.
SKIN CONTACT: PROLONGED OR REPEATED CONTACT CAN CAUSE A SLIGTH SKIN IRRITATION.
EYE CONTACT: DIRECT CONTACT WITH PRODUCT MAY RESULT IN EYE IRRITATION.
EMERGENCY AND FIRST AID PROCEDURES:
INHALATION: REMOVE TO FRESH AIR,
EYES: FLUSH THOROUGHLY WITH WATER. CONSULT A PHYSICIAN IF IRRITATION PERSISTS.
SKIN: WASH AFFECTIVE AREAS WITH SOAP AND WATER. CONSULT PHYSICIAN IF IRRIATATION PERSISTS
INGESTION: IF VICTIM IS CONSCIOUS, GIVE 2 GLASSES OF WATER TO DRINK. NEVER GIVE ANYTHING BY
MOUTH TO AN UNCONSCIOUS PERSON.
SECTION VI - REACTIVITY DATA
STABILITY: ? ? Unstable ? X ? Stable
AVOID TEMPERATURE ABOVE 177c/350f, THE ONSET OF POLYMER DECOMPOSITION. THERMAL DECOMPOSITION
IS DEPENDENT ON TIME AND TEMPERATURE.
HAZARDOUS POLYMERIZATION: ? ? May occur ? X ? Will not occur
--HAZARDOUS DECOMPOSITION PRODUCTS: THERMAL DECOMPOSITION MAY YIELD ACRYLIC MONOMERS.
--INCOMPATIBILITY: THERE ARE NO KNOWN MATERIALS THATARE INCOMPATIBLE WITHTHIS PRODUCT.
Page 2
MATERIAL SAFETY DATA SHEET
MASTER STEP 750 #91002, #91003, #91004, #91008, #910023, & #910024
SECTION VII - SPILL OR LEAK PROCEDURES
--STEP TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED: USE SAND OR OTHER INERT MATERIAL TO DAM
AND CONTAIN SPILL. FLOOR MAY BE SLIPPERY; USE CARE TO AVOID FALLING. TRANSFER LIQUID AND DIKING
MATERIAL TO SEPARATE SUITABLE CONTAINERS FOR RECOVERY OR DISPOSAL. KEEP SPILL OUT OF SEWER OR
OPEN BODIES OF WATER. KEEP SPECTATORS AWAY.
--WASTE DISPOSAL METHOD: COAGULATE THE EMULSION BY THE STEPWISE ADDITION OF FERRIC CHLORIDE AND
LIME. REMOVE THE CLEAR SUPERNANT AND FLUSH TO A CHEMICAL SEWER. LANDFILL OR INCINERATE IN
ACCORDANCE WITH LOCAL, STATE AND FEFDERAL REGULATIONS.
SECTION VIII - SAFE HANDLING AND USE INFORMATION
--STORAGE CONDITIONS: KEEP FROM FREEZING:MATERIAL MAY COAGUALTE. THE MINIMUM STORAGE
TEMPERATURE FOR THIS MATERIAL IS 1C/34F. THE MAXIMUM RECOMMENED STORAGE TEMPERATURE
FOR THIS MATERIAL IS 49C/120F.
--HANDLING PROCEDURES: MAINTAIN ADEQUATE VENTILATION.
SECTION IX - SPECIAL PRECAUTIONS
--RESPIRATORY PROTECTION: A RESPITORY PROTECTION PROGRAM MEETING OSHA 1910-134 AND ANSI Z88.2
REQUIRMENTS MUST BE FOLLOWED WHENEVER WORKPLACE CONDITIONS WARRANT A RESPITATOR鈥橲 USE.
NONE REQUIRED IF AIRBORNE CONCENTRATIONS ARE MAINTAINEDBELOW THE EXPOSURE LIMIT LISTED IN
EXPOSURE LIMIT INFORMATION. FOR AIRBORNE CONCENTRATIONS UP TO 10 TIMES THE EXPOSURE LIMIT,
WEAR NOISH APPROVED(OR EQUIVALENT)HALF-MASK, AIR PURIFYING RESPIRATOR. AIR-PURIFYING
RESPIRATORS SHOULD BE EQUIPPED WITH NOISH APPROVED (OR EQUVALENT) CARTIDGES FOR PROTECTION
AGAINST AMMONIA AND METHYLAMINE AND FILTERS FOR PROTECTION AGAINST DUSTS AND MISTS
--EYE PROTECTION: USE SAFETY GLASSES WITH SIDE SHEILDS (ANSI Z87.1 OR EQUIVALENT). EYE PROTECTION MUST BE
COMPATIBLE WITH RESPIRATORY PROTECTION SYSTEM EMPLOYED.
--HAND PROTECTION: NEOPRENE GLOVES MAY PROVIDE PROTECTION AGAINST PERMEATION. GLOVES OF OTHER
CHEMICALLY RESISTANT MATERIALS MAY NOT PROVIDE ADEQUATE PROTECTION.
--ENGINEERING CONTROLS (VENTILATION): USE LOCAL EXHAUST VENTILATION WITH A MINIMUM CAPTURE
VELOCITY OF 100 FT/MIN. (0.5M/SEC) AT THE POINT OF VAPOR EVOLUTION.
SECTION X - STATE REGULATIONS
Workplace Classifications 鈥? This product is considered non-hazardous under the OSHA Hazard Communication Standard
(29CFR1910.1200). This product is NOT a 鈥淐ontrolled product鈥? under Canadian Workplace Hazardous Material Information
System (WHMIS).
SARA TITLE # Section 311/312 Categorization (40CFR370)- This product is NOT a hazardous chemical under 29CFR1910.1200,
and therefore is not covered by Title III of SARA.
SARA Title # Section 313 Information (40CFR372)- This product doe NOT contain a chemical which is listed in Section 313 at or
above de minimis concentrations.
CERCLE 鈥? Information (40CFR302.4) 鈥? Releases of this material to air, land, or water are not reportable to the National Response
center under the Comprehensive Environmental Response, Compensation, and Liability Act (CERLA) or to Sate and Local
emergency planning committees under the Super fund Amendments and Reauthorization Act (SARA Title III Section 304.
Waste Classification 鈥? When a decision is made to discard this material as supplied, it does not meet RCRA鈥檚 characteristic definition
of ignitability, corrosivity, or reactivity and is not listed in 40 CFR 261.33. The toxicity characteristic (TC), however, has not
been evaluated by the Toxicity Characteristic Leaching Procedure (TCLP).
United States 鈥? All components of this product are in compliance with the inventory listings requirements of the US Toxic Substance
Control Act (TSCA) Chemical Substance inventory.
THE INFORMATION CONTAINED HEREIN IS, TO THE BEST OF OUR KNOWLEDGE AND BELIEF, ACCURATE.
HOWEVER, SINCE CONDITIONS OF HANDLING CHANGE AND USE ARE BEYOND OUR CONTROL, WE MAKE NO GUARANTEE
OF RESULTS, AND ASSUME NO LIABILITY FOR DAMAGES INCURRED BY USE OF THIS MATERIAL. IT IS THE
RESPONSIBILITY OF THE USER TO COMPLY WITH ALL APPLICABLE FEDERAL, STATE AND LOCAL LAWS AND
REGULATION.
|