541200 (541) Shaft & Bearing Retaining Compound
PRODUCT:
MSDS ID: ND2215
11/13/98
ORIG. DATE:
6/2/04
REV. DATE:
7/3/07
REV. DATE:
ND INDUSTRIES , INC. (248) 288-0000 Fax: (248) 288-0022
24 hr. EMERGENCY CHEMTREC:
1893 BARRETT ROAD
Chemical Safety
PREPARED BY:
1-800-424-9300
TROY, MICHIGAN 48084
H: 2 F: 1 R: 1 PPE:
B
SECTION I -Material Identification and Information
PERCENT OSHA OTHER LIMITS
ACGIH
CAS #
COMPONENTS PEL RECOMMENDED
TLV
%
Ethoxylated Dimethacrylate NDA-10-480 24448-20-2 40-50 n.e. n.e.
Hydroxyalkyl Methacrylate NDA-10-235 27813-02-1 30-35 n.e. n.e.
Bisphenol A Fumarate Resin NDA-10-152 39382-25-7 15-20 n.e. n.e.
Cumene Hydroperoxide NDA-10-151 80-15-9 1-3 n.e. n.e.
Saccharin NDA-10-150 81-07-2 .5-4 n.e. n.e.
All ingredients are listed on the TSCA Inventory. n.a.= not applicable / n.e.=not established
SECTION II -Physical and Chemical Characteristics
BOILING POINT: >200掳F
VOC #/gal. : 3.55
VAPOR DENSITY: n.a. air = 1
DENSITY OF COATING:
VAPOR PRESSURE: <10 mmHg @ 80掳F
MELTING POINT: n.a.
SPECIFIC GRAVITY: 1.09 water = 1
EVAPORATION RATE: n.a.
WATER REACTIVE: n.a.
SOLUBILITY IN WATER: Slight
APPEARANCE AND ODOR: Green liquid with sharp cumene odor.
SECTION III - Fire and Explosion Hazard Data
FLASH POINT: > 200掳C T.O.C.
AUTOIGNITION TEMPERATURE: not determined
UEL: not determined
FLAMMABILITY LIMITS % IN AIR: LEL: not determined
EXTINGUISHER MEDIA: Use carbon dioxide, foam or dry chemical.
Wear a NIOSH approved self-contained breathing apparatus operated in pressure-demand or other positive
SPECIAL
pressure when fighting fires. Sealed containers may rupture explosively if exposed to heat.
FIREFIGHTING
PROCEDURES:
UNUSUAL FIRE Irritating organic vapors.
HAZARDS AND
CONDITIONS TO
AVOID:
PRODUCT: 541200 (541) Shaft & Bearing Retaining Compound
SECTION IV - Reactivity Hazard Data
STABILITY: stable: X unstable:
HAZARDOUS POLYMERIZATION: may occur: X will not occur:
CONDITIONS High temperature, and direct sunlight.
TO AVOID:
INCOMPATIBILITY: Reducing agents.
HAZARDOUS None known.
DECOMPOSITION
PRODUCTS:
SECTION V - Health Hazard Data
X
PRIMARY ROUTES OF ENTRY: X
INHALATION: INGESTION: SKIN ABSORPTION:
EYE CONTACT: A primary route of exposure that will cause eye irritation characterized by excessive tearing, redness and blinking.
Flush eyes with generous amounts of water for at least 15 minutes, lifting both upper and lower eyelids
FIRST AID: frequently. Get medical attention.
A primary route of exposure that may cause moderate skin irritation and allergic skin reaction. May cause rash,
SKIN
redness, swelling and blistering (symptoms may be delayed)
CONTACT:
Thoroughly wash exposed area with soap and water. If irritation develops, seek medical attention. Launder
clothing before reuse.
FIRST AID:
Not a likely route of exposure.
INHALATION:
If overcome by exposure, victim should be removed to fresh air immediately. Give artificial respiration as needed.
FIRST AID:
Get immediate medical attention.
INGESTION: Ingestion may cause irritation of the gastrointestinal tract.
FIRST AID: Do no induce vomiting. Keep individual calm. Immediately seek medical attention.
May cause dermatitis on prolonged contact in sensitive individuals.
CHRONIC
EFFECTS:
Carcinogenic: Contains saccharin which has been determined to cause cancer in laboratory animals.
PRODUCT: 541200 (541) Shaft & Bearing Retaining Compound
Component Oral LD50 Dermal LD50 Inhalation LC50
not determined
not determined
Aromatic Dimethacrylate Ester not determined
not determined
not determined
Hydroxyalkyl Methacrylate not determined
not determined
not determined
Bisphenol A Fumarate Resin not determined
700 ppm Rat
Severe irritation
Cumene Hydroperoxide 800-1600 mg/Kg
not determined
not determined
Saccharin not determined
SECTION VI - Control and Protective Measures
RESPIRATORY None needed for normal use. Work in a well ventilated area.
PROTECTION:
PROTECTIVE Disposable polyethylene gloves with vinyl latex over gloves will give protection.
GLOVES:
EYE PROTECTION: Wear NIOSH approved safety glasses with side shields or chemical splash goggles.
VENTILATION LOCAL EXHAUST: X MECHANICAL: SPECIFIC:
TO BE USED: OTHER (specify):
PROTECTIVE CLOTHING Wear impervious clothing to prevent repeated, prolonged skin contact.
AND EQUIPMENT:
Practice good personal hygiene and wash hands after handling product.
HYGIENIC WORK
PRACTICES:
SECTION VII - Precautions for Safe Handling and Spill/Leak Procedures
STEPS TO BE TAKEN IF MATERIAL IS SPILLED OR RELEASED:
Dike area to prevent spreading. Absorb on vermiculite, sand or other inert absorbing material.
Dispose of as a chemical waste in accordance with current local, state, and federal regulations
WASTE DISPOSAL
METHODS:
Avoid prolonged skin contact. Store product below 110掳F to preserve shelf life.
SAFE HANDLING
AND STORAGE:
OTHER PRECAUTIONS AND SPECIAL HAZARDOUS INFORMATION:
Avoid prolonged skin contact. Keep away from eyes.
RECOMMENDED 2 1 1 B
HEALTH FLAMMABILITY REACTIVITY PERSONAL
NFPA/HMIS PROTECTION
note: ratings may differ according to application, environment, and physical state.
RATING
PRODUCT: 541200 (541) Shaft & Bearing Retaining Compound
NOTES:
Shipping Regulations:
DOT and IATA Hazard Classification: Non restricted Articles
Proper DOT Shipping Name: N/A
SECTION 313 SUPPLIER NOTIFICATION
Detaching this notification from the Material Safety Data Sheet is prohibited by law and any copying or
distribution of same requires this attachment be included.
This product contains the following toxic chemicals subject to the reporting requirements of section 313
of the Emergency Planning and Community Right-To-Know Act of 1986 and 40 CFR 372:
CAS # CHEMICAL NAME % BY WEIGHT
80-15-9 Cumene hydroperoxide <3
107-21-1 Ethylene Glycol
This product contains the following materials that under California Proposition 65 of the Safe Drinking Water and Toxic
Enforcement Act of 1986 are recognized to cause cancer or reproductive toxicity.
Cancer Reproductive cancer Reproductive
Concentration &
Material CAS # agent Toxin
Agent Toxin
%
Saccharin 81-07-2 0.1-1% X
Ethylene Glycol 107-21-1 X
Vibra-TITE is a trademark of ND Industries, Inc.
The information contained herein is based on the data available to us and is believed to be correct. However, ND Industries庐,
Inc. makes no warranty, expressed or implied regarding the accuracy of these data or the results to be obtained from the use
thereof. Information is supplied upon the condition that the persons receiving same will make their own determination as to its
suitability for their properties prior to use. Since conditions of use are beyond our control, all risks are assumed by the user.
|