Fire
庐 2 Reactivity
2 0
Health
0
Special
NFPA
MATERIAL SAFETY DATA SHEET
I. PRODUCT IDENTIFICATION
Telephone:
Manufacturer: WD-40 Company
Emergency Only: 1 (800) 424-9300 (CHEMTREC)
Address: 1061 Cudahy Place (92110) Information: (619) 275-1400
P.O. Box 80607 Chemical Name: Organic Mixture
San Diego, California
Trade Name: WD-40 Aerosol
92138-0607 Item No. 10002, 10005, 10008, 10011,
10013, 10016, 10023
II. HAZARDOUS INGREDIENTS
Exposure Limit
Chemical Name CAS Number % ACGIH/OSHA
Aliphatic Petroleum Distillates 8052-41-3 60-70 100 ppm PEL
5 mg/M3
Petroleum Base Oil 64742-65-0 15-25 TWA (mist)
Carbon Dioxide 124-38-9 2-3 5000 ppm PEL
Non-hazardous Ingredients <10
III. PHYSICAL DATA
Boiling Point: NA Evaporation Rate: Not determined
110 卤5 PSI @ 70掳F
Vapor Density (air = 1): Greater than 1 Vapor Pressure:
Solubility in Water: Insoluble Appearance: Light amber
Specific Gravity (H 20 = 1): 0.816 @ 70掳F Odor: Characteristic odor
Percent Volatile (volume): 70%
IV. FIRE AND EXPLOSION
Flash Point: Tag Open Cup 110掳F (minimum)
Flammable Limits: (Solvent Portion) [Lel] 1.0% [Uel] 6.0%
Extinguishing Media: CO2 , Dry Chemical, Foam
Special Fire Fighting Procedures: Contents Under Pressure
Unusual Fire and Explosion Hazards: FLAMMABLE 鈥? U.F.C. level 3 AEROSOL
V. HEALTH HAZARD / ROUTE(S) OF ENTRY
Threshold Limit Value
Aliphatic Petroleum Distillates (Stoddard solvent) lowest TLV (ACGIH 100 ppm.)
Symptoms of Overexposure
Inhalation (Breathing): May cause anesthesia, headache, dizziness, nausea and upper respiratory irritation.
Skin Contact: May cause drying of skin and/or irritation.
Eye Contact: May cause irritation, tearing and redness.
Ingestion (Swallowed): May cause irritation, nausea, vomiting and diarrhea.
First Aid Emergency Procedures
Ingestion (Swallowed): Do not induce vomiting, seek medical attention.
Eye Contact: Immediately flush eyes with large amounts of water for 15 minutes.
Skin Contact: Wash with soap and water.
Inhalation (Breathing): Remove to fresh air. Give artificial respiration if necessary.
If breathing is difficult, give oxygen.
Pre-existing medical conditions such as eye, skin and respiratory disorders may be
aggravated by exposure.
DANGER!
Aspiration Hazard: If swallowed, can enter lungs and may cause chemical pneumonitis.
Do not induce vomiting. Call Physician immediately.
Suspected Cancer Agent
x
Yes No The components in this mixture have been found to be noncarcinogenic by NTP, IARC
and OSHA.
VI. REACTIVITY DATA
x
Stability: Stable Unstable
Conditions to avoid: NA
Incompatibility: Strong oxidizing materials
Hazardous decomposition products: Thermal decomposition may yield carbon monoxide and/or carbon dioxide.
x
Hazardous polymerization: May occur Will not occur
VII. SPILL OR LEAK PROCEDURES
Spill Response Procedures
Spill unlikely from aerosol cans. Leaking cans should be placed in plastic bag or open pail until pressure has dissipated.
Waste Disposal Method
Empty aerosol cans should not be punctured or incinerated; bury in land fill. Liquid should be incinerated or buried in land
fill. Dispose of in accordance with local, state and federal regulations.
VIII. SPECIAL HANDLING INFORMATION
Ventilation: Sufficient to keep solvent vapor less than TLV.
Respiratory Protection: Advised when concentrations exceed TLV.
Protective Gloves: Advised to prevent possible skin irritation.
Eye Protection: Approved eye protection to safeguard against potential eye contact,
irritation or injury.
Other Protective Equipment: None required.
IX. SPECIAL PRECAUTIONS
Keep from sources of ignition. Avoid excessive inhalation of spray particles, do not take internally. Do not puncture, incinerate or
store container above 120掳F. Exposure to heat may cause bursting. Keep can away from electrical current or battery terminals.
Electrical arcing can cause burn-through (puncture) which may result in flash fire, causing serious injury. Keep from children.
X. TRANSPORTATION DATA (49 CFR 172.101)
Domestic Surface
Description: Consumer Commodity
Hazard Class: ORM-D
ID No.: NONE
Label Required: Consumer Commodity (ORM-D)
Domestic Air
Description: Consumer Commodity (Non-Flammable Gas 鈥? Aerosol)
Hazard Class: ORM-D
ID No.: NONE
Label Required: Consumer Commodity (ORM-D-AIR)
XI. REGULATORY INFORMATION
All ingredients for this product are listed on the TSCA inventory.
SARA Title III chemicals: None
California Prop 65 chemicals: None
CERCLA reportable quantity: None
RCRA hazardous waste no.: D001 (Ignitable)
Technical Director
SIGNATURE: TITLE:
March 1998 June 1996
REVISION DATE: SUPERSEDES:
NA = Not applicable NDA = No data available < = Less than > = More than
We believe the statements, technical information and recommendations contained herein are reliable. However, the data is provided without warranty,
expressed or implied. It is the user鈥檚 responsibility both to determine safe conditions for use of this product and assume loss, damage or expense, direct or
consequential, arising from its use. Before using product, read label. MSDS-A
|