Laidlaw Corporation Date Signed: 9/15/2004 Transportation: Chemtrec
5326 Industrial Park Rd Prepared by: John T. Beckman Emergency: 1-800-424-9300
Metropolis, IL 62960
MATERIAL SAFETY DATA SHEET
I. IDENTIFICATION
Product Name: P.O.G (Paint, Oil, and Grease Remover)
Chemical Name: Spot and stain remover.
Cas Number: MIXTURE
Emergency Telephone Number: (618) 524-9394
II. COMPONENTS AND HAZARD INFORMATION
Component CAS NO. of TLV of OSHA Approximate
Component Component Pel Concentration
Diacetone Alcohol 123-42-2 50 ppm 50 ppm 25.00%
Orthodichlorobenzene 95-50-1 50 ppm 50 ppm 10.00%
Paraffin Oil 64741-89-5 5 mg/m鲁 5mg/m鲁 10.00%
Aromatic 100 64742-95-6 50 ppm 50 ppm 25.00%
This product contains Orthodiclorobenzene which is subject to the reporting requirements of SARA III.
DOT Hazard Classification: Combustible Liquid NOS (contains Petroleum Distillates), NA 1993, PG III
Hazardous Materials Identification System (HMIS)
Health Flammability Reactivity BASIS
2 2 1 Recommended by Laidlaw
TLV for Total Product BASIS
50 ppm Calculated TLV REF ACGIH
III. PHYSICAL DATA
Boiling Point 260掳 F Vapor Density Not determined
Vapor Pressure Not determined. Percent Volatiles 75.00%
Specific Gravity 0.936 Evaporation Rate Not determined
IV. FIRE AND EXPLOSION DATA
124掳 F
Flash Point (掳F TCC)
Chemical foam.
Extinguishing Media
_________________________________________________________________________________
Self contained breathing equipment operated in positive pressure mode.
Special Firefighting Procedure
________________________________________________________________________
None.
Unusual Fire & Explosion Hazards
________________________________________________________________________
________________________________________________________________________
National Fire Protection Association (NFPA -) Hazard Identification
Health Flammability Reactivity BASIS
2 2 2 Recommended by Laidlaw
V. HEALTH HAZARD DATA
Effects of Overexposure:
Can cause severe irritation, redness, tearing, blurred vision.
Eyes:
____________________________________________________________________________________________
Prolonged or repeated contact can cause moderate irritation.
Skin:
____________________________________________________________________________________________
Breathing: Excessive inhalation of vapors can cause nasal and respiratory irritation.
____________________________________________________________________________________________
Swallowing: Can cause gastrointestinal irriation, nausea, and vomiting.
____________________________________________________________________________________________
First Aid Procedures:
Do not induce vomiting. Get medical attention.
Swallowing:
____________________________________________________________________________________________
Wash exposed area with soap and water.
Skin:
____________________________________________________________________________________________
Inhalation: Remove to fresh air, administer oxygen if breathing is difficult.
____________________________________________________________________________________________
Flush with water for at least 15 minutes.
Eyes:
____________________________________________________________________________________________
Health studies have shown that health risks vary from person to person. As a precaution exposure to liquids, vapors, misty
fumes or dust should be minimized.
VI. REACTIVITY DATA
Hazardous Polymerization: Cannot occur.
Stability: Stable.
Incompatibility: Avoid contact with strong oxidizing agents.
Hazardous Decomposition Products: May form toxic hydrocarbons at high temperatures.
_______________________________________________________________
VII. SPILL OR LEAK PROCEDURES
Steps to be taken in case material is released or spilled:
Absorb on paper or other absorbent material. Dispose of in accordance with local, state, and federal, regulations. Keep
out of water supply. Contain large spills and transfer to closed metal containers. Dispose of in a permitted hazardous
waste management facility.
VIII. PROTECTION AND PRECAUTIONS
Respiratory Protection: Approved organic vapor respirator if exposure may or does exceed TLV limits.
_____________________________________________________________________________________________________
_____________________________________________________________________________________________________
Ventilation : Provide sufficient ventilation to maintain exposure below TLV.
Protective Gloves: None normally required.
Eye Protection : Splash goggles if eye contact is likely to occur.
Other Protective Equipment: None
Other Precautions: None
IX. PRECAUTIONS OR OTHER COMMENTS
Precautions to be taken in handling and storing: Maintain good housekeeping. Avoid contact with eyes. Wash thoroughly
after handling. Use with adequate ventilation.
The information and recommendations accumulated herein are to be the best of Laidlaw's knowledge and belief, accurate
and reliable as of the date issued. Laidlaw does not warrant or guarantee their accuracy or reliability and shall not be liable
for any loss or damage arising out of the use thereof.
HMIS and NFPA recommended ratings are based upon the criteria supplied by the developers of these systems together
with Laidlaw's interpretation of the available data.
2 of 2
P.O.G (Paint, Oil, and Grease RePage
|