MATERIAL SAFETY DATA SHEET
PRODUCT NAME: RUST LICK 631 HMIS CODES:
LONG-TERM RUST PREVENTATIVE Health = 1
PART NUMBERS: Flammability = 2
1 GAL = 71011 Reactivity = 0
5 GAL = 71051
55 GAL = 71551
____________________________________________________________________________
SECTION 1 - MANUFACTURER IDENTIFICATION
____________________________________________________________________________
MANUFACTURER'S NAME: ITW ROCOL NORTH AMERICA
ADDRESS : 3624 West Lake Avenue
Glenview Illinois 60026
EMERGENCY PHONE : 800-424-9300 (CHEMTREC)
INFORMATION PHONE: 800-452-5823 DATE REVISED : 1/26/06
NAME OF PREPARER : Leroy Hitchcock SUPERCEDES : 12/16/03
___________________________________________________________________________
SECTION 2 - INGREDIENTS
____________________________________________________________________________
COMPONENT CAS # WEIGHT PERCENT
---------------------------------------------------------------------------
PETROLEUM SOLVENT 64742-47-8 71-90%
SEVERLY HYDROTREATED 64742-52-5 10-15%
PETROLEUM OIL
Dimethyl Phthalate 131-11-3 < 0.5%
SARA Title III Sec. 313 toxic chemical
* Indicates chemical(s) subject to the reporting requirements of OSHA's
Hazard Communication Standard 1910.1200.
All components of this product are listed on TSCA.
____________________________________________________________________________
SECTION 3 - PHYSICAL/CHEMICAL CHARACTERISTICS
____________________________________________________________________________
BOILING POINT: 250掳F SPECIFIC GRAVITY (H2O=1): 0.82
VAPOR DENSITY: (Air = 1): >1 EVAPORATION RATE: (BuAc=1): <1
SOLUBILITY IN WATER: Insoluble
APPEARANCE AND ODOR: Brown liquid with hydrocarbon odor
NOTE: This product has been evaluated and determined to meet the low vapor
pressure (LVP) exemption set by the California Air Resources Board for Volatile
Organic Compounds (California Code of Regulations, Title 17, Article 2, section
94510).
____________________________________________________________________________
SECTION 4 - FIRE AND EXPLOSION HAZARD DATA
____________________________________________________________________________
FLASH POINT: 180掳F METHOD USED: TCC
FLAMMABLE LIMITS IN AIR BY VOLUME- LOWER: 0.7% UPPER: 6.0%
EXTINGUISHING MEDIA: Water No, CO2 Yes, Dry chemical Yes, Foam Yes,
Alcohol foam No.
SPECIAL FIREFIGHTING PROCEDURES: Fire fighters should wear self-contained
breathing apparatus in confined areas.
UNUSUAL FIRE AND EXPLOSION HAZARDS: None.
____________________________________________________________________________
SECTION 5 - REACTIVITY DATA
____________________________________________________________________________
STABILITY: Chemically stable.
CONDITIONS TO AVOID: None
INCOMPATIBILITY (MATERIALS TO AVOID): Strong oxidizing agents.
HAZARDOUS DECOMPOSITION OR BYPRODUCTS: Oxides of carbon.
HAZARDOUS POLYMERIZATION: Will not occur.
____________________________________________________________________________
SECTION 6 - HEALTH HAZARD DATA
____________________________________________________________________________
INHALATION HEALTH RISKS AND SYMPTOMS OF EXPOSURE: High concentrations of
vapors may produce irritation of the respiratory tract, headache,
dizziness, and nausea.
SKIN AND EYE CONTACT HEALTH RISKS AND SYMPTOMS OF EXPOSURE: Slight
irritation.
SKIN ABSORPTION HEALTH RISKS AND SYMPTOMS OF EXPOSURE: Slight irritant.
INGESTION HEALTH RISKS AND SYMPTOMS OF EXPOSURE: No data.
HEALTH HAZARDS (ACUTE AND CHRONIC):
Acute: Slight irritation.
Chronic: Effects are not known.
CARCINOGENICITY: NTP CARCINOGEN: No
IARC MONOGRAPHS: No
OSHA REGULATED: No
ACGIH CARCINOGENICITY: No
MEDICAL CONDITIONS GENERALLY AGGRAVATED BY EXPOSURE: Skin disorders.
EMERGENCY AND FIRST AID PROCEDURES:
EYES: Flush well with water. Contact a physician if irritation persists.
SKIN: Wash with soap and water.
INHALATION: No emergency care anticipated under normal conditions.
INGESTION: Do not induce vomiting. Contact a physician. If vomiting
occurs, keep head below hips to prevent aspiration of liquid into lungs.
____________________________________________________________________________
SECTION 7 - PRECAUTIONS FOR SAFE HANDLING AND USE
____________________________________________________________________________
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED: Prevent skin
and eye contact. Use non-combustible material to confine and/or absorb.
Eliminate ignition sources. Ventilate area.
WASTE DISPOSAL METHOD: Remove to a waste disposal facility operating in
compliance with federal, state, and local regulations. Waste rags soaked
with coolant should be disposed of into oily waste cans.
Applicable CERCLA/RCRA Hazardous Waste Codes: None
DOT TRANSPORTATION: Not regulated
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING: If mists are generated in
the use of this product; then the following values for petroleum oils
apply:
---ACHIG - TLV/TWA = 5 mg/m3/8hr
---OSHA - PEL/TWA = 5 mg/m3/8hr
---ACGIH - TLV/STEL = 10 mg/m3
SHIPPING CLASSIFICATIONS:
GROUND SHIPMENTS: Non-hazardous
BULK, AIR, AND VESSEL SHIPMENTS: Petroleum distillates, N.O.S., Combustible
Liquid, UN1268, PG III
____________________________________________________________________________
SECTION 8 - CONTROL MEASURES
____________________________________________________________________________
RESPIRATORY PROTECTION: None required at normal handling temperatures.
VENTILATION: Local exhaust is recommended for confined areas. General
mechanical ventilation is adequate for normal use.
PROTECTIVE GLOVES: Chemical resistant rubber gloves, such as polyvinyl
chloride-coated, and other protective gear as required to minimize
skin contact.
EYE PROTECTION: Safety glasses. Splash proof goggles.
OTHER PROTECTIVE CLOTHING OR EQUIPMENT: Eye bath and safety shower.
WORK/HYGIENIC PRACTICES: Follow current H.M.I S. regulations.
____________________________________________________________________________
SECTION 9 - DISCLAIMER
____________________________________________________________________________
ITW ROCOL NORTH AMERICA bases the information and recommendations in this
document on data believed to be correct. No warranty of any kind,
however, is made as to the information in this document.
|