HENRY COMPANY CANADA INC.
10 St-Pierre, Lachine, Quebec H8R 1N7
Tel.:(514) 364-5224 Fax:(514)364-7270
EMERGENCY TEL. NO.: (514) 364-5224
MATERIAL SAFETY DATA SHEET
WHMIS: D-2B
I - PRODUCT INFORMATION
Bakor 120-19
PRODUCT NAME
Polyvinyl Acetate Emulsion
PRODUCT TYPE
Fire resistive coating for thermal insulation
PRODUCT USE
II - HAZARDOUS INGREDIENTS
INGREDIENTS % CAS # EXPOSURE LIMITS LD50/LC50(SPECIES & ROUTE)
Ethylene Glycol 1-5 107-21-1 50 ppm TLV LD50 (oral-rat) > 4700 mg/kg
(vapour, ACGIH) LD50 (dermal-rabbit) > 9530 mg/kg
III - PHYSICAL DATA
PHYSICAL [ ] GAS ODOUR & APPEARANCE ODOUR THRESHOLD (ppm)
White, medium viscosity liquid. Acetic acid odour. Not available
STATE [x] LIQUID
[ ] SOLID
VOC
VOLATILE (VOL.) VAPOUR PRESSURE (mm Hg) VAPOUR DENSITY (AIR = 1) EVAPORATION RATE (BuAc=1)
53% <100 g/L As for water As for water As for water
BOILING POINT (掳C) FREEZING POINT (掳C) SPEC. GRAVITY (WATER - 1) DENSITY (g / ml)
Approx. 100掳C Approx. 0掳C 1.28 1.28
Miscible in water as supplied
SOLUBILITY (IN WATER) COEF. OF WATER/OIL DIST. pH
Insoluble when dry. Not available 6-8
IV - FIRE & EXPLOSION HAZARD
FLAMMABILITY [ ] YES CONDITIONS OF FLAMMABILITY
Not applicable.
[ X ] NO
None
FLASH POINT (掳C): FLAMMABLE LIMITS (% VOLUME) AUTO-IGNITION TEMP. (掳C)
-- None None None
METHOD: LOWER: UPPER:
TDG FLAMMABILITY CLASS SENSITIVITY TO MECHANICAL IMPACT SENSITIVITY TO STATIC DISCHARGE
Not regulated None None
On burning (dry film), some CO, HCl and chlorine..
HAZARDOUS COMBUSTION
Main combustion products are H2O, CO2 and C (as heavy smoke).
PRODUCTS
Not applicable
MEANS OF EXTINCTION
Not applicable
SPEC. FIRE FIGHTING PROCEDURES
V - PREPARATION OF M.S.D.S.
PREPARED BY: PHONE NUMBER DATE
WHMIS Group (514) 364-5224 May 2006
VI - REACTIVITY DATA Bakor 120-19
CHEMICAL [ X ] YES CONDITIONS TO AVOID:
Not applicable.
STABILITY [ ] NO
Materials that react with water.
INCOMPATIBILITY
(SUBSTANCE TO AVOID)
Not applicable.
CONDITIONS
OF REACTIVITY
Will not decompose under normal conditions of handling or warehousing.
HAZARDOUS DECOMPOS-
ITION PRODUCTS
VII - TOXICOLOGICAL PROPERTIES
THRESHOLD LIMIT VALUE LC50/LD50 (estimated) LD50 (oral-rat) > 4700 mg/kg
50 ppm LD50 (dermal-rabbit) > 9530 mg/kg
ROUTE OF ENTRY [ ] SKIN CONTACT [ ] SKIN ABS. [x] EYES [x] INGESTION [ ] INHALATION
Not known but product could probably cause eye irritation if not washed immediately.
EFFECTS OF ACUTE
Could also cause gastro-intestinal problems if ingested in large quantity.
EXPOSURE
EFFECTS OF
Not known
CHRONIC EXPOSURE
Not known
IRRITANCY SENSITIZATION SYNERGISTIC MATERIALS
Not known Not known.
[ ] CARCINOGENICITY [ ] REPRODUCTIVE EFFECTS [ ] TERATOGENICITY [ ] MUTAGENICITY
Product not believed to cause any of these effects.
VIII - FIRST AID MEASURES
Thoroughly wash with soap and water.
SKIN
Flush eyes thoroughly with plenty of lukewarm water. Get medical attention if needed..
EYES
Should not cause problems.
INHALATION
If victim is conscious, give two glasses of water to drink and induce vomiting.
INGESTION
Obtain medical attention.
IX - PREVENTIVE MEASURES
Safety goggles if applied by spray..
EYES:
Suggested.
PERSONAL GLOVES:
Regular.
PROTECTIVE CLOTHING:
No special equipment required.
EQUIPMENT RESPIRATORY:
Not required.
ENGINEERING CONTROLS
(VENTILATION, ETC.)
Wet material: Scrape up to disposal containers. Wash with water.
LEAK AND SPILL
Dry material: Scrape off heavy deposit. Wash off with paint strippers.
PROCEDURE
Approved incineration or sanitary landfill as per local, provincial, state and federal
WASTE
regulations.
DISPOSAL
Normal.
HANDLING PROCEDURES
Protect from freezing.
STORAGE REQUIREMENTS
Protect from freezing.
SHIPPING INFORMATION
While Henry Company Canada Inc. believes that the data contained herein are factual & opinionsexpressed are those of qualified experts regarding the results of the
tests conducted, the data is not to be taken as warranty or representation for which Henry Company Canada Inc. assumes legal responsibility. These are offered solely
for your consideration, investigation and verification. Any use of this data and information must be determined by the user to be in accordance with federal,
provincial or municipal laws and regulations.
|