SECTION V HEALTH HAZARD DATA
MATERIAL SAFETY DATA SHEET CC 352
Threshold Limited Value
ALDON As Cobalt metal, dust or fume: TWA: 0.02 mg/m3 (air) (ACGIH 1992-93).
1533 W.Henrietta Rd.
CC 352
Avon, New York 14414 MSDS No.
庐
CORPORATION August 9, 1996
Effective Date
(716) 226-6177
Effects of Overexposure
EYES: Contact with eyes causes irritation. SKIN: Prolonged or repeated
exposure causes irritation and may result in an allergic skin reaction.
SECTION I NAME 24 HOUR EMERGENCY ASSISTANCE INGESTION: May cause vomiting, diarrhea, and a sensation of hotness.
Product COBALTOUS CHLORIDE 1.0 MOLAR AQ. SOL鈥橬
CHEMTREC Health 2
800-424-9300
Chemical
Emergency and
Cobalt Chloride, Water Solution INGESTION: If conscious, give one or two glasses of water to drink,
Synonyms 0
Fire
Day 716-226-6177
First Aid Procedures induce vomiting and call a physician. Never give anything by mouth to an
Formula Mixture. See Section II. 0
Reactivity unconscious person. SKIN: Flush with water, then wash with mild soap
NFPA
and water. EYES: Flush thoroughly with water, lifting upper and lower
HAZARD RATING HMIS *
Unit Size up to 4 Lt.
eyelids occasionally. If irritation develops or persists, get medical attention.
LEAST SLIGHT MODERATE HIGH EXTREME
0 1 2 3 4 INHALATION AS MIST: Remove to fresh air. If discomfort or illness
C.A.S. No. Mixture. See Section II.
develops, get medical attention.
SECTION II INGREDIENTS OF MIXTURES
SECTION VI REACTIVITY DATA
Principal Component(s) % TLV Units
Conditions to Avoid
Stability Unstable
Cobalt Chloride: (CAS No. 7646-79-9) 12.98% See Section V. Excessive temperature to cause evaporation.
Stable X
Water: (CAS No. 7732-18-5) 87.02% None established. Incompatibility
Strong oxidizers.
(Materials to Avoid)
WARNING! MAY BE HARMFUL IF SWALLOWED.
Hazardous Thermal decomposition or burning may produce cobalt oxide dust,
MAY CAUSE SKIN IRRITATION.
Decomposition Products hydrochloric acid or chlorine.
SECTION III PHYSICAL DATA
Conditions to Avoid
Hazardous Polymerization
Specific Gravity (H2O = 1)
Melting Point (掳F) Freezes approx. 0掳C (32掳F) Approx. 1.0
May Occur Will Not Occur Not applicable.
Percent Volatile
Boiling Point (掳F) Approx. 100掳C (212掳F) 87.02% X
by Volume (%)
Evaporation Rate
SECTION VII SPILL OR LEAK PROCEDURES
Vapor Pressure (mm Hg) 14 (water). Water Slightly less than 1.
=1)
(
Steps to be taken in case
Vapor Density (Air=1) 0.7 (water).
material is released or spilled Absorb spill in vermiculite, sand, earth, paper towel and place in a
Solubility in Water Complete. suitable container. Wash spill area with soap and water.
Clear, water white, water like liquid; no odor.
Appearance & Odor
Discharge, treatment, or disposal may be subject to Federal, State or Local laws.
Waste Disposal Method
SECTION IV FIRE AND EXPLOSION HAZARD DATA These disposal guidelines are intended for the disposal of catalog-size quantities only.
Lower
Flammable Limits in Air Upper
Flash Point
Dispose of in an approved chemical landfill or contract with a licensed waste
Non-flammable. NA
% by Volume
(Method Used)
disposal service.
Extinguisher
Use any media suitable for extinguishing supporting fire. SECTION VIII SPECIAL PROTECTION INFORMATION
Media
None needed in normal laboratory handling. If misty conditions prevail, work in
Respiration Protection
ventilation hood or wear a NIOSH/MSHA-approved respirator.
(Specify Type)
SPECIAL FIREFIGHTING
Local Exhaust Special
Not required. No.
PROCEDURES Ventilation Not required. No.
Mechanical (General) Other
If involved in fire situation, wear a NIOSH/MSHA-approved self-
Protective Gloves Eye Protection
Rubber. Chemical safety glasses.
contained breathing apparatus. Use flooding amounts of water in
early stages of fire.
Other Protective
Lab coat, apron, eye wash station, proper gloves.
Equipment
SECTION IX SPECIAL PRECAUTIONS
Precautions to be Taken
UNUSUAL FIRE AND in Handling & Storing Store in a cool place. Wash thoroughly after handling.
EXPLOSION HAZARDS Keep container tightly closed when not in use.
Read label on container before using. Do not wear contact lenses when working with chemicals.
In fire conditions resulting in the evaporation of the water of solution Other Precautions
hazardous decomposition products may be produced as dust or
Avoid contact with skin and eyes.
fume.
Remove and wash contaminated clothing.
For laboratory use only. Not for drug, food or household use. Keep out of reach of children.
Chemical Safety
Approved
Revision Date Michael Raszeja
No. 3 8/09/96 MR
Coordinator
D.O.T. NON-REGULATED. The information contained herein is furnished without warranty of any kind. Employers should use this information only as a supplement to other information
gathered by them and must make independent determinations of suitability and completeness of information from all sources to assure proper use of these
Approved by U.S. Department of Labor "essentially similar" to form OSHA-20 materials and the safety and health of employees. * Hazardous Materials Industrial Standards. Printed on recycled paper.
|