SECTION V HEALTH HAZARD DATA
MATERIAL SAFETY DATA SHEET EKH09719
Threshold Limited Value
ALDON 200 ppm, 8 hr TWA
1533 W.Henrietta Rd.
EKH09719
Avon, New York 14414 MSDS No.
庐
CORPORATION December 27, 1995
(716) 226-6177 Effective Date
Effects of Overexposure May be harmful in contact with skin or eyes. May cause irritation. May be
harmful by ingestion or inhalation. To the best of our knowledge, the
chemical, physical and toxicological properties have not been thoroughly
SECTION I NAME 24 HOUR EMERGENCY ASSISTANCE
investigated. Specific data is not available. Exercise appropriate
Product HEXADECYLTRIMETHYLAMMONIUM HYDROXIDE procedures to minimize potential hazards.
CHEMTREC Health 2
800-424-9300
Cetyltrimethylammonium Hydroxide
Chemical
Emergency and
Synonyms (25% in Methanol) EYES: Flush thoroughly with water for at least 15 minutes, lifting upper and
3
Fire
Day 716-226-6177
First Aid Procedures lower eyelids occasionally. Get immediate medical attention. SKIN: Flush
Formula C16H33N(CH3)3OH Reactivity 0 thoroughly with water, then wash with mild soap and water. INHALATION:
NFPA
Remove to fresh air. If not breathing, give artificial respiration. If breathing
HAZARD RATING HMIS *
Unit Size up to 180 Kg.
is difficult, give oxygen. Get medical attention. INGESTION: If swallowed,
LEAST SLIGHT MODERATE HIGH EXTREME
0 1 2 3 4 if conscious, give water to drink, induce vomiting and call physician. Never
C.A.S. No. 505-86-2
give anything by mouth to an unconscious person.
SECTION II INGREDIENTS OF MIXTURES
SECTION VI REACTIVITY DATA
Principal Component(s) % TLV Units
Conditions to Avoid
Unstable
Stability
Hexadecyltrimethylammonium Hydroxide 25% None established. Excessive light and heat. Sparks or flame.
Stable X
Contains: Methanol: (CAS No. 67-56-1) 75% None established. Incompatibility
Strong oxidizing agents.
(Materials to Avoid)
DANGER! FLAMMABLE! MAY BE HARMFUL IF INHALED,
Hazardous
SWALLOWED OR IN CONTACT WITH SKIN OR EYES. Carbon dioxide, carbon monoxide, oxides of nitrogen.
Decomposition Products
SECTION III PHYSICAL DATA
Conditions to Avoid
Hazardous Polymerization
Specific Gravity (H2O = 1)
Melting Point (掳F) Not applicable. 0.83
May Occur Will Not Occur Not applicable.
Percent Volatile
Boiling Point (掳F) 64掳C (147掳F) 75% X
by Volume (%)
Evaporation Rate
SECTION VII SPILL OR LEAK PROCEDURES
Vapor Pressure (mm Hg) 96 mm 2
=1)
(
Steps to be taken in case
Vapor Density (Air=1) 1.11 Eliminate ignition sources. Avoid eye or skin contact. Contain
material is released or spilled spill to minimize contaminated area. Cover with dry Lime or
Solubility in Water Complete. Soda ash, pick up, keep in a closed container and hold for
waste disposal.
Appearance & Odor Slightly yellow, clear liquid.
Discharge, treatment, or disposal may be subject to Federal, State or Local laws.
Waste Disposal Method
SECTION IV FIRE AND EXPLOSION HAZARD DATA These disposal guidelines are intended for the disposal of catalog-size quantities only.
Lower
Flammable Limits in Air Upper
Flash Point
Dispose of in an approved incinerator equipped with an afterburner and
% by Volume
(Method Used) 14掳C (57掳F) 5.5 36.
scrubber or contract with a licensed waste disposal system.
Use CO2 or dry chemical for small fires, alcohol-type aqueous film-forming foam or water
Extinguisher
SECTION VIII SPECIAL PROTECTION INFORMATION
Media spray for large fires.
Respiration Protection
Wear a NIOSH/MSHA approved respirator.
(Specify Type)
SPECIAL FIREFIGHTING
Recommended. No.
Local Exhaust Special
PROCEDURES Ventilation Recommended. No.
Mechanical (General) Other
Wear self-contained breathing apparatus (SCBA) and complete
protective equipment when potential for exposure to vapors or Eye Protection
Protective Gloves Rubber. Chemical safety goggles.
products of combustion exists. Water spray can be used to reduce
Other Protective
intensity of flames and to dilute spills to non-flammable mixture. Lab coat, apron, eye wash station, proper gloves, ventilation hood.
Equipment
SECTION IX SPECIAL PRECAUTIONS
(1993 EMERGENCY RESPONSE GUIDEBOOK, DOT P 5800.6, GUIDE PAGE NO. 28)
Precautions to be Taken
UNUSUAL FIRE AND Store in a cool, dry, dark place.
in Handling & Storing
EXPLOSION HAZARDS Wash thoroughly after handling.
Keep container tightly closed when not in use.
Read label on container before using. Do not wear contact lenses when working with chemicals.
FLAMMABLE LIQUID! Other Precautions
When heated to decomposition it emits toxic fumes of carbon
Avoid contact with skin, eyes and clothing. Avoid inhalation. Use
dioxide, carbon monoxide and oxides of nitrogen.
with adequate ventilation. Remove and wash contaminated clothing.
For laboratory use only. Not for drug, food or household use. Keep out of reach of children.
Chemical Safety
Approved
Revision Date
No. 2 12/27/95 Michael Raszeja MR
Coordinator
D.O.T. METHANOL, (SOLUTION), 3, UN 1230 The information contained herein is furnished without warranty of any kind. Employers should use this information only as a supplement to other information
gathered by them and must make independent determinations of suitability and completeness of information from all sources to assure proper use of these
Approved by U.S. Department of Labor "essentially similar" to form OSHA-20 materials and the safety and health of employees. * Hazardous Materials Industrial Standards. Printed on recycled paper.
|