PS-77
Material Safety Data Sheet
Issue Date: 5/13/05 Revision Date: 8/25/05 Supersedes: 8/25/05
Product Identification:
MEMBRANES, INC. INFORMATION:
2325 COUSTEAU COURT (612) 553-3300 (800) 328-3340
VISTA, CA 92081
(760) 727-3711 EMERGENCY PHONE NUMBERS:
For Chemical Emergency, Spill Leak Fire Exposure
or Accident - Call CHEMTREC Day or Night
DOMESTIC NORTH AMERICA 800-424-9300
INTERNATIONAL, CALL 703-527-3887 (collect calls
accepted)
NFPA Hazard Ratings
Health: (Blue) 2 Flammability: (Red) 0
Reactivity: (Yellow) 1 Special Hazards: Corrosive
EPA Reg. Number: 52252-4
Trade Name: Minncare庐 Cold Sterilant - AMI Model No. PS-77
Composition/ Information on Ingredients/ Hazard
Identification:
INGREDIENT CAS NO. PERCENT TLV PEL
HYDROGEN 7722-84-1 22.0% 1 PPM 1 PPM
PEROXIDE
PERACETIC ACID 79-21-0 4.5% N/E N/E
ACETIC ACID 64-19-7 --- 10 PPM 10 PPM
WATER 7732-18-5 --- N/E N/E
NOTE: N/E = NONE ESTABLISHED
TLV = THRESHOLD LIMIT VALVE
PEL = PERMISSABLE EXPOSURE LIMIT
First Aid Measures:
Symptoms of Exposure: Can cause burns to eyes, as evidenced by a
temporary whitening of the skin. Irritation to eyes
skin, and mucous membranes.
Carcinogenicity: Not listed as a cancer causing agent.
Page 1 of 3
Applied Membranes, Inc. assumes no liability for results obtained or damages incurred through the improper application of the above
information and data.
Revised 10/18/2005
PS-77 MSDS (continued)
Eyes and Skin: Flush eyes with excess water at least 15 minutes. If burn
or irritation has occurred, see physician immediately. If
clothing is contaminated, remove clothing, wash skin
and wash clothing before reusing.
Ingestion: If swallowed, drink large amounts of water. Do not
attempt to induce vomiting.
Fire Fighting Measures:
Flash Point: N/A
Flammable Limits: N/A
Extinguishing Media: Water, Foam, CO2, Dry Chemicals
Fire Fighting Procedures: Wear self-contained breathing appratus
and full protective equipment. Dilute with
large volume of water.
Unusual Fire and Explosion Hazards: N/D
Accidental Release Measures:
Spill Response: Wash down area thoroughly with water, mop thoroughly.
Do not use absorbent to soak up spill.
Waste Disposal: To be performed in compliance with all current local,
state and federal regulations. Do not contaminate water,
food, or feed. Waste resulting from the use of this
product may be disposed of on site by diluting in a
sanitary sewer or at an approved waste disposal facility.
Handling and Storage:
Handling and Storing: Keep container closed, but vented, when not in use.
Store in a cool, dry area (below 75掳F). Do not transfer
product from original container and once product has been
removed, do not return to original container.
Exposure Control/ Personal Protection:
Respiratory Protection: If air contamination is above permitted levels, use
suitable respiratory protection. Use local exhaust.
Page 2 of 3
Applied Membranes, Inc. assumes no liability for results obtained or damages incurred through the improper application of the above
information and data.
Revised 10/18/2005
PS-77 MSDS (continued)
Protective Covering: Protective gloves, either rubber or plastic, should be worn
to prevent skin contact. Glasses, goggles or face shield
should be worn at all times. Rubber apron and rubber
boots should be worn when handling product
Physical and Chemical Properties:
Boiling Point (掳C @ 760 mmHg): N/A
Melting Point (掳C): N/A
Vapor Pressure (mmHg): N/A
Vapor Density (AIR=1): N/A
Specific Gravity (H2O=1): 1.13
Evaporation Rate: N/A
Solubility In Water: Complete
pH as concentrate: 1.3
Appearance and Odor: Clear, Colorless Liquid, Pungent Odor
Stability and Reactivity:
Stability: Product is stable.
Conditions to Avoid: Hot storage (>75掳F).
Hazardous Polymerization: Will not occur.
Materials to Avoid: Heavy metals including iron, copper, copper alloys, brass,
and aluminum, salts, flammable organics, alkalis caustics
chlorine and formaldehyde.
Hazardous Decomposition: Oxygen and heat. Do not mix with chlorinated products
as this could liberate toxic corrosive chlorine gas.
Transport Information:
PROPER SHIPPING NAME: HYDROGEN PEROXIDE AND PEROXYACETIC ACID
MIXTURE, STABILIZED
Class: 5.1 (8)
UN #: 3149
Packing Group: II
Page 3 of 3
Applied Membranes, Inc. assumes no liability for results obtained or damages incurred through the improper application of the above
information and data.
Revised 10/18/2005
|