QUICKCABLE
Material Safety Data Sheet (MSDS)
Description: W\B Battery Protector-Silicone Part Number: 510410
SECTION I
Date: May 2006
Quick Cable Corporation
3700 Quick Drive
Franksville, WI 53126
Telephone: 1-800-558-8667
Emergency Telephone 1-800-468-1263(INFOTRAC) Quick Cable Product ID: 510410
SECTION II
HAZARDOUS INGREDIENTS/IDENTITY INFORMATION
Hazardous
Components CAS # ACGIH OSHA Range Average
Specific Percent by
TLV PEL
Chemical weight
Identity
Dimethyl Ether 115-10-6 1000 ppm N.E. 35.0% N.E
Polyalkyl, 7732-18-5 N.E N.E N.E N.E
Alkaryl Siloxane
Nitrous Acid 7632-00-0 180 mg/kg/rat 5500000
mg/m3/4H/R
SECTION III
PHYSICAL/CHEMICAL CHARACTERISTICS
Appearance and Odor: White, Ether Specific Gravity: 0.8323
Solubility in water: Complete Vapor Density: Is heavier than Air
Freezing Point: 32 Vapor Pressure: 55-65
Physical State: Aerosol
Boiling Point:-13 鈥? 212掳F
PH @ 100% : 9
Evaporation Rate: Is faster than Butyl Acetate
SECTION IV
FIRE AND EXPLOSION HAZARD DATA
Flash Point:-42掳F
Special fire fighting procedures: Remove Aerosol
Extinguishing Media: Alcohol Foam CO2 Dry Chemical
containers from fire area if possible. Use a self-contained
Water Fog
breathing apparatus for fire fighting and full protective gear.
Unusual fire and Explosion Conditions: Do not spray
near open flame, Flammable material Aerosol cans may explode if heated above 120掳F.
LEL: 3.4% UEL: 18.0%
DANGER: EXTREMELY FLAMMABLE
SECTION V
REACTIVITY DATA
Stability: Stable Hazardous Polymerization: No
Hazardous Decomposition Products: Oxides of carbon, oxides of nitrogen, and may produce forms of Chloride,
chlorine, and Phosgene
Materials to avoid: All sources of ignition, welding arcs, and open flames
Chemical Incompatibilities: Strong Acids, alkalis, oxidizers, and Amines
SECTION VI
HEALTH HAZARD DATA
Primary Route(s) of Entry: Inhalation, Skin, Harmful or Fatal if swallowed
Signs and symptoms of exposure: Inhalation: Headaches, dizziness, nausea, and anesthesia. Skin and
Eyes: May cause irritation/ drying. Ingestion: This Material May be harmful or fatal if swallowed. Corrosive
product may cause severe and permanent damage to mouth, throat, and stomach.
Chronic Overexposure: Dermatitis, Nervous system damage, Lung damage, kidney damage
Medical Conditions Generally aggravated by exposure: None Identified
Emergency and First Aid Procedures: (If symptoms persist, contact a physician)
Inhalation: Remove to fresh air, Give artificial respiration if needed, Call a physician
Ingestion: Do not induce vomiting, Call a physician
Eyes: Flush with Large amounts of water for 15 minutes
Skin: Remove contaminated clothing; wash area with soap and water
SECTION VII
PRECAUTIONS FOR SAFE HANDLING AND USE
Steps Taken in case material is released or spilled: Ventilate areas, Absorb with inert material and place in a
Chemical Waste container.
Waste Disposal Method: All used and unused product should be disposed of in conformance with local, state
and federal regulations.
Precautions to be taken in handling and storing: Store in a cool, dry area away from heat.
EXTREMELY FLAMMABLE. Keep from Freezing.
Other Precautions: Do not puncture or incinerate aerosol cans. Do not spray near fire or open flames.
SECTION VIII
CONTROL MEASURES
Respiratory Protection (Specific Type): Use NIOSH/MSHA complaint respirators or a self contained
breathing apparatus above exposure limits. Follow OSHA regulations 29 CFR1910.134.
Ventilation: Adequate to prevent accumulation of vapors and maintain levels below exposure limits.
Protective Clothing: Wear chemically protective gloves and safety glasses.
Eye and Face Protection: Safety glasses with side shields, Face shield.
Work Hygienic Practices: Good Personal hygiene and work practices are recommended.
SECTION IX
OTHER REGULATORY INFORMATION
HMIS
Health (Blue) 2
Flammability (Red) 4
Reactivity (Yellow) 0
SARA Title III: Section 311/312: Immediate Health Hazard, Fire Hazard, Pressurized Gas Hazard
Section 313: no components exist in this product
Extremely Hazardous substance: No
California Proposition 65: No proposition 65 chemicals exist in this product
Canadian WHMIS: No information available
This information is accurate to the best of Quick Cable Corporation鈥檚 knowledge or obtained from sources believed by Quick Cable to be
accurate. Before using any product, read all warnings and directions on the label.
|