QUICKCABLE
Material Safety Data Sheet (MSDS)
Description: Battery Cleaner Part Number: 510420
SECTION I
Emergency Telephone 1-800-468-1263(INFOTRAC)
Date: April 2006
Quick Cable Corporation
3700 Quick Drive Quick Cable Product ID: 510420
Franksville, WI 53126 Telephone: 1-800-558-8667
SECTION II
HAZARDOUS INGREDIENTS/IDENTITY INFORMATION
Hazardous Components Specific
Chemical Identity CAS # ACGIH OSHA Range Percent
Skin
by weight
TLV PEL
Propane/ Isobutane/N-Butane 68476-86-8 800ppm 800ppm Yes 15.0%
Triethanolamine 102-71-6 5mg/m3 N.E. No 5.0%
SECTION III
PHYSICAL/CHEMICAL CHARACTERISTICS
Appearance and Odor: Clear, Amine Specific Gravity: 0.9429
Solubility in water: Complete Vapor Density: Is heavier than air
Vapor Pressure: 30-40
Freezing Point: 32掳F
Physical State: Aerosol
Boiling Point: - 43 鈥? 651掳 F
PH @ 100%: N/A
Evaporation Rate: Is faster than Butyl Acetate
Coefficient of water/oil distribution: Complete
SECTION IV
FIRE AND EXPLOSION HAZARD DATA
Flash Point: -156掳F
Special fire fighting procedures: Containers can build up
Extinguishing Media: Alcohol Foam, CO2, Dry
pressure if exposed to heat (fire). As in any fire, wear self-
Chemical, Water Fog
contained breathing apparatus pressure-demand
Unusual fire and Explosion Conditions: 鈥淓mpty鈥?
(MSHA/NIOSH approved or equivalent) and full protective
containers retain product residue (liquid and/or Vapor)
gear.
and can be dangerous. DO NOT PRESSURIZE, CUT,
WELD, BRAZE, SOLDER, DRILL, GRIND, OR EXPOSE
LEL: 1.3% UEL: 10.0%
SUCH CONTAINERS TO HEAT, FLAME, SPARKS,
STAIC ELECTRICITY, OR OTHER SOURCESOF
IGNITION; THEY MAY EXPLODE AND CAUSE INJURY DANGER: EXTREMELY FLAMMABLE
OR DEATH.
SECTION V
REACTIVITY DATA
Stability: Stable under normal storage conditions
Conditions to avoid: All sources of ignition, Welding Arcs, and Open Flames
Hazardous Decomposition Products: Oxides of Carbon, Oxides of Nitrogen, and may produce forms of
Chloride, Chlorine, and Phosgene
Chemical Incompatibilities: Strong Acids, Alkalis, Oxidizers, and Amines
Hazardous Polymerization: Will not occur under normal storage conditions.
SECTION VI
HEALTH HAZARD DATA
Primary Route(s) of Entry: Skin Contact, Inhalation, ingestion, Eye Contact
Signs and symptoms of exposure: Skin Contact: Prolonged or repeated contact can result in defatting and drying of the
skin, which may result in skin irritation and Dermatitis (rash). Inhalation: Headaches, dizziness, nausea, decreased blood
pressure, changes in heart rate and cyanosis may result from over-exposure to vapor or skin exposure. Prolonged
inhalation may be harmful. Ingestion: This material may be harmful or fatal if swallowed. Eye Contact:Aerosols and
Vapors of this product are irritating and can cause pain, tearing, reddening and swelling accompanied by a stinging
sensation and/or feeling like that of a fine dust in the eyes.
Chronic Overexposure: Overexposure may cause nervous system damage.
Emergency and First Aid Procedures: (If systems persist contact a physician)
Eye Contact: Immediately flush eyes with plenty of water. Get medical attention if irritation persists.
Skin Contact: Immediately flush skin with plenty of water. Remove clothing. Get medical attention Immediately. Wash
clothing separate before reuse.
Inhalation: Remove to fresh air. If not breathing, give artificial respiration. If breathing is difficult give oxygen. Get
immediate medical attention.
Ingestion: Get Medical attention immediately. If swallowed, do NOT induce vomiting. Give victim a glass of water or milk.
Call a physician or poison control center immediately. Never give anything by mouth to an unconscious person.
SECTION VII
PRECAUTIONS FOR SAFE HANDLING AND USE
Steps Taken in case material is released or spilled: Absorb spill with inert material (e.g. dry sand or Earth), then place
in a chemical waste container. Avoid runoff into storm sewers and ditches, which lead to Waterways.
Waste Disposal Method: dispose in accordance with all Federal, State, and Local regulations.
Precautions to be taken in handling and storing:
Wash thoroughly after handling. Keep from freezing.
SECTION VIII
CONTROL MEASURES
Respiratory Protection (Specific Type): A NIOSH\MSHA approved air purifying resiprator with an organic
vapor cartridge or canister may be permissible under certain circumstances where airborne concentrations are
expected to exceed exposure limits. Protection provided by air purifying respirators is limited. Use a positive
pressure air supplied respiator if there is any potential for an uncontrolled release, exposure levels are not
known, or any other circumstances where air purifying respirators may not provide adequate protection.
Ventilation: Use only in a well ventilated area.
Protective Clothing: Standard industrial Clothing standards should be followed.
Eye and Face Protection: Wear safety glasses with side shield (or goggles) and other protective equipment.
Work Hygienic Practices: Wash hands before eating. Remove contaminated clothing and wash before
reuse. Use only in a well ventilated area. Follow all MSDS/label precautions even after the container is
emptied because they may retain product residues. Avoid prolonged or repeated contact with eyes, skin, and
clothing. Avoid breathing vapors from heated material. Avoid contact with eyes, skin, and clothing.
SECTION IX
OTHER REGULATORY INFORMATION
HMIS
Health (Blue) 1
Flammability (Red) 1
Reactivity (Yellow) 0
SARA Title III: Section 311/312: Immediate health Hazard, Chronic Health Hazard, Fire Hazard, Pressurized Gas Hazard
Section 313: 2-Butoxyethanol
California Proposition 65: No proposition 65 chemicals exist in this product.
Canadian WHMIS Class: This MSDS has been prepared in compliance with Controlled Product Regulations.
New Jersey / Pennsylvania Right-to-Know: The following Materials are non hazardous ingredients At greater than 3% and is among
the top five ingredients: WATER CAS# 7732-18-5 ; sodium Bicarbonate 144-55-8
This information is accurate to the best of Quick Cable Corporation鈥檚 knowledge or obtained from sources believed by Quick Cable to
be accurate. Before using any product, read all warnings and directions on the label.
|