SECTION II
HAZARDOUS INGREDIENTS/IDENTITY INFORMATION
Hazardous Components
Specific Chemical Identity OTHER Percent
CAS# ACGIH OSHA PEL
(Common Name(s)) LIMITS
TLV
Inhibited Paraffinic Oil Mixture 5mg/m3 5 mg/m3 (mist) 10-20 N/A
Microcrystalline Wax 8009-03-8 NE 5 mg/m3 NE 15-35%
Xylene 1330-20-7 100 ppm 100 ppm NE 1-10%
Petroleum Distillate 8052-41-3 NE NE 100 ppm 10-20%
Isohexanes 107-83-5 500 ppm 500 ppm NE 30-50%
n-Hexane 110-54-3 50 ppm NE <10 N/A
Heptane 142-82-5 400 ppm 400 ppm NE 1-10%
Ethylbenzene 100-41-4 100 ppm 100 ppm NE <2%
SECTION III
PHYSICAL/CHEMICAL CHARACTERISTICS
Appearance and odor: Red viscous liquid. Specific Gravity (H2O=1): .85
Solubility in Water: Negligible in Water Vapor Density (Air=1): >Air
Freezing Point: Not Determined Vapor Pressure (mm Hg): Not Determined
Boiling Point: 138掳F-144掳F *Approximate % Volatile: 78.4% g/L: 526 lbs./gal 4.38
Evaporation Rate: Not Applicable
SECTION IV
FIRE AND EXPLOSION HAZARD DATA
Flash Point (Method Used): <0掳F (TCC) Flammable
Extinguishing Media: Carbon Dioxide, Foam, and Dry Chemical LEL: 1.7 UEL: 9.0
Hazardous Combustion Products: Thermal-carbon monoxide
Unusual Fire and Explosion Hazards: Extremely Flammable. Contents under pressure.
Special Fire Fighting Procedures: Remove Aerosol containers from fire area if possible. Use a self-contained breathing apparatus for
fire fighting. Aerosol cans may explode if heated above 120掳F.
SECTION V
REACTIVITY DATA
Stability: Stable Chemical Incompatibilities: Strong oxidizers
Conditions to avoid: Do not store above 120掳F to prevent cans from exploding. Hazardous Polymerization: No
Hazardous Decomposition of By-products: None
Materials to avoid: Strong oxidizers
Long-term toxilogical studies have not been conducted for this product.
SECTION VI
HEALTH HAZARD DATA
Primary Route(s) of Entry: Inhalation, skin and eyes
Signs and Symptoms of Exposure: Inhalation: Headaches, dizziness, nausea and anesthesia. Skin and Eyes: May cause
irritation/drying. Ingestion: NA.
Chronic overexposure: Dermatitis
Medical Conditions Generally Aggravated by Exposure: Not applicable
Emergency and First Aid Procedures: (If symptoms persist, contact a physician)
Inhalation: Remove to fresh air, Give artificial respiration if necessary
Ingestion: Do not induce vomiting. Call a physician
Eyes: Flush with large amounts water for 15 minutes
Skin: Remove contaminated clothing and wash area with soap and water
SECTION VII
PRECAUTIONS FOR SAFE HANDLING AND USE
Steps taken in Case Material is Released or Spilled: Usually not a problem with aerosols. Area should be ventilated. Absorbent
should be used to pick up excess material.
Waste disposal Method: This material if discarded may be hazardous waste under U.S. EPA RCRA regulations. All disposal activities
must comply with federal, state and local regulations. Contact your local or state environmental agency for specific rules. Do not dump
into sewers, on the ground or into any body of water.
Precautions to be taken in Handling and Storing: Store in a cool, dry area. Aerosol cans must be maintained below 120掳F to prevent
cans from exploding.
SECTION VIII
CONTROL MEASURES
Respiratory Protection (Specific Type): Use NIOSH/MSHA compliant respirators or a self contained breathing apparatus above
exposure limits. Follow OSHA regulations 29 CFR 1910.134.
Ventilation: Adequate to prevent accumulation of vapors.
Protective Clothing: Wear chemically protective gloves and safety glasses. Use splash aprons and boots if splashing occurs.
Engineering Controls: Adequate to prevent accumulation of vapors. Use mechanical means if necessary to maintain levels below the
exposure limits. If working in a confined space, follow applicable OSHA regulations.
SECTION IX
OTHER REGULATORY INFORMATION
NFPA HMIS
Health (Blue) 2 2
Flammability (Red) 4 4
Reactivity (Yellow) 0 0
PPE: B
SARA Title III: Section 311/312: Acute, Pressure Section 313: n-Hexane, Xylene, Ethylbenzene *See Section 2 for percentage
California Prop 65: This product contains chemicals known to the state of California to cause cancer, birth defects and other
reproductive harm
CERCLA/Superfund (RQ): NA
TSCA: All components are either listed under TSCA or are exempt.
This information is accurate to the best of Quick Cable Corporation鈥檚 Knowledge or obtained from sources believed by
Quick Cable to be accurate. Before using this product, read all warnings and directions on the label.
ALL Chemical Property And Toxicity Analysis PAGES IN THIS GROUP