CL-1-1-409
H.M.I.S.
Health: 1
Material Safety Data Sheet Flammability: 1
Reactivity: 0
These ratings should be
used only as a part of
a fully implemented
Section I - Product Identication H.M.I.S. program.
Trade Name and Synonyms Part Numbers:
ChampLub P08907A, P08908A, P08909A, P09479A
Manufacturer鈥檚 Name
Champion
Health Emergency Phone Number
Address
(217) 222-5400
1301 North Euclid Ave., Princeton, IL 61356
Safety Department
Product Identification
Hydrocarbon Reciprocating Compressor Oil
Chemical Names and Synonyms
Petroleum Hydrocarbon
Section II - Typical Chemical and Physical Properties
Amber to Light Liquid Nil
Appearance: % Vol by Vol:
>300掳F Negligibly
Boiling Point: Soluble in Water:
ND > Air
Melting Point: Vapor Density:
0.88 (approx.) NA
Specific Gravity: Evaporation Rate:
** Vapor Density of Air is = 1 **
** Evaporation Rate of Butyl Acetate is = 1 **
Section III - Composition/Information of Ingredients
COMPOSITION CASE # % PEL
P: Industrial Oil Mixture 100 5 mg/CUM
1: Solv. Ref. Hvy. Parraffin Oil 64742-54-7 5 mg/CUM
2: Lt. Napth. Hydrotreated Dist. 64742-53-6 5 mg/CUM
3: Hvy. Napth. Hydrotreated Dist. 64742-67-7 5 mg/CUM
4: Deasphalted Residium 64742-95-3 5 mg/CUM
5: Solv. Ref. Sat. Parraffin Dist. 64742-65-0 5 mg/CUM (as mist)
Section IV - HMIS Hazard Rating
Least 0 Health 1
Slight 1 Fire 1
Moderate 2 Reactivituy 0
High 3 Other 0
Extreme 4 Personal Protection B
Section V - Hazards Identification
Acute Health No Reactivity No
Chronic Health No Fire No
** See Section XII for Complete Health Hazard Information **
Section VI - Emergency and First Aid Procedures
As with most foreign materials, if eye contact should occur, flush eyes with plenty of water. If
Eye Contact:
irritation occurs, get medical attention.
Wash exposed skin with soap and water. Remove contaminated clothing and wash before
Skin Contact:
reuse.
Remove exposed person to fresh air if adverse effects are observed.
Inhalation:
Ingestion: DO NOT INDUCE VOMITING. Get medical attention.
CL-1-1-409
Section VII - Fire Fighting Measures
Flash Point: Flammable Limits:
257掳C 500掳F UPPER: NE LOWER: NE
Auto Ignition (Fire Point):
>680掳F
Extinquishing Media:
Use water fog, foam, dry chemical of CO2. Do not use a direct stream of water. Material will float on water surface
and can re-ignite on the surface of the water.
Special Fire Fighting Procedures:
Do not enter confined fire-space without full bunker gear, including positive pressure SCBA. Cool fire exposed
containers with water.
Unusual Fire and Explosion Hazards:
None
Section VIII - Reactivity Data
Stability: Conditions and Material to Avoid:
Stable Avoid heat, open flames and strong oxidizers.
Hazardous Decomposition Products:
Thermal decomposition products are highly dependent on the combusion process. By-products of combustion may
include: Oxides of carbon, boron, nitrogen, sulfur, phosphorus, zinc, calcium, and/or magnesium.
Hazardous Polymerization:
Will not occur.
Section IX - Spill or Leak Procedure
Procedures if Material is Released or Spilled:
Remove all sources of ignition. Small spills may be absorbed with inert material as sand, clay, vermiculite, etc.
Large spills should be diked to prevent entry to sewers or waterways. Large spills may be picked up with a vacuum
truck, shovels, or other appropriate means and placed in salvage drums or other suitable containers.
Section X - Special Protection Information
Eye Protection:
Chemical goggles.
Skin Protection:
Long sleeve shirt is recommended. Nitrile gloves.
Respiratory Protection:
If the recommended exposure limit is exceeded, use respirator with organic vapor & dust/mist cartridges.
Ventilation:
Sufficient mechanical (general) and/or local exhaust ventilation to maintain exposure below PEL.
Section XI - Special Precautions
Handling:
Keep containers closed when not in use. Empty container contains product residue and may exhibit hazards of
product.
Storage:
Store in a cool, dry, well ventilated area.
Section XII - Toxicological Data
Ingestion:
LD 50 in rats > 5000 mg/Kg; Practically non-toxic.
Inhalation:
Oil mist may cause respiratory irritation.
Eye Irritation:
Mild eye irritant.
Skin Irritation:
Not expected to be a primary skin irritant.
Carcinogenicy:
Not a known carcinogen.
CL-1-1-409
CL-1-1-409
Section XIII - Ecological Information
Freshwater Fish Toxicity: Test program is in progress.
Freshwater Invertebrates Toxicity: Test program is in progress.
Saltwater Fish Toxicity: NE
Saltwater Invertebrates Toxicity: NE
Bacterial Toxicity: Test program is in progress.
Miscellaneous Toxicity: NE
Miscellaneous Environmental Fate: Test program for biodegradation is in progress.
Section XIV - Disposal Considerations
Dispose of in compliance with all federal, state, and local laws.
Section XV - Transportation Information
DOT Classification: Non-hazardous.
Proper Shipping Name: NA
Section XVI - Regulatory Information
The components of this product are listed on the TSCA inventory of chemical substances.
Section XVII - Other Information
Always wash hands and face before eating, drinking, or smoking.
The information contained herein is based on data available to us and is believed to be correct. However, Champion
makes no warranty expressed or implied regarding the accuracy of these data or the results to be obtained from the use
thereof. Champion assumes no responsibility for injury from the use of the product described herein.
NOTE: Not a controlled product under Canadian WHMIS Hazard Criteria; as specified in Controlled Product Regulation.
CL-1-1-409
October 2002
|