H.M.I.S.
Health: 0
Flammability: 1
Reactivity: 0
Material Safety Data Sheet These ratings should be
used only as a part of a fully
implemented H.M.I.S.
Section I - Product Identification program.
Trade Name and Synonyms Part Numbers:
AEON-PD-FG Health Emergency Phone Number
28H97, 28H98, 28H99, and 28H100
(217) 222-5400
Manufacturer鈥檚 Name
Gardner Denver, Inc. Safety Department
Address
100 Gardner Park Peachtree City, GA 30269
Transport Emergency Phone Number
Product Identification
Positive Displacement Blower Lubricant 鈥? Food Grade (800) 424-9300 (CHEMTREC)
Chemical Names and Synonyms Use or Description
Polyalphaolefin (Synthetic Hydrocarbon)
Section II - Components and Hazard Statement
Hazardous Ingredients:
None (This product contains no known carcinogens. No special warning labels are required under OSHA 29 CFR 1910.1200.)
WHMIS (Canada): Not a controlled product under Canadian WHMIS Hazard Criteria; as specified in Controlled Product Regulation.
FDA Statement:
This product complies with FDA 21 CFR 178.3570 regarding lubricants for incidental food contact.
Section III - Safe Handling and Storage
Handling:
Do not take internally. Avoid contact with skin, eyes, and clothing. Upon contact with skin, wash with soap and water.
Flush eyes with water for 15 minutes and consult physician. Wash contaminated clothing before reuse.
Storage:
Keep container tightly sealed when not in use.
Section IV - Physical Data
Clear liquid, light yellow to light brown tint Formula: C10nH20n+2
Appearance:
None
Odor: CAS#: Proprietary
Relative Density 15/4 C: Insoluble
Solubility in Water:
N/A
Melting Point F(C): 0.79-0.87
Specific Gravity (water=1):
>300掳F
Boiling Point F(C): 0%
Volatiles, Percent by Volume:
Nil
<0.01 mmHg @ 20掳C
Vapor Pressure: Evaporation Rate (butyl acetate=1):
NA=Not Applicable NE=Not Established D=Decomposes
Section V - Fire and Explosion Hazard Data
Flash Point (by Cleveland Open Cup): Flammable Limits:
o
535 F Not Established
Extinguishing Media: Autoignition Temperature:
Dry chemical; CO2 foam, water spray (fog) No Data
Special Fire Fighting Techniques:
Burning fluid may evolve irritating/noxious fumes. Firefighters should use NIOSH/MNSA-approved self-contained
breathing apparatus. Use water to cool fire-exposed containers. Use water carefully near exposed liquid to avoid frothing
and splashing of hot liquid.
Unusual Fire and Explosion Hazards:
None
HMIS Ratings: Health: 0 Flammability: 1 Reactivity: 0
NFPA Ratings: Not Established
AEON-PD-FG
Section VI - Reactivity Data
Stability (Thermal, Light, Etc.): Conditions to Avoid:
Stable Excessive Heat
Incompatibility (Materials to Avoid):
Strong Oxidizers
Hazardous Decomposition Products:
Analogous compounds evolve carbon monoxide, carbon dioxide, and other unidentified fragments when burned. See
Section 5.
Hazardous Polymerization:
Will not occur.
Section VII - Health Hazard Data
Threshold Limit Value:
3
3
Observed current ACGIH TLV of 5 mg/m for base fluid mist.
5mg/m ACGIH
Avoid breathing oil mists.
Situations to Avoid:
Emergency and First Aid procedures:
Product is not toxic by inhalation. If oil mist is inhaled, remove to fresh air and consult
Inhalation:
physician.
Ingestion: Consult physician at once. DO NOT INDUCE VOMITING. May cause nausea and
diarrhea.
TO THE BEST OF OUR KNOWLEDGE, THE TOXICITY OF THIS PRODUCT HAS NOT BEEN FULLY INVESTIGATED.
ANALOGOUS COMPOUNDS ARE CONSIDERED TO BE ESSENTIALLY NON-TOXIC.
Section VIII - Personal Protection Information
Eye/Face Protection:
Goggles
Protective Gloves:
Not required, but recommended, especially for prolonged exposure.
Respiratory Protection:
Use in well ventilated area.
Ventilation:
Local exhaust.
Section IX - Spill or Leak Procedure
In Case of Spill:
Wear suitable protective equipment, especially goggles. Stop source of spill. Dike spill area. Use absorbent materials to
soak up fluid (i.e., sand, sawdust and, commercially available materials). Wash spill area with large amounts of water.
Properly dispose of all materials.
Section X - Waste Disposal Method
Incinerate this product and all associated wastes in a licensed facility in accordance with Federal, State and local
regulations.
May 2000 BK-29 Version 01
|