H.M.I.S.
Health: 0
Flammability: 1
Material Safety Data Sheet Reactivity: 0
These ratings should be
used only as a part of a
fully implemented H.M.I.S.
program.
Section I - Product Identification
Trade Name and Synonyms Part Numbers:
P12909A,P12910A,28H164,28H165
RotorLub 8000 Health Emergency Phone Number
(815) 875-3321
Manufacturer鈥檚 Name
Champion Safety Department
Address
1301 North Euclid Avenue, Princeton, IL 61356
Transport Emergency Phone Number
Product Identification
Rotary Screw Compressor Lubricant and Coolant (800) 424-9300 (CHEMTREC)
Chemical Names and Synonyms
Synthetic Hydrocarbon/Carboxylic Acid Type Ester
Section II - Transportation (NR - Not Regulated by TDG)
UN Number: NR Primary Classification: NR Subsidiary Classification: NF Compatibility Groups: NR
Section III - Composition
COMPONENTS ALLOWABLE LIMITS (8 Hr.) % (Vol.) CAS #
3
Synthetic Hydrocarbon/MFSE 5 mg/m >98 68037-01-4 (PAO)
Defoamer, Antioxidants, Rust Inhibitors, Dye N/A <2 N/A
Section IV - Physical Data
Density (at 15掳C): Boiling Point/Range (at 1 atm):
0.86 kg/L >300掳F
Vapor Pressure (at 20掳C): <1.0 mmHg Percent Volatile (at 20掳C) 0%
Vapor Density (at 20掳C): Evaporation Rate: N/A
N/A
Solubility in Water: Insoluble Pour Point: -65掳F (-54掳C)
Section V - Fire and Explosion Hazard Data
Flash Point (method used = COC): Flammable Limits in Air (% by volume):
500掳F (260掳C) (minimum) N/A
Extinguishing Media: Autoignition Temperature:
Dry chemical; CO2 foam, water spray, carbon dioxide for small fires. >670掳F (>354掳C)
Fire and Explosion Hazards:
Addition of water or foam to burning liquid may cause frothing. Do not cut, drill, or weld empty containers.
Fire Fighting Techniques:
LOW FIRE HAZARD. Contain spill. Cover with extinguishing agent. Use water spray to cool fire-exposed containers and
as a protective screen. Do not point solid water stream directly into burning oil to avoid spreading.
Section VI - Health Hazard Information
Toxicity Data: * Estimated acute LD50>5000 mg/kg (rat. Oral): practically non-toxic. Severely
hydrotreated base oils are negative when tested by the modified Ames test.
Effects of Overexposure:
Inhalation: Product is not toxic by inhalation. If oil mist is inhaled, remove to fresh air and consult
physician.
Skin and eyes: Mildly irritating to eyes. Prolonged or repeated contact with skin may cause mild
irritation and possibly dermatitis.
Ingestion: Consult physician at once. DO NOT INDUCE VOMITING. May cause nausea and
diarrhea.
* Based on toxicity of severely hydrotreated paraffinic oil only.
Emergency and First Aid Procedure Information:
Skin: Remove contaminated clothing - launder before reuse. Soap and water wash.
Discard saturated leather articles.
Eyes: Copious warm water flush - 15 minutes. Physician assessment if eyes inflamed.
Inhalation: Evacuate to fresh air. Apply Cardiopulmonary Resuscitation if required. Administer
oxygen if available. If resuscitation is required, physician assessment mandatory.
Ingestion: DO NOT INDUCE VOMITING. Force fluids. Activated charcoal tablets.
Notes to Physician: Gastric lavage should only be done after endotracheal intubation in view of the
risk of aspiration which can cause serious chemical pneumonitis for which
antibiotic and corticosteroid therapy may be indicated.
Section VII - Reactivity Data
Stability: Conditions to Avoid:
Stable Excessive Heat
Materials to Avoid:
Strong Oxidizing Agents (peroxides, chlorine, strong acids, etc.)
Hazardous Decomposition Products:
Analogous compounds evolve carbon monoxide, carbon dioxide, and other unidentified fragments when burned.
Hazardous Polymerization:
Will not occur.
Section VIII - Spill or Leak Procedure
Steps to be Taken If Material is Released or Spilled:
Contain spill. Absorb with inert absorbent such as dry clay, sand, or diatomaceous earth, commercial sorbents, or
recover using pumps. Scoop up used absorbent and rags into drums.
Waste Disposal Method:
Dispose in approved landfill site or licensed waste reclaimer facility.
Section IX - Special Protection Information
Ventilation: General ventilation.
Respirator Protection: Use in well ventilated area.
Protective Gloves: Not required, but recommended, especially for prolonged exposure.
Eye Protection: None normally required: chemical goggles if splashing likely or high-pressure system used.
Other Protective Clothing: Oil-resistant clothing if direct contact with liquid likely.
Section X - Special Precautions
Store in cool, well-ventilated area. Wash hands after handling and before eating. Avoid inhalation and skin contact. Launder
work clothes frequently. Discard saturated leather articles.
NOTE: Not a controlled product under Canadian WHMIS Hazard Criteria; as specified in Controlled Product Regulation.
AEON Lubricants are not formulated to contain PCBS.
Prepared by the Product Specialist, Aftermarket
September 2002
|