Material Safety Data Sheet
Aluminator 鈥? Aluminum Oxide Remover
Product Hazard: Health: 2 Fire: 0 Toxicity: 0 Reactivity: 1 Special: 0
Hazard Rating: 4 = Deadly 3 = Extreme 2 = Hazardous 1= Slight Hazard 0 = Normal
1. IDENTIFICATION OF THE SUBSTANCE/PREPARATION AND THE COMPANY/UNDERTAKING 01/10/08
Aluminator 鈥? Aluminum Oxide Remover
Product Name:
Manufacturer/Supplier: Orison Marketing, L.L.C. (Cage Code: 1GZV7)
4801 South Danville Drive
Abilene, TX 79602
Emergency Telephone Number: (325) 692-1135 or 800-460-2403 (in the U.S.)
2. INGREDIENTS
Chemical Name: CAS# OSHA PEL TLV WT%
Phosphoric Acid 7664-38-2 1mg/m3 1mg/m3 <5
*These chemicals are subject to reporting requirements off section 313 of the Emergency Planning and Right-To-Know Act of 1986 and of
40 CFR 372.
3. HAZARDS IDENTIFICATION
Carcinogen: NA NTP: NA IARC Monograph: NA OSHA: NA
Primary Routes of Entry: Eye 鈥? Yes Ingestion 鈥? Yes Inhalation 鈥? Yes Skin - Yes
Effects of overexposure: Eye 鈥? eye irritant, will burn eyes
Ingestion 鈥? nausea
Inhalation 鈥? Prolonged exposure to fumes can burn mucous membranes
Skin 鈥? mild burning of skin
Most Important Hazards: None
Specific Hazards: Corrosive inhalation toxic 鈥? mild burning of skin, will burn eyes and mucous membranes. No chronic effects
expected with use of this product.
4. FIRST AID MEASURES
General Advice: Practice good hygiene and use in well ventilated area.
Inhalation: Remove to fresh air. If symptoms persist, consult physician.
Skin Contact: Neutralize with mild soap and water on skin areas.
Eye Contact: Rinse thoroughly with plenty of water. If symptoms persist, consult physician.
Ingestion: If swallowed give victim two glasses of water or milk and DO NOT INDUCE
VOMITING. Get immediate attention if breathing has stopped. Do not give anything
by mouth to an unconscious person.
5. FIRE-FIGHTING MEASURES
Suitable Extinguishing Media: Water, Dry chemical, CO2
Special Fire Fighting Procedures: Wear SCBA & all protective equipment
Specific Hazards: Corrosive
Flash Point: None
6. ACCIDENTAL RELEASE MEASURES
Personal Precautions: See section 8. Caution floor may be slippery.
Environmental Precautions: Corrosive.
Methods for Cleaning Up: Neutralize with soda ash and dispose of according to local, state or federal
regulations..
www.orisonllc.com * info@orisonllc.com * Cage Code: 1GZV7 * 800.460.2403
SAFETY DATA SHEET Page: 2 of 2
PRODUCT: ALUMINATOR 鈥? Aluminum Oxide Remover Revision Date: 01/10/08
7. HANDLING AND STORAGE
Corrosivity: Corrosive.
Technical Measures/Precautions: Normal ventilation is adequate.
Safe Handling Advice: Avoid contact with eyes and skin.
Technical Measures/Storage Conditions: Low temperature can cause handling problems. Viscosity of material will increase.
Incompatible Products: Avoid storing near oxidizers, bleach, or strong acids
Packaging Material: Store in tightly sealed containers in a cool, dry place.
8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Engineering Measures: General room ventilation is satisfactory.
Control Parameters: None needed.
Personal Protection Equipment
Respiratory: None required.
Eye: Safety glasses, face shield, or goggles
Hand: Plastic or rubber gloves, plastic or rubber apron
Hygiene Measures: Employ good hygiene measures.
9. PHYSICAL AND CHEMICAL PROPERTIES
Form: Water viscous liquid Color: Clear light purple
Odor: Characteristic odor pH: 3 - 4
Boiling Point/Range: 212掳 F Volatile Organic Compounds: None measurable
Freezing Point: 32掳F/0掳C Viscosity @ 25掳C: same as water
Flash Point: None to boiling Explosive Properties: None
Evaporation Rate: >1 ether=1 (same as water) Water Solubility: Complete
Vapor Pressure: Not determined Vapor Density: NA air =1
Evaporation Rate: >1 ether=1 (same as water) Specific Gravity: 1.018
10. STABILITY AND REACTIVITY
Stability: Stable
Conditions to Avoid: None known
Materials to Avoid: Avoid contact with strong oxidizing agents and high alkalines. Reaction of the
material with active metals like aluminum, zinc, iron, etc. can liberate hydrogen.
Hazardous Decomposition Products: Phosphorus oxides
Hazardous Polymerization: Will not occur
11. TOXICOLOGICAL INFORMATION
Acute Toxicity: None known
Local Effects: None known.
Specific Effects: None known.
12. ECOLOGICAL INFORMATION
No information found.
13. DISPOSAL CONSIDERATIONS
Neutralize with soda ash and dispose of according to local, state or federal regulations. Treat material as waste from material cleaned in product.
Contaminated Packaging: If recycling is not practicable, dispose of in compliance with the Environmental Protection (Duty of Care)
Regulations 1991 if contaminated with hazardous materials.
14. TRANSPORTATION INFORMATION
DOT: No special requirement or permission needed for shipping by ground transportation as per 49 CFR 173.154
15. REGULATORY INFORMATION
Chemical Name: CAS# OSHA PEL TLV WT%
Phosphoric Acid 7664-38-2 1mg/m3 1mg/m3 <5
16. OTHER INFORMATION
For further information, contact the Headquarters of Orison Marketing, L.L.C.
Recommended Use: Aluminum Oxide Remover
The information provided in this Safety Data Sheet is correct to the best of our knowledge, information and belief at the date of its publication. The information given is
designed only as a guidance for safe handling, use, processing, storage, transportation, disposal and release and is not to be considered a warranty or quality specification.
The information relates only to the specific material designated and is not valid for such material used in combination with any other materials or in any process, unless
specified in the text.
www.orisonllc.com * info@orisonllc.com * Cage Code: 1GZV7 * 800.460.2403
|