MATERIAL SAFETY DATA SHEET
SAFE-LUBE庐
PRODUCT: NFPA Rating Rating
BIO Forming Fluid HD 0 - Insignificant 0 - Flammability
1 - Slight 1 - Health
2 - Moderate 0 - Reactivity
3 - High
4 - Extreme
SECTION I: SUPPLIER AND LOCATION
Manufacturer: Gemtek Products
Supplier: Orison Marketing, L.L.C. Telephone: 325-692-1135
Location: 4801 South Danville Dr. Facsimile: 325-690-0569
Abilene, TX 79602 E-Mail: info@orisonllc.com
SECTION II: MATERIAL IDENTIFICATION AND INFORMATION
TLV/PEL (mg/m3_)
Component CAS Number Volume %
No regulated components
The specific chemical names and composition of the components not disclosed is confidential business information and is withheld as
permitted by 29CFR 1910.1200 and various state Right-to-Know laws.
This material is not known to contain any chemical listed as a carcinogen or suspected carcinogen by OSHA Hazard Communication Standard
29CFR 1910.1200, IARC, or the National Toxicology Program (NTP) at a concentration greater than 0.1%.
This product does not contain as an ingredient chlorine, phenols, nitrites, heavy metals, arsenic, PCB, PCT, TCDD or other Dioxin related
substances.
SECTION III: PHYSICAL AND CHEMICAL PROPERTIES
Chemical Family:Aqueous Botanical Metalworking Fluid Form: Straw/Amber liquid
Odor: Mild Specific Gravity (Water = 1.00): 1.01
Melting Point: NE Boiling Point: 212F
Volatility, weight % at 25掳C: NE Evaporation Rate: <1 (water=1)
Solubility in Water: Soluble Stability: Stableundernormalconditions
SECTION IV: FIRE AND EXPLOSION DATA
Flashpoint (Cleveland Open Cup): > None (Aqueous) Autoignition Temperature: NE
Flammable Limits: NA
Fire Extinguishing Agents: If water evaporates, dry chemical, foam,or CO2. Water stream may splash burning
liquid and spread fire.
Special Fire Fighting Procedure: As for petroleum products. Do not use direct or heavy water stream to fight fire.
Use self-contained breathing apparatus to fight fire.
SAFE-LUBE - BIO Forming Fluid HD Page Two
SECTION V: FIRST AID
Contact with Eyes: May cause mild irritation. Immediately flush with large quantities of cool water for at least 15
minutes. If symptoms persist, get medical attention.
Contact with Skin: May cause mild irritation, including dryness. Wash off with soap and water. If symptoms persist,
get medical attention.
Inhalation: Expected to have low degree of toxicity. Remove to fresh air. If not breathing, give artificial
respiration. Get medical attention:
Ingestion: No harmful effects reported. Do not induce vomiting. Contact a physician.
SECTION VI: REACTIVITY
Reactivity: Stable under normal temperatures and pressures.
Incompatibilities: Strong oxidizing agents.
Conditions to Avoid: Nitrosating Agents.
Hazardous Polymerization: Will not occur.
Hazardous Decomposition Products: Oxides of carbon.
SECTION VII: SPECIAL PROTECTION INFORMATION
Ventilation: Local exhaust to keep vapor concentrations below the TLV limit.
Respiratory Protection: None required in normal use. Use only NIOSH/MSHA approved equipment if necessary.
Gloves: Not required in normal use.
Eye Protection: Goggles or safety glasses are recommended. (Policy decision)
Other Protective Equipment: Practice good personal hygiene. Wash hands after use and handling.
SECTION VIII: ENVIRONMENTAL PROCEDURES
Clean-Up of Spills: Contain any spills with dikes or absorbent to prevent migration and entry into sewers and waterways. Take up
small spills with dry chemical absorbent. Large spills may be taken up with pump or vacuum and finished off with
dry chemical absorbent.
Waste Disposal: To the best of our knowledge, this product is not regulated by CERCLA/RCRA as a hazardous waste or material.
However, this product has not been tested for the toxicity characteristic via the Toxicity Characteristic Leaching
Procedure. Therefore,, it may be disposed of as an industrial waste in a manner acceptable to good waste
management practice and in compliance with all applicable federal, state and local regulations.
Right-to-Know: There is no requirement to report this product under existing SARA Title III regulations.
TSCA: This material is in compliance with the Toxic Substances Control Act (15 USC 2601 - 2629).
SECTION IX: STORAGE AND HANDLING
Keep containers sealed until ready for use. Avoid freezing temperatures. Avoid excessive long -term storage temperatures to prolong shelf life.
Maximum storage temperature: 120掳F. Store in well ventilated areas.
SECTION X: TRANSPORT
D.O.T. Shipping Name/I.D.No.: Not regulated as hazardous material Freight Classification:
Reportable Quantity: NA Special Transport Notes: None
Orison Marketing, L.L.C. believes that the information and recommendations contained herein (including data and statements) are accurate as
of the date hereof. No warranty of fitness, warranty of merchantability or any other warranty, expressed or implied, is made concerning the
information provided herein. The information provided herein relates only to the specific product designated and may not be valid where such
product is used in combination with any other materials or in any process. Further, since the conditions and methods of use of the product and of the
information referred to herein are beyond the control of Orison Marketing, L.L.C.., Orison Marketing, L.L.C. expressly disclaims any and all liability
as to any results obtained or arising from any use of the product or reliance on such information.
Revision Date: 02/03/05
|